Fastrac Horizontal Conveyor Toaster Installation and Operating Instructions

ManualsBrandsAPW Wyott ManualsToasterFT 800H

Phone: +1 (214) 421-7366

Fax: +1 (214) 565-0976

Toll Free: +1 (800) 527-2100

Website: www.apwwyott.com

E-mail: info@apwwyott.com

INSTALLATION

AND

OPERATING

INSTRUCTIONS

INTENDED FOR OTHER THAN HOUSEHOLD USE

Model: FT 800H

RETAIN THIS MANUAL FOR FUTURE REFERENCE

UNIT MUST BE KEPT CLEAR OF COMBUSTIBLES AT ALL TIMES

P/N 67191 9/06

FASTRAC HORIZONTAL CONVEYOR TOASTER

APW WYOTT

729 Third Avenue

Dallas, TX 75226

This equipment has been engineered to provide you with year-round dependable service when used

according to the instructions in this manual and standard commercial kitchen practices.

WARNING: Improper installation, adjustment, alteration, service or maintenance can

cause property damage, injury or death. Read the Installation, Operating and

Maintenance Instructions thoroughly before installing or servicing this equipment.

TABLE OF CONTENTS

Safety Precautions

Important Safety Instructions

General Information

Installation Instructions

Operation Instructions

Cleaning Instructions

Warranty Procedure

Troubleshooting

Replacement Parts List

Wiring Diagram

Warranty

Summary of content (12 pages)

PAGE 1
R INSTALLATION AND OPERATING INSTRUCTIONS FT 800H TM FASTRAC HORIZONTAL CONVEYOR TOASTER Model: INTENDED FOR OTHER THAN HOUSEHOLD USE RETAIN THIS MANUAL FOR FUTURE REFERENCE UNIT MUST BE KEPT CLEAR OF COMBUSTIBLES AT ALL TIMES TABLE OF CONTENTS Safety Precautions Important Safety Instructions General Information Installation Instructions Operation Instructions Cleaning Instructions Warranty Procedure Troubleshooting Replacement Parts List Wiring Diagram Warranty ! 2 3 4 4 5 5 6 6 8 10 11 WARNING: Imp
PAGE 2
IMPORTANT FOR FUTURE REFERENCE Please complete this information and retain this manual for the life of the equipment. For Warranty Service and/or Parts, this information is required. Model Number Serial Number Date Purchased Notes: SAFETY PRECAUTIONS Before installing and operating this equipment be sure everyone involved in its operation are fully trained and are aware of all precautions. Accidents and problems can result by a failure to follow fundamental rules and precautions.
PAGE 3
1. IMPORTANT SAFETY INSTRUCTIONS ! IMPORTANT: Read the following important safety instructions to avoid personal injury or death, and to avoid damage to the equipment or property. ! ! WARNING: Do not allow untrained personnel to operate the toaster. ! ! NOTICE: Do not use toppings (butter, etc.) on product as product is inverted during normal operation.
PAGE 4
! CAUTION: The National Sanitation Foundation (NSF) requires that units over 36” (91 cm) in length or weighing more than 80 lbs. (36 kg) to be either sealed or raised on the installation surface. If this unit cannot be sealed at the point of use, 4” (10 cm) legs are included to allow for proper cleaning access below unit. ! ! WARNING: Genuine APW Wyott Replacement Parts are specified to operate safely in the environments in which they are used.
PAGE 5
III. Toaster Placement A. Locate the toaster near a grounded receptacle of the proper configuration (see below). Plug the cordset directly into receptacle (DO NOT USE AN EXTENSION CORD). 1. In the United States, NEMA 6-20R. 2. In Canada, NEMA 6-20R. B. Place the toaster on a flat surface providing the following minimum clearances: 1. Base = one inch (provided with legs installed). 2. Side and back walls = one inch 3. Overhead = Enough space to allow adequate heat displacement. 4.
PAGE 6
D. E. F. II. Slide the reflector/crumb tray out of the toaster by pulling forward. Dispose of crumbs and wash the tray in hot, soapy water. Dry the tray and place it back into the toaster. Remove the bottom toast drawer from the toaster by sliding it out and lifting up. Dispose of crumbs and wash the drawer in hot, soapy water. Wipe crumbs from inside the toaster with a hot, damp cloth. Dry the drawer and place it back into the toaster. Wipe the exterior surfaces of the toaster with a hot, damp cloth.
PAGE 7
TROUBLESHOOTING CHART: THE PROBLEM THE CAUSE THE SOLUTION Won't toast... a. Toaster cold. a. Allow five (5) minutes for warm up. b. Wrong power switch position. b. Position power switch to full power. c. Wrong conveyor speed setting. c. Reduce conveyor speed. Toasts unevenly... d. Only part of product surface is d. Reduce conveyor speed. Toasted. e. Product located too far to side of e. Place product on conveyor between conveyor. Product sticks to conveyor or slide.. end links. f.
PAGE 8
REPLACEMENT PARTS LIST - FT 800H ITEM P/N DESCRIPTION QTY 1 34236 TERMINAL BLOCK END MTG 1 2 34237 TERMINAL BLOCK (6) .
PAGE 9
EXPLODED VIEW - FT 800H 1 2 23 4 13 9 3 22 12 27 8 21 7 28 11 5 19 15 26 6 24 9 14 10 20 18 25 16 17
PAGE 10
WIRING DIAGRAM - MODEL FT 800H ! IMPORTANT NOTICE: The information contained in this section of the manual is intended for individuals possessing backgrounds of electrical and mechanical experience, such as an authorized APW Wyott service technician. APW or the seller cannot be responsible for the interpretation of this information, nor can it assume any liability in connection with its use.
PAGE 11
APW WYOTT EQUIPMENT LIMITED WARRANTY APW Wyott Foodservice Equipment Company warrants it's equipment against defects in materials and workmanship, subject to the following conditions: This warranty applies to the original owner only and is not assignable. Should any product fail to function in its intended manner under normal use within the limits defined in this warranty, at the option of APW Wyott such product will be repaired or replaced by APW Wyott or its Authorized Service Agency.
PAGE 12
R Phone: Fax: Toll Free: Website: E-mail: +1 (214) 421-7366 +1 (214) 565-0976 +1 (800) 527-2100 www.apwwyott.com info@apwwyott.