Instructions / Assembly

1 rev. 122711
Model XL2T
2 Ton Extra Long and Low Clearance Service Jack
For Technical Questions, Call: 1-800-879-7316
Warning information
This is the safety alert symbol. It is used to alert you
to potential personal injury hazards. Obey all safety
messages that follow this symbol to avoid possible
injury or death.
imPortant: rEaD tHESE inStrUCtionS BEforE oPErating
BEFORE USING THIS DEVICE, READ THIS MANUAL COMPLETELY AND THOROUGHLY, UNDERSTAND ITS OPERATING
PROCEDURES, SAFETY WARNINGS AND MAINTENANCE REQUIREMENTS.
It is the responsibility of the owner to make sure all personnel read this manual prior to using the device. It is also the responsiblity of
the device owner to keep this manual intact and in a convenient location for all to see and read. Contact PowerStation, LLC for a replace-
ment label if your stand's label is not readable. If the operator is not fluent in English, the product and safety instructions shall be read to
and discussed with the operator in the operator's native language by the purchaser/owner or his designee, making sure that the operator
comprehends its contents.
tHE natUrE of HaZarDoUS SitUationS
The use of Portable Automotive Lifting Devices are subject to certain hazards that cannot be prevented by mechanical means, but only
by the exercise of intelligence, care, and common sense. It is essential to have personnel involved in the use and operation of the device
who are careful, competent, trained, and qualified in the safe operation of the device and its proper use when servicing motor vehicles
and their components. Examples of hazards are dropping, tipping or slipping of loads caused primarily by improperly securing loads,
overloading, off-centered loads, use on other than hard level surfaces, and using equipment for a purpose for which it was not intended.
mEtHoDS to aVoiD HaZarDoUS SitUationS
 • Read,study,understandandfollowallinstructionsbeforeoperatingthisdevice.
 • Inspectthejackbeforeeachuse.Donotusejackifdamaged,altered,modied,inpoorcondition,leakinghydraulicuid,or
unstable due to loose or missing components. Make corrections before using.
 • Liftonlyonareasofthevehicleasspeciedbythevehiclemanufacturer.
 • WeareyeprotectionthatmeetsANSIZ87.1andOSHAstandards.
 • Donotusejackbeyonditsratedcapacity.
 • Thisisaliftingdeviceonly.Immediatelyafterlifting,supportthevehiclewithjackstandscapableofsustainingtheloadbefore 
working on the vehicle.
 • Useonlyonahardlevelsurfacefreefromobstructionssothejackisfreetorepositionitselfduringliftingandloweringoperations.
 • Centerloadonsaddle.Besuresetupisstablebeforeworkingonvehicle.
 • Donotmoveordollythevehiclewhileonthejack.
 • Donotusesaddleadaptersorsaddleextendersbetweenthestockliftingsaddleandtheload.
 • DonotuseanyadaptersunlessapprovedorsuppliedbyPowerStation,LLC.
 • Alwayslowerthejackslowlyandcarefully.
 • ThisproductcontainschemicalsknowntothestateofCaliforniatocausecancerandbirthdefectsorotherreproductiveharm.
Wash hands thoroughly after handling.
 • Failuretoheedthesewarningsmayresultinfatalpersonalinjuryand/orpropertydamage.
ConSEQUEnCES of not aVoiDing HaZarDoUS SitUationS
Failure to read this manual completely and thoroughly, failure to understand its OPERATING INSTRUCTIONS, SAFETY WARNINGS,
MAINTENANCEINSTRUCTIONSandcomplywiththem,andfailuretocomplywiththeMETHODSTOAVOIDHAZARDOUSSITUATIONS
could cause accidents resulting in serious or fatal personal injury and/or property damage.
WARNING: Indicates a hazardous situation
which, if not avoided, could result in death
or serious injury.
WARNING
WARNING
WARNING
WARNING