R INSTALLATION AND OPERATING INSTRUCTIONS Gas Char-Broilers......................MODELS: GCB-18H, -24H, -36H, -48H & Charrock Gas Broilers.......MODELS: GCRB-18H, -24H, -36H, -48H IMPORTANT FOR FUTURE REFERENCE Please complete this information and retain this manual for the life of the equipment. For Warranty Service and/or Parts, this information is required.
CAUTION: These models are designed, built, and sold for commercial use. If these models are positioned so the general public can use the equipment, make sure that cautions, warnings, and operating instructions are clearly posted near each unit so that anyone using the equipment will use it correctly and not injure themselves or harm the equipment. ! ! WARNING: Improper installation, adjustment, alteration, service or maintenance can cause property damage, injury or death.
IMMEDIATELY INSPECT FOR SHIPPING DAMAGE All containers should be examined for damage before and during unloading. The freight carrier has assumed responsibility for its safe transit and delivery. If equipment is received damaged, either apparent or concealed, a claim must be made with the delivering carrier. A) Apparent damage or loss must be noted on the freight bill at the time of delivery. It must then be signed by the carrier representative (Driver).
GENERAL INSTALLATION INSTRUCTIONS Ensure gas supply and gas type, as shown on unit nameplate agree. Unit installation must conform with the National Fuel Gas Code, ANSI Z223.1/NFPA 54, the National Gas Installation Code, CSA-B149.1, or the Propane Installation Code, CSA-B149.2 as applicable and in accordance with local codes. Screw legs into the permanently fastened nuts on the four corners of the unit and tighten by hand. Level the unit by turning the adjustment screw at the bottom of each leg.
DIMENSIONS: GCB-18H & GCRB-18H 30.39 (772) 4.95 (126) 9.00 (229) 15.61 (396) 15.00 (381) 18.00 (457) DIMENSIONS: 18.57 (472) 25.14 (639) 4.00 (102) GCB-24H & GCRB-24H 30.08 (764) 4.95 (126) 8.64 (219) 15.60 (396) 21.00 (533) 18.57 (472) 24.00 (610) 5 25.14 (639) 3.
DIMENSIONS: GCB-36H & GCRB-36H 25.05 (636) 4.95 (126) 9.55 (243) 15.54 (396) 33.00 (838) 18.57 (472) 25.14 (639) 36.00 (914) DIMENSIONS: GCB-48H & GCRB-48H 4.95 (126) 10.61 (269) 15.60 (396) 45.00 (1143) 18.57 (472) 25.14 (639) 48.00 (1219) 6 3.
CONVERSION ! ! ! 1. 2. 3. 4. 5. Instructions are for conversion from Natural Gas to Propane (L.P.) on all models GCRB and GCB. The conversion should be done before connecting the unit to the gas supply. Units are shipped from the factory equipped for use on natural gas. Orifices necessary for LP (propane) are provided in a bag tied to the valve on the front panel. Remove the knobs and front panel. Remove the orifice fittings from the valve. Change the orifices to the size recommended for propane (L.P.).
! Relight following steps 4 through 6 under Standing Pilot Lighting Instructions. LIGHTING MAIN BURNER: Since the burner is lit from constantly burning pilot, turn knobs to "HI" to put the unit in operation; then adjust to any desired position between "LO" and "HI". ! ! ! ! ! ! To light burner, turn knob to "max." then back off to the desired flame level. The range of adjustment is virtually infinite between high and off. (At the small flame, there is a pre-set low).
and systematic approach to the loading of the unit will produce the most consistent product results. RADIANTS Place the radiants in their position as shown in Sketch 1. Make sure that the radiants are setting properly into the slots on the front and rear supports. Radiants should be centered over straight section of the burners. COOKING GRATES Place the top cooking grates with the grid bars sloping toward the front as shown in Sketch 2.
WEEKLY Thoroughly clean the exposed surfaces of broiler, sides, front and top grease trough, with a damp cloth, then polish with a soft, dry cloth. A detergent may be used for cleaning. To remove discoloration, use a nonabrasive cleaner. After performing daily cleaning procedures, proceed with the following: A. Remove the radiants. Clean reflecting drip shield of any dust or debris with a brush. Note: Top grid grates and rock grates are heavy. B. Burner air shutter openings must be kept clean. C.
PLACE LAVA ROCKS WITH AIR SPACES BETWEEN THE ROCKS. DO NOT OVER LOAD ROCK GRATES. Please Use The Following Amount of Lava Rock Per Model. GCRB 18 = Approximately 3 LBS. GCRB 24 = Approximately 4 LBS. GCRB 36 = Approximately 7 LBS. GCRB 48 = Approximately 9 LBS.
PARTS LIST: GCB-18H & GCRB-18H Item P/N Description Quan Item 1 218207-55 Weldment, 18" Bullnose 1 35 218212-16 Radiant Med Duty - H 2 2 218215-11 Body, 18" Firebox GGM 1 36 43813149 Label, Warning Hot Surface (French) 1 3 8431300 1/4-20 Flanged Hex Locknut 6 37 8705800 Knob, Medium Duty Unit 1 4 21813085 Spacer 4 38 8632000 Leg, 4" Adjustable, 2000 Lb Cap.
EXPLODED VIEW: GCB-18H & GCRB-18H 41 41 3 GCRB ONLY 66 40 40 1 50 1 11 67 51 51 1 36 36 1 19 19 2 17 17 1 666 GCB ONLY 35 26 26 1 2 4 44 21 551 29 30 4 30 32 29 1 28 28 1 Y NL Y O B NL GC CB O G 25 3 24 24 2 23 23 1 32 1 37 37 1 727 12 1 12 11 11 1 34 34 1 25 4 3 6 33 33 1 13 1 13 18 18 1 31 1 31 38 38 4 21 21 12 20 48 20 2 48 1 27 15 1 15 14 881 14 1 16 1 27 4 42 1 16 42 47 1 45 44 47 45 1 44 1 49 43 49 1 43 1 10 10 1 39 39 22 1 22 2 13 9119 46 4
PARTS LIST: Item P/N GCB-24H & GCRB-24H Description Quan Item P/N Description Quan 1 218208-55 Weldment, 24" Bullnose 1 37 8705800 Knob, Medium Duty Unit 2 2 218208-51 Body, 24" Firebox GCRB-GGM 1 38 24250-00 Pan, Grease 24 1 3 8417100 Nut, Hex, KEPS 10-32 6 39 218208-26 Cap, End Control Panel, R.H. 1 4 8153100 #8-32 X 3/8 Type T 14 40 21820827 Cap, End L.H.
EXPLODED VIEW: GCB-24H & GCRB-24H 33 33 4 GCRB ONLY 69 36 36 1 111 34 1 34 31 31 1 21 21 1 19 19 1 16 9 9 2 101 10 151 70 14 43 43 1 52 52 1 11 23 23 2 41 41 1 336 5 848 27 27 1 51 51 2 727 44 44 1 GCB ONLY 20 15 2 12 1 12 21 26 26 6 13 1 13 22 22 1 LY ON LY B N Y GC B O ONL Y C NL B G GC CB O G 29 29 1 28 28 1 40 40 1 662 17 2 17 37 2 37 30 30 1 35 32 1 39 4 32 39 4 35 48 48 1 1 47 47 46 46 1 24 24 4 45 1 45 38 1 38 18 2 18 15 4 14 4 49 1 49 42 42 1 50 1 50
PARTS LIST: Item P/N Description GCB-36H & GCRB-36H Quan Item P/N Description Quan 1 218209-55 Weldment, Bullnose 36 1 37 218209-22 Support, 36" Rock Grate Front 1 2 218209-51 Body, 36" Firebox GGM 1 38 43813149 Label, Warning Hot Surface (French) 1 3 218209-52 Support, 36" Firebox Divider 1 39 218212-16 Radiant Med Duty - H 6 4 81546-00 #8 X 3/8 12 40 8632000 Leg, 4" Adjustable, 2000 Lb Cap.
EXPLODED VIEW: GCB-36H & GCRB-36 44 GCRB ONLY 68 43 37 37 1 111 55 2 19 17 18 22 14 22 2 13 3 13 16 1 16 GCB ONLY 9 97 3 3 1 551 8 8 1 20 20 2 45 45 1 39 LY ON LY B N GC B O NLY GC CB O NLY Y G CB O NL Y G CB O NL G CB O G 2 243 6 6 6 15 15 3 21 2 21 38 38 1 10 10 2 7 69 54 54 1 55 1 23 29 2 23 29 1 11 1 35 11 33 33 4 40 4 40 53 1 53 42 3 42 30 30 4 31 31 1 32 1 32 34 1 34 41 41 12 2 20 28 12 4 28 17 4 4 12 25 25 2 48 48 1 46 1 46 27 12 27 26 51 26 2 51 1 49 1
PARTS LIST: Item P/N GCB-48H & GCRB-48H Description Quan Item P/N Description Quan 1 218210-55 Weldment, 48" Bullnose 1 37 218210-23 Support, Leg 2 2 8417100 Nut, Hex, KEPS 10-32 7 38 21820827 Cap, End L.H. 1 3 8153100 #8-32 X 3/8 Type T 20 39 218208-26 Cap, End Control Panel R.H.
EXPLODED VIEW: GCB-48H & GCRB-48H 41 41 8 GCRB ONLY 36 1 36 111 69 66 66 1 44 511 51 9 6 5 43 GCB ONLY 67 67 1 Y NL B O NLY GC CB O ONLY Y G CB ONL LY N G CB G CB O ONLY Y G CB NL G B O NLY GC CB O G 16161 10 13 17 2 17 2 2 7 43 2 22 12 8 81 46 46 2 30 30 2 13 1 40 4 40 25 11 23 68 34 34 1 45 45 1 15 15 1 7 4 38 14 2 14 37 27 37 2 27 12 19 19 2 31 1 31 54 54 1 50 38 1 24 4 24 35 1 35 33 1 33 18184 29 6 29 7 23 4 26 39 39 1 47 49 20 28 2 28 3 19 52 48 21 21 8
APW WYOTT EQUIPMENT LIMITED WARRANTY APW Wyott Foodservice Equipment Company warrants it's equipment against defects in materials and workmanship, subject to the following conditions: This warranty applies to the original owner only and is not assignable. Should any product fail to function in its intended manner under normal use within the limits defined in this warranty, at the option of APW Wyott such product will be repaired or replaced by APW Wyott or its Authorized Service Agency.
