Use and Care Manual

EN - 5
Do not allow anyone to operate your log
splitter who has not read the Operator's
Manual or has not been instructed on the
safe use of the splitter.
Never allow children or untrained adults to
operate this machine.
Many accidents occur when more than one
(1) person operates the log splitter. If a
helper is assisting in loading logs to be split,
never actuate controls until the helper is
clear of the area.
Never allow anyone to ride on the machine.
Never transport cargo on the log splitter.
High fluid pressures are developed in
hydraulic log splitters. Pressurize hydraulic
fluid escaping through a pin hole opening
can puncture skin and cause severe blood
poisoning. Therefore, the following
instructions should be heeded at all times.
(a) Do not operate the unit with frayed,
kinked, cracked or damaged hoses,
fittings, or tubing.
(b) Stop the engine and relieve
hydraulic system pressure before
changing or adjusting fittings, hoses,
tubing, or other system components.
(c) Do not adjust the pressure settings
of the pump or valve.
(d) Do not check for leaks with your
hands. Leaks can be located by
passing cardboard or wood over the
suspected area. Look for discoloration.
If injured by escaping fluid, see a doctor
at once. Serious infection or reaction
can develop if proper medical treatment
is not administered immediately.
Keep the operator zone and adjacent area
clear for safe, secure footing.
If your log splitter is equipped with an
internal-combustion engine and intended for
use near any unimproved forest, brush, or
grass covered land, the engine exhaust
should be equipped with a spark arrestor.
Make sure you comply with applicable local,
state, and federal codes. Take appropriate
fire-fighting equipment with you.
Log splitters should be used only for splitting
wood. Do not use for other purposes unless
the manufacturer provides attachments and
instructions.
If unit is to be used by someone other than
original purchaser; loaned, rented or sold,
ALWAYS provide this manual and any
needed safety training before operation.
Operation
Before starting this log splitter, review the
"Rules for Safe Operation." Failure to follow
these rules may result in serious injury to the
operator or bystanders.
Never leave the machine unattended with
the power source operating.
Never operate the machine when under the
influence of alcohol, drugs, or medication.
The machine owner should instruct all
operators in safe log-splitter operation.
Always operate the log splitter with all safety
equipment in place and all controls properly
adjusted for safe operation.
Always operate the log splitter at
manufacturer's recommended speed.
Always keep hands and feet clear of moving
parts.
When loading a ram-type log splitter, place
your hands on the sides of the log not at the
ends. Never place your hands or any part of
your body between a log and any part of the
log splitter.
On ram-type log splitters, never attempt to
split more than one (1) log at a time unless
the ram has been full extended and a
second log is needed to complete the
separation of the first log.
On ram-type log splitters on which the logs
are not cut square, the longest portion of the
log should be rotated down and the most
square end placed against the ram.
Use only your hand to operate the log
splitter controls.
Do not refuel the engine until it has cooled
for several minutes.
Before starting engine ensure that control
lever is in neutral position.
Operate unit only when there is sufficient
light to clearly see work area.
NEVER allow children to operate or play on
or near unit.
Operate unit only when standing in operator
zone. Unit stabilizers must be extended
before starting unit.
Use wheel chocks to prevent movement of
unit during operation.
ALWAYS keep hands away from all moving
parts during operation. Moving parts can cut
or crush body parts.
DO NOT operate in the rain or in wet or
damp locations. Assure that operator zone is
free or debris and provides good footing.