Operating instructions

ManualsBrandsAPW Wyott ManualsFryerGF-15H

INSTALLATION

AND

OPERATING

INSTRUCTIONS

MODELS: GST, WGST

Steam Table

INTENDED FOR OTHER THAN HOUSEHOLD USE

RETAIN THIS MANUAL FOR FUTURE REFERENCE

UNIT MUST BE KEPT CLEAR OF COMBUSTIBLES AT ALL TIMES

FOR YOUR SAFETY: Do not store or use gasoline or other flammable vapors and

liquids in the vicinity of this or any other appliance.

WARNING: Improper installation, adjustment, alteration, service or maintenance can

cause property damage, injury or death. Read the Installation, Operating and

Maintenance Instructions thoroughly before installing or servicing this equipment.

Improper installation, adjustment, alteration, service or maintenance can cause property damage, injury or

death. Read the Installation, Operating and Maintenance Instructions thoroughly before installing or servicing

this equipment.

This equipment has been engineered to provide you with year-round dependable service when used according

to the instructions in this manual and standard commercial kitchen practices.

Phone: +1 (214) 421-7366

Fax: +1 (214) 565-0976

Toll Free: +1 (800) 527-2100

Website: www.apwwyott.com

E-mail: info@apwwyott.com

APWWYOTT

729 Third Avenue

Dallas, TX 75226

Summary of content (15 pages)

PAGE 1
INSTALLATION AND OPERATING INSTRUCTIONS MODELS: GST, WGST Steam Table INTENDED FOR OTHER THAN HOUSEHOLD USE RETAIN THIS MANUAL FOR FUTURE REFERENCE UNIT MUST BE KEPT CLEAR OF COMBUSTIBLES AT ALL TIMES FOR YOUR SAFETY: Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. WARNING: Improper installation, adjustment, alteration, service or maintenance can cause property damage, injury or death.
PAGE 2
Please complete this information and retain this manual for the life of the equipment. For Warranty Service and/or Parts, this information is required. Model Number Serial Number 1) OWNER’S INFORMATION ..........................................................................................................................................................2 2) SAFETY INFORMATION ...............................................................................................................................
PAGE 3
Warranty Information: Reliability Backed by APW Wyott’s Warranty: All APW Wyott’s Steam Tables are backed by a one year parts and labor warranty, including On-Site Service calls within 50 miles of authorized service technicians. Service Information: Service Hotline (800) 733-2203 2) SAFETY INFORMATION APW Wyott equipment is designed, built, and sold for commercial use and should be operated by trained personnel only.
PAGE 4
) SPECIFICATIONS: WGST MODEL GAS BTU RATING WGST-2 WGST-3 WGST-4 WGST-5 WGST-2 WGST-3 WGST-4 WGST-5 NG NG NG NG LP LP LP LP 15,150 15,150 30,150 30,150 15,150 15,150 30,150 30,150 5) GAS CONNECTION GST AND WGST PLUMBER OR INSTALLER Insure that all the connections and fittings are tight and did not come loose in shipment. A gas shut off valve and ground joint union in the supply line should be installed for easy service.
PAGE 5
Warning! Operating environment Ensure that operation location is at least 1” in all directions from combustible walls and materials otherwise combustion or discoloration could occur. Warning! Operating environment WGST Ensure that the front and rear louvers are unobstructed with at least ½” space between it and other surfaces. Caution! Operating environment Place unit on a stable, level floor.
PAGE 6
Step 2 Place the unit on the floor upside down. Be sure to protect the top surface and well from damage when the unit is placed on it top on the floor. Once the legs are in place tighten the set screws in the leg inserts. Step 3 Slide the shelf over the legs. Note: The flat surface should be facing down.
PAGE 7
6" Step 4 Locate the bottom of the shelf at minimum 6 inches from the floor to allow for cleaning and to comply with NSF standards. Tighten the 4 set screws located in each corner of the shelf leg inserts. Insert included plastic caps into the heads of the set screws. Step 5 Install the shelf support brackets to the shelf. Then end brackets will be attached with the cutting board stop and the middle (4 and 5 well only) will be attached to the existing studs.
PAGE 8
Step 6 Loosen top screws across the front of the unit and remove bottom screws. Slide keyways of the shelf and supports over the screw heads and slide into place. Install bottom screws and tighten top screws. Place cutting board over the stops. 7) OPERATION INSTRUCTIONS FOR GST 1. LIGHTING INSTRUCTIONS a. STANDING PILOT – If pilots or burners go out, turn off the gas to the unit and wait five minutes before attempting to relight. The pilots must be adjusted before using the appliance.
PAGE 9
operator. The proper switch setting necessary to keep foods at the desired temperature will vary dependent upon the frequency of turnover, size of food containers, amount of food in each container, room temperature, location of food warmer with respect to range or other heated equipment, air outlets, fans, doors and passageways. 8) OPERATION INSTRUCTIONS WGST 1. LIGHTING INSTRUCTIONS a. Safety Pilot – The WGST model comes standard with a safety pilot.
PAGE 10
WARNING Do not use any highly caustic cleaners, acids or ammonia. These may cause corrosion and/or damage to the stainless steel well. Do not allow water to stand in the well for long periods of time. Water must be removed from the well and the well cleaned after each use. CLEANING PROCEDURES FOR POLYETHYLENE OR ABS (RUBBER) COMPOSITION TABLE TOPS OR CUTTING BOARDS When high pressure cleaning equipment is not available; use hot water, a granular cleanser or detergent and a stiff bristle brush.
PAGE 11
2. Clean with the polish lines • Some stainless steel comes with visible polishing lines or “grain.” When visible lines are present, always scrub in a motion parallel to the lines. When the grain cannot be seen, play it safe and use a soft cloth or plastic scouring pad. 3. Use alkaline, alkaline chlorinated or non-chloride containing cleaners. • While many traditional cleaners are loaded with chlorides, the industry is providing an everincreasing choice of non-chloride cleaners.
PAGE 12
) GST GAS PARTS DIAGRAM 1 2 3 6 4 5 7 8 1 2 3 4 5 6 7 8 2066264 32012005 2066205 3201206 2066206 2065643 21880303 GST-2 32012011 GST-3 32012021 GST-4 32012031 GST-5 32012041 12 Burner Pilot Elbow Gas Line Adapter Pilot Valve Valve Manifold
PAGE 13
) WGST GAS PARTS DIAGRAM 1 7 6 2 3 5 10 4 11 8 13
PAGE 14
NOTES: 14
PAGE 15
APW WYOTT EQUIPMENT LIMITED WARRANTY APW Wyott Food service Equipment Company warrants it's equipment against defects in materials and workmanship, subject to the following conditions: This warranty applies to the original owner only and is not assignable. Should any product fail to function in its intended manner under normal use within the limits defined in this warranty, at the option of APW Wyott such product will be repaired or replaced by APW Wyott or its Authorized Service Agency.