Use and Care Manual

ManualsBrandsAZ Patio Heaters ManualsHeating, Ventilation, and Air Conditioning38,000 BTU Commercial Stainless Steel Quartz Tube Gas Patio Heater

GAS

PATIO HEATER

MODEL #BSH-A-SS

Français p. 26

Español p. 51

Serial Number

Purchase Date

Questions, problems, missing parts? Before returning to your retailer, call our

customer service department at 1-8888-775-1330, 8 a.m. - 4 p.m., P

ST, Monday -

Friday.

ANS Z83.26-2007/CSA 2.37-2007 Gas-Fired Outdoor Infrared Patio Heaters

ANS Z83.26a-2008/CSA 2.37a-2008 Gas-Fired Outdoor Infrared Patio Heaters

ATTACH YOUR RECEIPT HERE

FOR YOUR SAFETY

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open ame.

3. If odor continues, keep away from

the appliance and immediately call

your gas supplier or re department.

Do not store or use gasoline or other

ammable vapors and liquids in the

vicinity of this or any other appliance.

An LP-cylinder not connected for use

shall not be stored in the vicinity of

this or any other appliance.

WARNING

! WARNING: For Outdoor Use Only

CARBON MONOXIDE

HAZARD

This appliance can

produce carbon monoxide

which has no odor. Using

it in an enclosed space

can kill you. Never use

this appliance in an

enclosed space such as a

camper, tent or home.

! DANGER

DANGER

Summary of content (13 pages)

PAGE 1
GAS PATIO HEATER MODEL #BSH-A-SS Français p. 26 Español p. 51 ! DANGER FOR YOUR SAFETY If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flame. 3. If odor continues, keep away from the appliance and immediately call your gas supplier or fire department. ! WARNING Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.
PAGE 2
TABLE OF CONTENTS PACKAGE CONTENTS Package Contents............................................................................................................... 3 A Hardware Contents...............................................................................................................4 B Safety Information............................................................................................................... 4 C D Preparation .........................................................
PAGE 3
HARDWARE CONTENTS (shown actual size) AA AA BB BB Wing Nut Qty. 3 CC CC Fixing Bracket Qty. 3 DD DD HH LL MM Chain Qty. 1 (not actual size) JJ II M8 Cap Nut Qty. 3 M8 Nut Qty. 3 EE EE M5 x 12 mm Screw Qty. 42 Stud Qty. 6 Small Flat Washer Qty. 6 GG FF SAFETY INFORMATION NN Wafer Qty. 1 OO Wrench Qty. 1 (not actual size) M4 x 10 mm Screw Qty. 1 KK M4 Nut Qty. 1 Knob Qty. 1 M6 x 10 mm Bolt Qty. 8 Phillips Screwdriver Qty.
PAGE 4
SAFETY INFORMATION SAFETY INFORMATION WARNING • CARBON MONOXIDE HAZARD • We cannot foresee every use that may be made of our heaters. • Check with your local fire safety authority if you have questions about heater use. • Other standards govern the use of fuel gases and heat producing products for specific uses. Your local authorities can advise you about these. • Never use inside house, or other unventilated or enclosed areas. • This heater consumes air (oxygen).
PAGE 5
ASSEMBLY INSTRUCTIONS SAFETY INFORMATION WARNING: Two people are required to safely assemble the product! A dented, rusted or damaged propane cylinder may be hazardous and should be checked by your cylinder supplier. Never use a propane cylinder with a damaged valve connection. 1 1 The propane cylinder must be constructed and marked in accordance with the specifications for LP gas cylinders of the U.S.
PAGE 6
ASSEMBLY INSTRUCTIONS ASSEMBLY INSTRUCTIONS 3. Use Phillips screwdriver (OO) to secure the block belt (L) to the lower supports (K) with M5 x 12 mm screws (DD). 3 5. Use Phillips screwdriver (OO) to secure the top plate (D) to the upper supports (E) with M5 x 12 mm screws (DD). 5 DD D Hardware Used Hardware Used DD M5 x 12 mm Screw x4 DD M5 x 12 mm Screw x6 OO Philips Screwdriver x1 OO Philips Screwdriver x1 E K L 4.
PAGE 7
ASSEMBLY INSTRUCTIONS ASSEMBLY INSTRUCTIONS 7. Carefully install the glass tube (G) between the center of top plate (D) and control box assembly (I). Make sure the end of the glass tube (G) is inserted securely into the three clips of the control box assembly (I). 7 D G 9 9. Use Phillips screwdriver (OO) to install side panels (J) to bottom of assembly with M5 x 12 mm screws (DD). Note: Do not cover the panel where the control knob is.
PAGE 8
ASSEMBLY INSTRUCTIONS ASSEMBLY INSTRUCTIONS 11 11. Use Phillips screwdriver (OO) to install protective guards (F) to the upper supports (E) with M5 x 12 mm screws (DD) and fixing brackets (FF) as shown. 13. Secure the table connect panel (R) to the side door with M5 x 12 mm bolts (DD). Install table (Q) by putting the preassembled bolts through the holes of the table connect panel (R). Repeat for the other side door.
PAGE 9
OPERATING INSTRUCTIONS ASSEMBLY INSTRUCTIONS 15. Connect gas hose and regulator (P) to control box assembly (I). Do not cross-thread. 15 I WARNING: Ensure gas hose does not contact any high temperature surfaces, or it may melt and leak causing a fire. P To check for a leak: 1. Make 2-3 oz. leak check solution (one part liquid dishwashing detergent and three parts water). 2. Apply several drops of solution where regulator connects to cylinder and to all hose and valve connections 3.
PAGE 10
OPERATING INSTRUCTIONS ! OPERATING INSTRUCTIONS DANGER • CARBON MONOXIDE HAZARD • For outdoor use only. Never use inside house, or other unventilated or enclosed areas. This heater consumes air (oxygen). Do not use in unventilated or enclosed areas to avoid endangering your life. Caution: Do not attempt to operate the heater until you have read and understand all Safety Information in this manual and all assembly is complete and leak checks have been performed. Before Turning Gas Supply ON: 1.
PAGE 11
OPERATING INSTRUCTIONS ! OPERATING INSTRUCTIONS Heater is away from gasoline or other flammable liquids or vapors. Heater is away from windows, air intake openings, sprinklers and other water sources. Heater is at least 24 in. on top and at least 36 in. on sides from combustible materials. Heater is on a hard and level surface. There are no signs of spider or insect nests. All burner passages are clear. All air circulation passages are clear.
PAGE 12
CARE AND MAINTENANCE TROUBLESHOOTING Between uses: • Turn Control Knob OFF. • Disconnect LP source. • Store heater upright in an area sheltered from direct contact with inclement weather (such as rain, sleet, hail, snow, dust and debris). • If desired, cover heater to protect exterior surfaces and to help prevent build up in air passages. Note: Wait until heater is cool before covering. During periods of extended inactivity or when transporting: • Turn Control Knob OFF.
PAGE 13
WARRANTY REPLACEMENT PARTS LIST CUSTOMERS IN USA Do not return this product to the store where you purchased it. Please call 1-888-775-1330 for assistance. For replacement parts, call our customer service department at 1-888-775-1330, 8 a.m. - 4 p.m., PST, Monday - Friday. CUSTOMERS IN CANADA Only return this product to the store if it was purchased within 90 days. If you have problems after 90 days of purchase, please CALL 1-888-775-1330. DATED PROOF OF PURCHASE REQUIRED FOR WARRANTY SERVICE.