OWNERS MANUAL
Congratulations on your recent purchase of a Damon Motor Coach Recreational Vehicle. We sincerely thank you for choosing and putting your faith in Damon, and we would like you to know that your satisfaction is of great importance to us. Our major goal is to provide you with a quality recreational vehicle at a reasonable price. Your unit has been designed to provide you with many years of carefree, comfortable travel and vacationing.
Acknowledgement of Receipt of Warranty/Product Information IMPORTANT: The customer is required to read this document before signing it. We have listed several items which will help acquaint you with your new recreation vehicle.
TAPE - PLEASE DO NOT STAPLE FOLD HERE PLACE STAMP HERE DAMON MOTOR COACH CUSTOMER SERVICE DEPARTMENT PO BOX 2888 ELKHART, IN.
Table of Contents INTRODUCTION Introduction How to use this manual Reporting Safety Defects WARRANTY - CHAPTER 1 Damon Limited Warranty Owner Responsibility Checklist Major Equipment Suppliers PLANNING AND PREPARATION - CHAPTER 2 License and Insurance Inspect and Maintain Loading and Weight Controlling the Motorhome Pre-travel Checklist Opening Checklist Weights Federal Certification Label Federal Weight Label Capacity Weighing Your Motorhome Weight Distribution Trailer Hitches and Towing Towing and GCWR ON
Table of Contents Awning 120 Volt Outlet Power Cord Generator Compartment Furnace Door Water Heater Access Refrigerator Panel Automotive Fuse Block Exterior TV Hook-up Fantastic Vent CARE AND MAINTENANCE - CHAPTER 10 Batteries Waste Water System Fresh Water System Electrical System Generator Power System Propane System ABS Plastic Parts Alignment Awning Chassis Doors & Door Locks Exterior Lights Fiberglass Wax Graphics Sidewalls Roof Roof Vents Seals & Adhesives Slideout Tires TV Antenna Underbody Windows
Introduction This manual describes many features of your motorhome and provides a guide to operating procedures so that you can obtain the best performance from those features. Your motorhome has been designed to conform with, or exceed, the American National Standards Institute A 119.2, NFPA 1192, CANADIAN CAN/CSA-Z240 RV SERIES-99 (Canadianbuilt or units built for Canada), and applicable motor vehicle safety standards.
Introduction How to Use This Manual Your motorhome has been thoroughly inspected before shipment to the dealer. Your selling dealer is responsible for performing a complete pre-delivery inspection of all motorhome components as specified in the pre-delivery checklists supplied by the manufacturer. You should receive a copy of these completed checklists from your dealer when the motorhome is delivered to you.
Chapter 1 - Warranty WHAT THE PERIOD OF COVERAGE IS: This Limited Warranty provided by Damon Corporation® (“Warrantor”) covers those components, assemblies and systems of your new motorhome not excluded under the section “What is Not Covered”, when sold by an authorized dealer, for twelve (12) months from the first buyer’s retail purchase date or the first 12,000 miles of use, whichever occurs first.
Chapter 1 - Warranty selling dealer during the inspection process performed by the Warrantor and the selling dealer. If, however, you discover any such defect or damage when you take delivery of the motorhome, you must notify your dealer or Warrantor within ten days of the date of purchase to have repairs performed to the defect at no cost to you as provided by this Limited Warranty.
Chapter 1 - Warranty TO RECOVER FROM WARRANTOR ANY CONSEQUENTIAL OR INCIDENTAL DAMAGES RESULTING FROM ANY DEFECT IN THE MOTORHOME, INCLUDING BY WAY OF EXAMPLE FUEL AND TRANSPORTATION EXPENSES TO DELIVER THE PRODUCT TO THE SERVICING DEALER, HOTEL ROOMS, LOST WAGES AND MOISTURE DAMAGE SUCH AS MOLD AND MILDEW. THE EXCLUSION OF CONSEQUENTIAL AND INCIDENTAL DAMAGES SHALL BE DEEMED INDEPENDENT OF, AND SHALL SURVIVE, ANY FAILURE OF THE ESSENTIAL PURPOSE OF ANY LIMITED REMEDY.
Chapter 1 - Warranty 12
Chapter 1 - Warranty Damon reserves the right to make changes in Vehicles built and/or sold by it at any time without incurring any obligations to make the same or similar changes on Vehicles previously built and/or sold by Damon. PRODUCTION CHANGES As the proud owner of a Damon Motor Coach, you want to trust that your unit will continue to perform at its peak. To ensure this Damon has provided you this checklist of the responsibilities of the Damon owner.
Chapter 1 - Warranty 14 PROPER LOAD BALANCE Your motorhome is built to withstand a certain maximum load. Check the amount listed on the Federal Certification Label in the driver’s area of your motorhome to determine safe load limits. NEVER OVERLOAD THE MOTORHOME. Reference pages 20 - 23 for proper loading and weight distribution. SEALANTS Weatherproofing sealants are used around the doors, windows, vents, and joints during construction of your motorhome.
Chapter 1 - Warranty SUPPLIERS PROVIDING SEPARATE WARRANTIES Please read your recreational vehicle warranty carefully. It is very important to know what Damon Motor Coach warrants, and what is warranted by other suppliers’ warranties. Damon Motor Coach does not warrant some items within your vehicle. Below you will find a list of manufacturers who can help you with these components. Please contact them should a need arise.
Chapter 1 - Warranty 16
Chapter 2 - Planning and Preparation A thorough working knowledge of your motorhome is important if you are going to get the most out of the convenience and safety items built into your unit. Be as familiar with it as you are with your personal car or truck. Study all the booklets included in your Owner’s Information Kit. These booklets cover details of operation for the major appliances and equipment built into your motorhome for your comfort, convenience and safety.
Chapter 2 - Planning and Preparation WHEEL LUGS Must be tightened to the specifications in the Chassis Manufacturer’s Owner’s Manual. WINDSHIELD Should be clean, wiper blades inspected, and windshield washer reservoir filled. LIGHTS Should be tested, including brake lights, warning flashers, clearance lights, tail lights, turn signals and headlights. Clean all lens covers. REARVIEW MIRROR Should be adjusted so the driver can see to the rear on both the right and left side of the unit.
Chapter 2 - Planning and Preparation • Open all doors and compartments. Check for animal or insect intrusion, water damage, or other deterioration. • Check charge level in batteries. Refill with distilled water and recharge if necessary. Reinstall batteries if necessary. Be sure cable ends and terminals are clean and free of corrosion. Turn the Battery Disconnect Switch off if applicable. • Check tire pressure. Inflate to the specified cold pressure. • Remove coverings from windows if necessary.
Chapter 2 - Planning and Preparation • Check all the chassis fluid levels including engine oil, coolant, power steering fluid, brake fluid, transmission, rear axle oil and washer fluid. Top off if necessary. • Check all exterior lights; clearance, brake, turn, and reverse should be fully functional. Your motorhome should be ready for a new traveling season. Your dealer can check your preparation and correct any defects or make any necessary adjustments.
Chapter 2 - Planning and Preparation Neither the axle loads nor the vehicle loads must ever exceed their respective maximum weight ratings. A properly loaded vehicle is safer and easier to drive. Distribute your cargo evenly from CAPACITY side-to-side and front-to-back. Heavier items should be stowed on or near the floor and be as centrally located as possible. They should be secured so they cannot slide during a panic stop causing damage. Lighter items can be stored in overhead cabinets.
Chapter 2 - Planning and Preparation The following explains commonly used weight abbreviations. • GROSS VEHICLE WEIGHT RATING (GVWR) is the maximum permissible weight of this fully loaded motorhome. • UNLOADED VEHICLE WEIGHT (UVW) is the weight of this motorhome as manufactured at the factory with full fuel, engine oil, coolants, and propane. • OCCUPANT and CARGO CARRYING CAPACITY (OCCC) is equal to the GVWR minus the UVW. Dealer installed equipment and towed weight will reduce the OCCC.
Chapter 2 - Planning and Preparation is the total amount that you may safely tow behind your motorhome. This Combined Vehicle Weight cannot exceed your motorhome’s specific GCWR. Example: If you have a GVWR of 16,000 lbs., and your unit weighs 13,965 lbs.: GVWR Subtract Unit weight = = 16,000 lbs. 13,965 lbs. 2,035 lbs. Total of 2,035 lbs. available for cargo in the motorhome providing you DO NOT overload the individual GAWR’s. Example: If you have a GCWR of 20,000 lbs.
Chapter 2 - Planning and Preparation 24
Chapter 3 - On the Road Safety Seat belts are an important safety feature of your vehicle. Each designated seat is designed to carry passengers while the vehicle is in motion. Each Designated Seating Position is equipped with either a type 1 (lap belt) or a type 2. (shoulder and lap belt) The number of seats equipped with seat belts is to provide a choice of seating locations. This does not necessarily mean that you may safely carry that many passengers.
Chapter 3 - On the Road Safety on drive train components, especially the transmission. Under extreme heat conditions you may need to turn off the vehicle air conditioner to improve engine and transmission cooling. Allow for the extra height of your motorhome and avoid areas having low overhead clearance. Check for low hanging tree branches or other obstructions wherever you drive or park. Avoid low roof heights when pulling in for service.
Chapter 3 - On the Road Safety start your trip home. If your vehicle is stored for any length of time, the air pressure should be checked prior to storage, but more importantly, when it comes out of storage. Check your tires when they are “cold” and have not been driven for more than one mile. The stated load capacity for a given cold inflation pressure is based on ambient outside temperature. To maintain the inflation pressure in your tires you will need the proper equipment.
Chapter 3 - On the Road Safety 28
Chapter 4 - Safety Provisions Your motorhome has been supplied with various safety features and equipment for your convenience and for safe operation. As with all areas in life, the chance for accidents is possible, and the recreational life-style is no exception. Please take the time to familiarize yourself with the safety features of your motorhome now to prevent any question of how they are used if an emergency should arise.
Chapter 4 - Safety Provisions The motorhome should never be operated or occupied unless the CO Detector is present and functioning properly. Do not under any circumstances operate the vehicle or generator engine while sleeping. BATTERY INSTALLATION The carbon monoxide detector is installed without batteries. To install the batteries, press the tab at the top of the CO detector and slide the detector upwards. Open the battery compartment door by hinging the left lower side downward.
Chapter 4 - Safety Provisions 3. Do not operate the generator in an enclosed building or in a partly enclosed area such as a garage. It is also not recommended that you use the generator when there are other vehicles nearby. 4. Review the safety precautions for fuel and exhaust fumes elsewhere in this manual. 5. Do not operate the generator when the RV is parked in high grass or brush. Heat from the exhaust could cause a fire in dry conditions. 6.
Chapter 4 - Safety Provisions • • Vehicle capacity weight (VCW - the maximum occupant and cargo weight a vehicle is designed to carry) Front and rear gross axle weight rating (GAWR - the maximum weight the axle system are designed to carry) Both placards and certification labels are permanently affixed to the motorhomes interior sidewall. Locate the placards and labels inside of a cabinet door, near to the driver’s area.
Chapter 4 - Safety Provisions grooves. When they appear “even” with the outside of the tread, it is time to replace your tires. Another method for checking tread depth is to place a penny in the tread with Lincoln’s head upside down and facing you. If you can see the top of Lincoln’s head, you are ready for new tires. To avoid vibration or shaking of the vehicle when a tire rotates, the tire must be properly balanced.
Chapter 4 - Safety Provisions 34
Chapter 5 - Health and Well-being After you first purchase your new recreational vehicle and sometimes after it has been closed up for an extended period of time, you may notice a strong odor and chemical sensitivity. This is not a defect in your recreational vehicle. Like your home, there are many different products used in the construction of recreational vehicles, such as carpet, linoleum, plywood, insulation, upholstery, etc.
Chapter 5 - Health and Well-being collide on wall surfaces, thus creating condensation. • Use a fan to keep air circulating inside the vehicle so condensation and mildew cannot form in dead air spaces. Allow air to circulate inside closets and cabinets (leave doors partially open). Please keep in mind that a closed cabinet full of stored goods prevents circulation and allows the exterior temperature to cause condensation. • The natural tendency would be to close the vehicle tightly during cold weather.
Chapter 5 - Health and Well-being and walls as moisture, or in cold weather as frost or ice. It may also condense out of sight within the walls or the ceiling where it will manifest itself as warped or stained panels. Appearance of these conditions may indicate a serious condensation problem. When you recognize the signs of excessive moisture and condensation in the motorhome, action should be taken to minimize their effects.
Chapter 5 - Health and Well-being 38
Chapter 6 - Plumbing Systems FRESH WATER SYSTEM Your motorhome is self contained, able to carry fresh water in the potable storage tank and hold the waste water in dual holding tanks for dumping when convenient. Water connections are also available for a city water hose hookup to an external pressurized water source. The fresh water storage tank supplies potable water to all fixtures within your motorhome by means of a 12 Volt water pump.
Chapter 6 - Plumbing Systems 1. Drain the fresh water tank by opening the drain valve. All of the faucets should be in the closed or off position. 2. Prepare a solution of 1/4 cup household liquid chlorine bleach (5% sodium hypochlorite) to one gallon of water for every 15 gallons of tank capacity. Do not pour bleach straight into tank. Bleach must be diluted in water prior to filling. Example: Add four 2/3 gallons solution to a 70 gallon tank. Add five 1/3 gallons solution to a 80 gallon tank.
Chapter 6 - Plumbing Systems The holding tanks are enclosed sewer systems, and must be drained into an approved dump station. Tanks should be thoroughly drained and rinsed to prevent any accumulation on the interior of the tanks. 1. Twist off the termination cap counterclockwise. Some liquid may be trapped between the valves. 2. Connect the sewer hose by turning it clockwise, making sure that the connection end levers are locked over the termination end. 3.
Chapter 6 - Plumbing Systems TERMINATION COMPARTMENT COMPONENTS The termination compartment has many operations. Listed below are the fixture call outs and functions: 1. Gloves. 2. City Water Connection. Connect to direct water source. 3. Sewer holding tank flush attachment. Attach the city pressure hose and allow the water to flow for three minutes. Be sure to open the termination valves and have the sewer hose attached and draining into an approved waste disposal system. 4. Swan Valve.
Chapter 7 - Technical Systems The basic utility systems in your unit can be classified under two general titles, Electrical, and Propane. This section outlines these systems, describing their function, operation, and simple maintenance. This section is not intended as a service guide. Should a problem arise, we recommend that you contact your Damon dealer.
Chapter 7 - Technical Systems The inverter converts 12 Volt power from your house batteries to 120 Volt power for your motorhome. The inverter will power the entertainment circuits, which include, the TV and DVD player. Be aware that batteries are a limited power source and will quickly discharge under high loads. ALTERNATING CURRENT SYSTEM The AC electrical system provides grounded electrical power to your 120 Volt electrical appliances through the external shoreline or your power generator.
Chapter 7 - Technical Systems Your motorhome is equipped with a generator, it will provide independent AC power. When the generator is in operation an automatic switch will change the AC appliances to generator power from the previous AC source. A short delay occurs before the switching process is complete to allow the generator to stabilize its output. The generator is mounted to allow for easy access during service functions.
Chapter 7 - Technical Systems This vehicle is designed with a propane system to provide a safe and reliable fuel source for your range, furnace, water heater, and refrigerator. As with any flammable and volatile material, proper handling and precautions should be exercised at all times. The following warnings must be reviewed and adhered to for safe and trouble free operation. Propane containers should not be placed or stored inside the vehicle.
Chapter 7 - Technical Systems The tank has a gauge installed to show the level of propane in the tank. The tank level can be remotely read from the monitor panel. The monitor panel is usually located in the hallway. PROPANE REGULATOR The propane tank has a regulator installed adjacent to the main shut-off valve. The regulator controls the pressure to the appliances as required for proper operation.
Chapter 7 - Technical Systems To access the DVD menu from the dash radio when a DVD is inserted: 1.) Press the MENU button on the remote control to recall the main DVD menu. Use the joystick on the main control to select a title from the menu or touch the title on screen. 2.) Press ENTER button to confirm your selection and begin playback. TROUBLESHOOTING TIPS COMMON TROUBLESHOOTING TIPS. For a complete listing, check the products owners manual. Unit will not power on: Fuse may be blown.
Chapter 8 - Interior Systems Driving a motorhome is similar to driving a car. You have an ignition switch, gearshift controls, turn signals, and dash components. As you sit in the driver’s seat the center of the cluster includes tachometer, speedometer, fuel gauge, oil gauge, temperature gauge, and amp meter. Switches may have symbols to describe their function. See pages 51 and 52 for more detailed information on the function of each switch. Switch locations may be different from model to model.
Chapter 8 - Interior Systems STEERING WHEEL The steering wheel can be moved to allow additional room for entering and exiting the driver’s seat, as well as for selected driving positions. Operate the tilt mechanism by lifting the smaller lever on the left side of the steering column just below the directional signal lever. Move the steering wheel to the desired position and release the lever to secure. Never attempt to adjust the steering wheel while the vehicle is in motion.
Chapter 8 - Interior Systems • People and pets should be clear of the coach while operating leveling system. • Be sure to keep hands and other body parts clear of fluid leaks. Never lift all the wheels off the ground to level the coach. The living room television may operate like the one that is in your home. The controls to the TV are located on its side. You may need to program the TV prior to use. Please see the products owners manual provided for complete instructions.
Chapter 8 - Interior Systems EXTENDING SLIDE ROOM 1. Before operating the system, verify your coach batteries are fully charged. 2. Before extending slide room, verify the following: • Turn chassis ignition off. This system will not function with your key on. Level your motorhome by utilizing the hydraulic leveling jacks.
Chapter 8 - Interior Systems Your bedroom door slides conveniently out of the way beside the wall. Damon provides a stainless steel pin located at the top of the door, to secure the door while the motorhome is in motion. Pull out this pin to allow the bedroom door to close. BEDROOM DOOR & LATCH For your comfort we have 13,500 BTU Carrier air conditioner with heat pumps. There is a remote control for the air conditioners for your convenience. This remote also controls the furnace.
Chapter 8 - Interior Systems 54 KITCHEN FAUCET The faucet in your motor coach is a single lever faucet with sprayer. To use the sprayer, pull out on the head of the faucet. Press the button on top to release the water. To reinsert the hose, gently guide it back to the original position. If you are not hooked up to a pressurized water system at the city water fill, you must turn the water pump switch on. You can find the water pump switch on the monitor panel .
Chapter 9 - Exterior Systems When locking and unlocking the main door, there is a dead bolt and a latch bolt which MAIN ENTRANCE are keyed separately. Unlock both, pull the latch open, and pull out on the door handle. The main entry door is a two piece door. You can use the screen door separately from the main door by unlatching it. Slide the screen handle cover closed to keep insects out of your motorhome. If the door needs adjustment, see a Damon dealer for service.
Chapter 9 - Exterior Systems 120- VOLT OUTLET Plug in 120 Volt AC devices here. The kitchen, bathroom, and outside receptacles are protected by a ground fault current interrupter. If the appliance does not operate, check the circuit breaker located in the 120 Volt breaker box. (See page 42) POWER CORD The 120 Volt power cord is stored in one of the rear compartments on the driver’s side of the motorhome.
Chapter 10 - Care and Maintenance Periodic maintenance and cleaning of your recreational vehicle is necessary to retain the dependability, safety, and appearance that will provide you with many miles of trouble free operation, as well as protecting your investment.
Chapter 10 - Care and Maintenance WASTE WATER SYSTEM The drainage system, including the tanks and associated drain piping should be periodically inspected for loose fittings from vibrations. Any deterioration of the sealant around joints and fittings should be repaired immediately. Check the operation of the termination valves. If they pull or close with effort, lubricate the shaft and slide valve with spray silicone. Termination valves that leak should be repaired or replaced as soon as possible.
Chapter 10 - Care and Maintenance Some components of the recreational vehicle are constructed of strong, lightweight ABS plastic. Sometimes, it may be necessary to remove stains, or generally clean. A mild solution of soap and water will clean many stains, and should be used initially. Tougher stains may require stronger cleaners, but be sure to read the label to determine if the product is recommended for use on plastics.
Chapter 10 - Care and Maintenance Proper engine servicing and record of servicing may be mandatory to ensure chassis warranty protection. Follow the manufacturer’s instructions on periodic maintenance checks. DOORS & DOOR LOCKS Moving parts of the entrance door and lock should be adjusted and lubricated at least once a year or as needed depending on use. Screws and fasteners should be checked and tightened periodically. Check weather-stripping seals to assure proper fit and seal.
Chapter 10 - Care and Maintenance Proper care and maintenance of vinyl graphics or paint is critical in maintaining its appearance. The following cleaning and maintenance recommendations should be followed to ensure the maximum appearance and performance of your vehicle’s custom designed finish: GRAPHICS When washing, flush the surface with water to loosen large particles of dirt and grime. SIDEWALLS Fill a bucket with warm water (not to exceed 120 degrees F.
Chapter 10 - Care and Maintenance and scrub the entire roof. Rinse thoroughly with clean water to avoid residue buildup on the roof or sidewall of the unit. • For more difficult stains contact your Damon dealer for the correct heavy duty cleansers. Do not use general-purpose cleaners containing petroleum solvents, harsh abrasives, or citric based cleaners. If your roof should somehow be punctured, cover the puncture to seal out moisture, and have it repaired as soon as possible (check with your dealer).
Chapter 10 - Care and Maintenance Whenever possible, wipe down the exterior walls before retracting the room to prevent water from draining onto the carpet. The rollers under the slide room are not sealed rollers, therefore, some residue may appear on your carpet. This is a normal function, so be aware and take proper precautions. Vacuum the carpet after each extension of the slide out room. Verify that your house batteries are fully charged before operating the room.
Chapter 10 - Care and Maintenance HYDRAULIC FLUID Check fluid levels. If levels are low, take to your dealer to have the motorhome serviced by a qualified RV technician. The following instructions are guidelines for the care and maintenance of your motorhome. Please refer back to the products Owner’s Manual for more information on the care and maintenance of that product. APPLIANCES Be sure to remove all food and ice from the refrigerator at the end of each trip.
Chapter 10 - Care and Maintenance Keep your blinds looking new by wiping with a soft cloth. Vacuum shades regularly. Use a mild detergent to spot clean if necessary. Close the blinds and shades all the way to properly clean inside and out. MINI BLINDS & ROMAN SHADES Clean with hot soapy water or a good liquid cleaner. Avoid using abrasive cleaners. Never use steel wool on stainless steel, since the steel particles left in the sink can rust and become unsightly.
Chapter 10 - Care and Maintenance 66 WINDOWS Any glass will develop water spots if glass is not cleaned properly. This spotting effect is magnified when glass has a reflective finish. Use a squeegee immediately after washing to reduce water spotting. To remove stubborn water stains from reflective glass, there are several aftermarket specialty glass cleaners. The inside window track must be kept free of debris to keep the drain holes clear.
Chapter 11 - Winter Use and Storage Many people choose to use their motorhomes throughout the entire year. Extensive usage is not recommended in severe cold weather. However, winter traveling can be safe for you and your motorhome if you follow the precautions outlined in this chapter. For those who choose to use their motorhomes only during the warmer months, winter storage is necessary.
Chapter 11 - Winter Use and Storage unit around for a few miles will allow the cleanser to circulate within the tanks and drains. Drain and flush once more with fresh water. • After all the tanks have been drained, make sure that any water remaining in the lines is either blown out, or replaced with a nontoxic RV antifreeze solution which will prevent any water that remains from freezing.
Chapter 11 - Winter Use and Storage Draining the tanks and water lines in your motorhome is half the battle of winterization. Complete the Storage and Winterization Checklist (page 70) to ensure protection of your motorhome. An authorized Damon service dealer can help you in the winterization process for your convenience. A water heater bypass valve system is located inside your motorhome usually behind the water heater. When the system is closed, water is shut off to the water heater.
Chapter 11 - Winter Use and Storage WINTERIZATION CHECKLIST Chassis – Run engine for 30 minutes once a month if possible. Prepare as outlined in the Chassis Owner’s Manual. Generator – Prepare as outlined in the Generator Owner’s Manual. Plumbing Lines – Drain and protect by filling with approved RV antifreeze. (See pages 67 - 69) Water Heater – Drain. (Pages 67 - 69) Toilet – Drain. Hold pedal down and pour RV antifreeze into bowl.
Chapter 11 - Winter Use and Storage the proper electrolyte level and that they are fully charged. A discharged battery will freeze and may crack the case, causing severe damage to the battery and surrounding area. In storage, a battery will lose charge gradually over a 30 to 45 day period, even when disconnected by the use of the Battery Disconnect Switch. We recommend that the batteries be checked for charge at least monthly.
Chapter 11 - Winter Use and Storage 72
PRIOR TO STORAGE AS REQUIRED EVERY YEAR EVERY 6 MONTHS EVERY 3 MONTHS EVERY MONTH EVERY TRIP Maintenance Schedule PROCEDURE TO BE PREFORMED: Maintenance x x Inspect & reseal roof & exterior attachment areas. ITEM Roof & Components x x Clean roof. x Fiberglass Exterior x x Wax w/ liquid or nonabrasive wax. x Seals & Adhesives Check vinyl seals when washing exterior. x Check seals for damage & repair as needed. x Lubricate door hinges & step components w/spray grease.
Travel Preparation Checklist CLOTHING SLEEPING GEAR MISCELLANEOUS Dresses Blankets Alarm Clock Gloves Pillows, Pillow Cases Batteries Hat or Cap Sheets Bucket Jackets, Coats Sleeping Bags Clothes Hangers Jeans, Dress Pants Clothes Line, Clothes Pins Pajamas Electronics Chargers Shirts, Blouses PERSONAL COMFORT Fresh Water Hose Shoes, Sandals Anti-Bacterial Wet Wipes Fuses Shorts Ash Tray Ground Extension Wire Socks Personal Medications Umbrella Sweaters Personal Toiletries Wheel Chocks Swimsuits
Maintenance Schedule Date Service Preformed Mileage Date Service Preformed Mileage 75
Maintenance Schedule Date 76 Service Preformed Mileage Date Service Preformed Mileage
Fuel / Oil Record Date Mileage Fuel Oil (Gallon) (Quarts) MPG Date Mileage Fuel Oil (Gallon) (Quarts) MPG 77
Fuel / Oil Record Date 78 Mileage Fuel Oil (Gallon) (Quarts) MPG Date Mileage Fuel Oil (Gallon) (Quarts) MPG
Notes 79
Notes 80
Troubleshooting Checking the fuses. • The Battery Control Center is built in two layers, the printed circuit board and the relays. The box has been designed so that nearly all troubleshooting can be done without the removal of the printed circuit board. Have a Damon dealer remove the circuit board if necessary. • Check fuses visually or with an electrical tester. • Check for power on both sides of the fuse. • Replace the fuse with a new one of the same ampere.
Troubleshooting • Furnace does not light and fan does not run. • Replace fuse with one of the same ampere rating. Turn thermostat and furnace gas control valve off and contact your dealer or an authorized service center. DO NOT attempt to repair or adjust the furnace yourself. GENERATOR Starter engages while holding the start button down, but generator does not start. • Generator may be out of fuel. Check the chassis fuel level.
Troubleshooting Ignition switch is on, but no power to pump and/or control panel. • Parking brake is not set. • 12 Volt from power source is not available. Check the in-line fuse under the dash by the O.E.M. fuse panel. • Faulty wire or electrical connection. Have checked by a qualified service technician. Pump will not activate. • Grounding switch on valve is not working. • Pump relay not functioning. • Pump not grounded. Hydraulic pump activates without use of control valve pad.
Troubleshooting Holding tank lights deliver false readings (i.e., 1/3 or 2/3 indication). • Verify tank is empty. • Debris may be built up across probes. Clean and flush tank using four parts vinegar mixed to two parts water. Propane indicator display indicates E or F all the time. OUTSIDE RECEPTACLE OVEN • Ensure propane gas tank is full. • If display is F, check the wiring or sending unit for malfunction. • Have it inspected by a certified technician. No power to outside receptacle.
Troubleshooting Lights are illuminating, but no cooling. • Use a proper power source that is available and cooling operation to specification. • Make sure the refrigerator unit is level. • Allow sufficient time for proper cool down and try to load with precooled food. • Have a qualified RV technician check that the vents and chimney at the rear of the refrigerator are clear and unobstructed. • Have a qualified RV technician make sure the burner jets or burners are not dirty or damaged.
Troubleshooting SATELLITE DISH Dish does not rotate or is hard to rotate. • Check antenna on roof, make sure that the mount has not been damaged. • Check for caulking between gear housing and base plate. • Be sure cables are not binding. Dish does not raise or is hard to rise. • Check antenna on roof, make sure that the mount has not been damaged. • Check for caulking on elevating shaft. Poor Reception.
Troubleshooting • Cut or torn cable. Have a Damon dealer or a qualified RV technician replace bad cable where needed at TV and antenna. Elevation handle turns, but antenna does not raise or lower. • Handle may be loose. Tighten screws. • Gears may be stripped. Have a Damon dealer or a qualified RV technician replace the gears. Antenna will not rotate. • The rotate handle is engaged to the ceiling plate. Pull down on handle to disengage from the ceiling plate.
Troubleshooting Refill with fresh water, circulate and rinse. • WATER PUMP If you use your vehicle frequently or for long periods of time, flushing the water heater several times a year will prolong the life of the water heater storage tank. Pump will not start. • Check that house battery disconnect switch is on. • Check pump switch at monitor panel. • Check fuse in power center. • Check to see if water is frozen. Will not prime, sputters. (No discharge, but the motor runs.).
Electrical Diagrams 89
Electrical Diagrams 90
Electrical Diagrams Avanti 91
Electrical Diagrams 92
Electrical Diagrams 93
Electrical Diagrams 94
Electrical Diagrams 95
Electrical Diagrams 96
Electrical Diagrams 97
Electrical Diagrams 98
Electrical Diagrams 99
Electrical Diagrams 100
Index 120 Volt Outlet A/C & Furnace Thermostat ABS Plastic Parts Air Pressure Alignment Appliances Assist Handle Automotive Dash Automotive Fuse Block Awning Backup Monitor Bath Fixtures Bath Vent Bathtub Seal Batteries Battery Control Center (BCC) Bedroom Door Latch Bedspread & Drapes Cabinets & Drawers Capacity Carbon Monoxide Precautions Carpet Changing Tires Chassis Chassis Electrical Chemical Sensitivity City Water Hook-up CO Detector Coach Electrical Compartment Doors Condensation Controlling the Moto
Index Range Rear Ladder Refrigerator Refrigerator Panel Reporting Safety Defects Retracting the Slideroom Roof Roof Air Conditioner Safety Belts Sanitizing the Fresh Water System Seals & Adhesives Shower Head and Hose Sidewalls Sink Slideout Smoke Detector Smoking Solid Surface Countertop Steering Wheel Temperature Control Termination Compartment Components Tips to Control Condensation Tire Care Tires Toilet Towing and GCWR Trailer Hitches and Towing TRAVEL PREPARATION CHECKLIST TV Antenna Underbody Upholst
Damon Motor Coach P.O. Box 2888 Elkhart, IN.
