Specifications

ManualsBrandsAPW Wyott ManualsGriddle-48H

MANUFACTURED

EXCLUSIVELY

FOR

McDONALD'S

729 THIRD AVENUE

DALLAS, TEXAS 75226

(214) 421-7366

FAX (214) 565-0976

APW WYOTT

TABLE OF CONTENTS

GENERAL INFORMATION AND TROUBLESHOOTING

HORIZONTAL RADIANT CONVEYOR TOASTER

BT-15 SERIES

Electrical Specifications

Installation

Operating Instructions

Troubleshooting Guide

Wiring Diagram

Warranty

Page 2

Page 3

Page 6

Page 7

Page 8

Cleaning & Maintenance

Parts List w/Exploded View

Page 3

Page 4-5

INSTALLATION AND OPERATION INSTRUCTIONS

WARRANTY POLICY & PROCEDURES

SERVICE CENTER DIRECTORY FOR

BT-15 SERIES

HORIZONTAL RADIANT CONVEYOR TOASTER

ona

ld’

Summary of content (8 pages)

PAGE 1
INSTALLATION AND OPERATION INSTRUCTIONS WARRANTY POLICY & PROCEDURES SERVICE CENTER DIRECTORY FOR BT-15 SERIES HORIZONTAL RADIANT CONVEYOR TOASTER McDonald’s R MANUFACTURED EXCLUSIVELY FOR McDONALD'S R BY APW WYOTT FOODSERVICE EQUIPMENT COMPANY 729 THIRD AVENUE DALLAS, TEXAS 75226 (214) 421-7366 FAX (214) 565-0976 TABLE OF CONTENTS GENERAL INFORMATION AND TROUBLESHOOTING Page 2 HORIZONTAL RADIANT CONVEYOR TOASTER BT-15 SERIES Page 2 Electrical Specifications Page 2 Installation Page 2 Operating
PAGE 2
GENERAL INFORMATION Model Number Overall Dimensions Electrical GENERAL INSTALLATION 1. Always clean equipment thoroughly before first use. (See general cleaning instructions.) 2. Check rating label for your model designation & electrical rating. 3. Locate equipment on level counter and plug into a grounded outlet so that the plug is accessible. (See individual description for electrical loads.) 4.
PAGE 3
b. Temperature: TOP HEAT - The MIN. setting will help produce the lightest- top toast The MAX. setting will help produce the darkest toast. BOTTOM HEAT - The MIN. setting will help produce the lightest bottom - toast. The MAX. setting will help produce the darkest bottom toast. Off turns the heating elements off. C. INSTALLATION 1. Place the toaster on approved toaster table and insure that the unit's vents are not blocked.
PAGE 4
BT-15 CONVEYOR TOASTER MCD's 05/21/2004 CONTROL PANEL CENTER TOP PANEL FAN GUARD WASHER ELEMENT TOP 69V, (208V)9E, 300W ELEMENT TOP 80V, (240V) 9E, 300W TOP WIRE GUARD ADAPTER BUTTER PAN BRACKET THERMOSTAT 345°F ELEMENT RACK ASSEMBLY FRONT SHAFT 69104-EGO 83222 REFLECTOR, CRUMB TRAY BREAD SLIDE BREAD DRAWER TRAY ELEMENT 208V, 1400W BOTTOM ELEMENT 240V, 1400W BOTTOM DRIVE MOTOR, 240V, 60Hz, 208V DRIVE MOTOR 230V, 50Hz TOP INFINITE CONTROL, 240V TOP INFINITE CONTROL, 208V KNOB, INFINITE CONTROL TOGGLE MA
PAGE 5
37 28 32 18 19 12 43 44 36 26 3 2 24 38 45 41 34 16 50 40 5 52 17 39 30 46 22 8 1 7 51 33 23 21 42 29 20 47 13 9 25 11 48 15 35 10 5 6 31 14 4 27 49
PAGE 6
D. CONVEYOR TOASTER TROUBLE-SHOOTING GUIDE THE PROBLEM THE CAUSE THE SOLUTION Won't toast ................................,....... a. Wrong control setting. a. b. Wrong selector switch position. Check control settings, and allow 20 min. for warm up. c. Wrong speed setting. b. Check recommended position. d. Excessive cupping of bread c. Check control setting and reduce e. Product is too moist. d. Use fresher bread. Get better a. Only part of bun surface is a.
PAGE 7
PAGE 8
APW WYOTT EQUIPMENT LIMITED WARRANTY APW Wyott Foodservice Equipment Company warrants it's equipment against defects in materials and workmanship, subject to the following: This warranty applies to the original owner only and is not assignable. Should product fail to function in its intended manner under normal use within the limits defined in this warranty, at the option ofAPW Wyott such product will be repaired or replaced byAPWWyott or itsAuthorized ServiceAgency.