ESTATE OWNER’S MANUAL & INSTALLATION GUIDE Installer: This booklet must be given to the product owner. Please add important information below. Model # ___________________________________ Purchase Date ___________________________________ Serial # ___________________________________ Distributor ___________________________________ Note: Read all instructions before proceeding with installation. All specifications are ± 3/8’’ and are subject to change without notice. Dimensions listed in inches (mm).
TABLE OF CONTENTS PRODUCT WARRANTY REGISTRATION INFORMATION IMPORTANT SAFETY INSTRUCTIONS INSTALLATION INSTRUCTIONS Pre-Installation Procedures Structural Preparation Plumbing Final System Test & Clean-Up Rough-In Measurements Electrical Installation Optional Inline Maintenance Heater Operating Instructions Installation of Electronic On/Off Timer Control To Replace LED Light Santa Clara & Santa Cruz – Integrally Skirted Models Installation Procedures for Integrally Skirted Models Removable Skirt Panels for
Estate Series Owner's Manual & Installation Guide AQUATIC Product Warranty Registration Information Thank you for choosing an Aquatic bath. You have chosen one of the finest bath products in the industry! Aquatic supports your purchase with strong commitments to quality and customer satisfaction. IMPORTANT! To activate Product Warranty, please register with Aquatic. Your product warranty must be registered and confirmed with Aquatic through the Serial Number on your unit.
Estate Series Owner's Manual & Installation Guide IMPORTANT SAFETY INSTRUCTIONS WARNING: When using this unit, basic precautions should always be followed, including the following: READ AND FOLLOW ALL INSTRUCTIONS: • WARNING: Risk of lethal electric shock. To reduce risk of electric shock, connect only to circuits protected by a Ground-Fault Circuit-Interrupter (GFCI) or Residual Current Device (RCD).
Estate Series Owner's Manual & Installation Guide IMPORTANT SAFETY INSTRUCTIONS Before taking your first whirlpool bath, be sure you have performed the “System Test.” [See INSTALLATION INSTRUCTIONS, pg. 8.] Be sure that you are familiar with all the controls and switches and that the unit is operating properly. 1. The water in a whirlpool should never exceed 40º C (104º F). Water temperature between 38º C (100º F) and 40º C (104º F) are considered safe for a healthy adult.
Estate Series Owner's Manual & Installation Guide INSTALLATION INSTRUCTIONS READ ALL INSTRUCTIONS CAREFULLY BEFORE INSTALLATION PRE-INSTALLATION PROCEDURES PLEASE NOTE: THE MANUFACTURER ACCEPTS A +3/8” VARIANCE. THERE ARE VARIATIONS ON EACH TUB AND SPECIFICATIONS ARE SUBJECT TO CHANGE AS WE IMPROVE UPON OUR PRODUCT AS REQUIRED. THE DIMENSIONS NEEDED FOR SITE PREPARATION AND STRUCTURE BUILDINGS SHOULD BE MEASURED FROM THE TUB; AQUATIC ASSUMES NO RESPONSIBILITY FOR PREPARATORY WORK.
Estate Series Owner's Manual & Installation Guide INSTALLATION INSTRUCTIONS STRUCTURAL PREPARATION Note: The bath should remain in its shipping carton until time of installation. 1. Literature dimensions are for reference only. Installation dimensions should be taken directly from the tub. An unobstructed access panel of 16” x 16” minimum must be provided at the pump end of the whirlpool allowing sufficient clearance to make final connections and for servicing the pump and power panel.
Estate Series Owner's Manual & Installation Guide INSTALLATION INSTRUCTIONS PLUMBING 1. After securing tub in place, normal waste and overflow, water spout and valves are installed per normal plumbing procedures, in accordance with all state and local standards. 2. Install standard 1-1/2” trap to drain and overflow. Before proceeding make final operational check by filling tub with water to overflow and operate pump for 5 minutes.
Estate Series Owner's Manual & Installation Guide INSTALLATION INSTRUCTIONS ROUGH-IN MEASUREMENTS MODEL A See Figure 2, below B A Camina Motif Castaway Castaway Oval Clearwater Clearwater, Jr. Daytona Del Ray Laguna Oxford Pagosa Motif Point Arena Point Reyes Point Reyes, Jr.
Estate Series Owner's Manual & Installation Guide INSTALLATION INSTRUCTIONS ELECTRICAL INSTALLATION WARNING: ALL ELECTRICAL CONNECTIONS SHOULD BE MADE BY A LICENSED, LOCALLY CERTIFIED ELECTRICIAN, IN ACCORDANCE WITH THE REQUIREMENTS OF THE STATE AND LOCAL ELECTRICAL CODES AND PROCEDURES.
Estate Series Owner's Manual & Installation Guide INSTALLATION INSTRUCTIONS ELECTRICAL INSTALLATION Estate Component Breakdown ON/OFF PUMP BUTTON KEYPAD PUMP CONTROL BOX UP/HAUT OUTPUTINTPUT W/D KEYPAD AUX NEMA PLUG OPTIONAL HEATER NEMA PLUG ADDITIONAL 15A/120V BREAKER FOR THE HEATER NEEDED. PUMP MAIN BREAKER PANEL 120V-240V/60Hz NEMA PLUG IMPORTANT: 15A/120V BREAKER WITH GROUND FAULT CIRCUIT INTERRUPTER CLASS "A". (ONE 15 AMPS/120 VOLTS CIRCUIT.
Estate Series Owner's Manual & Installation Guide INSTALLATION INSTRUCTIONS OPTIONAL INLINE MAINTENANCE HEATER OPERATING INSTRUCTIONS Operation of the inline maintenance heater is completely automatic. The heater will help maintain the temperature of the water in the whirlpool. The heater includes the following components: THERMOSTAT: The “Smart Thermostat” requires no adjustment and will automatically maintain the water temperature at 102o F - 104o F.
Estate Series Owner's Manual & Installation Guide INSTALLATION INSTRUCTIONS TO REPLACE LED LIGHT 1. Disconnect the power to your bathtub. 2. Drain the bathtub. 3. Open the lens of the fixture using ONLY the proper tool provided for that purpose (see Figure 4). Do not attempt to remove the lens without the provided tool. 4. Replace your LED light (replacement LED lights can be obtained from Aquatic). Lens Tool LED Bulb Figure 4 NOTE: Do not twist LED light into socket.
Estate Series Owner's Manual & Installation Guide INSTALLATION INSTRUCTIONS SANTA CLARA & SANTA CRUZ - INTEGRALLY SKIRTED MODELS ALCOVE FRAMING AND PRE-INSTALLATION PROCEDURES: 1. Protect interior of tub throughout installation procedures. 2. Before moving unit into alcove see and follow enclosed Electrical Installation Procedures (electrical and air tube hookups will be difficult to perform if unit is installed first.) IMPORTANT! BEFORE INSTALLATION BEGINS, MAKE SURE THAT: 1.
Estate Series Owner's Manual & Installation Guide INSTALLATION INSTRUCTIONS INSTALLATION PROCEDURES FOR INTEGRALLY SKIRTED MODELS 1. To avoid obstructions during installation, make sure water lines, spout pipes and valve plumbing do not project into alcove. 2. Ledger Strip: Fasten a 1” x 3” (25mm x 75 mm) ledger strip along rear for alcove and along both sides in corner installations at Dimension LH. (see Figure 5A) 3.
Estate Series Owner's Manual & Installation Guide INSTALLATION INSTRUCTIONS FRAMING & INSTALLATION PROCEDURES 1. Protect interior of tub throughout installation process. 2. Framing and supports will vary according to the model and type of installation selected.
Estate Series Owner's Manual & Installation Guide INSTALLATION INSTRUCTIONS FRAMING & INSTALLATION PROCEDURES ALCOVES ISLANDS A Oval Models AS DESIRED AS DESIRED DH DH AS DESIRED AS DESIRED ACCESS PANEL ON PUMP END ACCESS PANEL ON PUMP END A C C Integrally Skirted Models ID AS DESIRED IW TEMPLATE CUTOUT MAJOR AXIS 16" (405) 1" (25) PLYWOOD DECK AS DESIRED Aquatic DECK CUTOUT - A paper template will be enclosed with all oval models.
Estate Series Owner's Manual & Installation Guide OPERATION OF WHIRLPOOLS NOTE: DO NOT START PUMP UNTIL ALL JETS ARE SUBMERGED. WATER LEVEL SHOULD BE 2” ABOVE HIGHEST JET. BATHSIDE CONTROL SYSTEMS On/Off Controls: The On/Off Electronic Button with Timer is the On/Off Button for the pump/jet action for the Estate Series. • One-Speed Pump 1. Make sure water level is approximately 2 inches above the highest jet. 2. Push the On/Off Button once to turn the pump on.
Estate Series Owner's Manual & Installation Guide OPERATION OF WHIRLPOOLS JET OPERATIONS Estate Series Whirlpool Jets The Estate Series combines High-flow directional jets and Dual-port high-flow spinning jets to provide an invigorating hydrotherapy experience. High-flow Directional Jets Designed to facilitate targeted, deep tissue massage therapy. Each jet is fully adjustable for direction of water flow and intensity of pressure.
Estate Series Owner's Manual & Installation Guide WHIRLPOOL USER INFORMATION PLEASE NOTE: WHIRLPOOL USER INFORMATION • PLEASE NOTE: The whirlpool action may cause even small amounts of bubble bath or shampoo to foam excessively. Exercise moderation in experimenting with different soap products. No servicing of this product should be done by the user. There are no user serviceable parts. All controls are located in the control recesses on the lip of the tub.
Estate Series Owner's Manual & Installation Guide TUB CARE MAINTENANCE • Ground-fault circuit-interrupter (GFCI): This device must be tested on a routine basis. [See IMPORTANT SAFETY INSTRUCTIONS.] Cleaning Your Whirlpool Bathtub IMPORTANT! Use only the recommended cleaners and procedures described in this section. Use of other materials and methods may harm your whirlpool and will VOID THE WARRANTY.
Estate Series Owner's Manual & Installation Guide TUB CARE CIRCULATING SYSTEM FAILURE TO PERFORM PERIODIC MAINTENANCE PROCEDURES MAY CAUSE SAFETY AND/OR HEALTH PROBLEMS AND MAY HARM THE BATHTUB, THE CIRCULATING SYSTEM AND PUMP, AND WILL VOID THE WARRANTIES. Circulating System: The whirlpool system must be purged at least monthly. To remove accumulations of bath residue from the whirlpool system, we recommend that you purge it at least twice a month, or more depending upon usage.
Estate Series Owner's Manual & Installation Guide WATER QUALITY CHEMICAL & WATER QUALITY Owners of fill and drain whirlpool bathtubs need to know basic information concerning water quality, how it affects the performance and enjoyment of the operation of their tubs, and steps that can be taken by the owner to correct related problems. Important issues are the microbiological and chemical quality of the water. 1.
Estate Series Owner's Manual & Installation Guide WATER QUALITY Iron - Iron is found in many natural waters especially from wells. Iron in water can also result from the corrosion of piping in the water supply system, such as cast iron mains or galvanized steel service lines, or galvanized piping in the home water system. High iron levels may result in the formation of brown stains in the vicinity of the faucet outlets of various fixtures in the home.
Estate Series Owner's Manual & Installation Guide TROUBLESHOOTING GUIDE WARNING: Always turn off power at the main electrical service panel when servicing your whirlpool. SYMPTOMS POSSIBLE PROBLEMS SUGGESTED SOLUTIONS Motor does not start 1) GFCI or circuit breaker in OFF position. 1) Reset GFCI (if optional heater is installed, be sure there are two GFCI circuits.) 2) Fuses blown or thermal overload open. 2) Contact your electrician. 3) Locked motor shaft.
Estate Series Owner's Manual & Installation Guide REPLACEMENT PARTS MAP 1b. 1a. 2a. 2b. 2c. 5a. 13a. 13b. 13c. 5b. 3a. (option) 4a. 3b. 3c. 3d. 4b.
Estate Series Owner's Manual & Installation Guide REPLACEMENT PARTS MAP 6a. 6b. 6c. 10. 8a. 7a. (Option) 8b. 9a. (Option) 12a. 12b. (Option) 12c. 12d. Aquatic (Option) 11.
Estate Series Owner's Manual & Installation Guide REPLACEMENT PARTS LIST ILLUSTRATION NO. PART # DESCRIPTION 1A. 8186ASSYxx FULL SIZE DIRECTIONAL JET 1B. 8186VJTB V-JET BODY 8186BDY 90 DEGREE JET BODY 8186WFTG WALL FITTING 2A.. 8184ROTxx STRESSEAZ JET INTERNAL 2B. 8184JTB STRESSEAZ JET BODY 2C. 8180NUT 3A. (OPTION) 8095HEATER 1.5 KW MAINTENENCE HEATER 3B. --- 2PC. HEATER SPLIT NUT 3C. --- GASKET / O-RING 3D. --- 1.5” X 1” TAILPIECE 4A. 8150UNION 1.5” PUMP UNION 4B.
Estate Series Owner's Manual & Installation Guide Aquatic Limited Lifetime Warranty FOR ESTATE SERIES Limited Warranty For Original Consumer For Household Usage WHAT PRODUCTS ARE COVERED Structures and surface finishes on Whirlpools (“Whirlpools”), Air Baths (“air baths”) and Soaking Tubs (“Tubs”), and their support equipment, components, attachments, controls and plumbing equipment. Different warranty periods apply to specific components.
AQUATIC Fax-On-Demand System: Toll Free (877) 618-7024 8101 E. Kaiser Blvd., Suite 200 • Anaheim, CA 92808 (800) 945-2726 • Fax (866) 544-5353 • www.aquaticbath.com 8MANEST | F.O.D. 9003 | Rev.