Owner`s manual

ManualsBrandsBakers Pride ManualsCooktop60BP10BS30S20

INSTALLATION AND OPERATION MAINTENANCE

BP SERIES – RANGE

OWNER’S MANUAL

Models:

24BP4BS20, 36BP6BS30, 48BP8BS20

60BP10BS26, 60BP10BS30S20, 60BP6BG24S26

60BP6BG24S30S20, 60BP6BRG24S26, 60BP6BRG24S30S20

65BP10BS30, 72BP12BS30

All equipments manufactured by Bakers Pride Oven Co. Inc. for use with the type of gas specified on

the rating plate and for installation will be in accordance with National Fuel Gas Code ANSI Z223.1

(latest edition)

FOR YOUR SAFETY: Do not store or use gasoline or other flammable vapors or

liquids in the vicinity of this or any other appliance.

WARNING: Improper installation, adjustment, alteration, service or maintenance

can cause property damage, injury or death. Read the installation, operating and

maintenance instructions thoroughly before installing or servicing this equipment.

Instructions to be followed in the event the user smells gas must be posted in a prominent location in

the kitchen area. This information shall be obtained from the local gas supplier.

PLEASE RETAIN THIS MANUAL FOR FUTURE REFERENCES.

P/N 312644 03/11

BAKERS PRIDE OVEN CO. INC.,

2205 South Standard Avenue

Santa Ana, CA 92707

(714) 424-9380 Phone

(714) 424-9385 Fax www.bakerspride.com Web address

Summary of content (15 pages)

PAGE 1
INSTALLATION AND OPERATION MAINTENANCE BP SERIES – RANGE OWNER’S MANUAL Models: 24BP4BS20, 36BP6BS30, 48BP8BS20 60BP10BS26, 60BP10BS30S20, 60BP6BG24S26 60BP6BG24S30S20, 60BP6BRG24S26, 60BP6BRG24S30S20 65BP10BS30, 72BP12BS30 All equipments manufactured by Bakers Pride Oven Co. Inc. for use with the type of gas specified on the rating plate and for installation will be in accordance with National Fuel Gas Code ANSI Z223.
PAGE 2
TABLE OF CONTENTS Installation Instructions .............................................................................................................................2 Operating Instructions...............................................................................................................................3 Maintenance Instructions ..........................................................................................................................3 Cleaning and Maintenance ................
PAGE 3
OPERATING INSTRUCTIONS Operation of this equipment must be performed by qualified or authorized personnel who have read and are familiar with the functions of the equipment. MAINTENANCE INSTRUCTIONS RATING PLATE The rating plate is located in front of the range below the oven section. Information on this plate includes the model, serial number, BTU / hour input of the burners, operating gas pressure in inches WC, and whether the appliance is orificed for natural or propane gas.
PAGE 4
AIR SUPPLY & VENTILATION The area in front of, around and above the appliance must be kept clear to avoid any obstruction of the flow of combustion and ventilation air. Adequate clearance must be maintained around the appliance for easy servicing. Provision should be made for any commercial, heavy duty cooking appliance exhaust combustion waste products to the outside of the building.
PAGE 5
FLEXIBLE COUPLINGS, CONNECTOR AND CASTERS For an appliance equipped with casters, the installation shall be made with a connector that complies with the Standard for Connectors for Movable Gas Appliances, ANSI Z21.69 or Connectors for Moveable Gas Appliances, CAN/CGA-6.16, and a quick disconnect device that complies with the Standard for Quick Disconnect Devices for Use With Gas Fuel, ANSI Z21.41, or Quick Disconnect Devices for Use With Gas Fuel, CANI-6.9.
PAGE 6
Oven pilot lighting or relighting is to be completed as follows: • Turn the thermostat knob to "OFF" position and wait for 5 minutes. • Open the oven’s lower kick plate by lifting up and out. This exposes the pilot valve and the igniter button. • Make sure accumulated gas if any has dispersed. Since propane gas is heavier than air, check near the floor area for the odor of propane gas before attempting to light any pilot burner.
PAGE 7
CLEANING AND MAINTENANCE Any equipment works better and lasts longer when maintained properly. Cooking equipment is no exception. Your Bakers Pride range and Oven must be kept clean on a daily basis. CAUTION: Never use Ammonia in an oven that is warmer than room temperature and always have direct ventilation! DAILY MAINTENANCE OPEN BURNERS • • • • Remove all top grates. Lift off the burner heads and venturies by raising the head slightly, sliding to the rear of the range and lifting upwards.
PAGE 8
arms connect to the door. Use lubricating oil. Ensure your Bakers Pride range be checked by a qualified technician once a year for efficient operation of the appliance. STAINLESS STEEL All stainless steel body parts should be wiped regularly with hot soapy water during the day and with a liquid cleaner designed for this material at the end of each day. DO NOT USE steel wool, abrasive cloth, or powders to clean stainless surfaces.
PAGE 9
BAKERS PRIDE – RANGE SERIES 9
PAGE 10
BAKERS PRIDE – RANGE SERIES WITH GRIDDLES AND RAISED GRIDDLES Item Part # Description Item Part # 1 2 3 311016 312619 312618 311031 311032 310510 310266 TOP GRATE 12" X 12" BURNER LONG VENTURI BAKERS PRIDE BURNER SHORT VENTURI BAKERS PR RACK 20" OVEN RACK 26 1 /2" OVEN RACK 30" OVEN BURNER HANGER 18 19 20 314010 310299 310295 RACK 24" RAISED GRIDDLE KNOB OVEN RANGE 500 BEZEL THERMOSTST 21 310154 KNOB METAL BLUE STRIP SET SCREW 22 312634 312635 CRUMB TRY 24" RANGE S/S CRUMB TRY 36" RANGE S/S
PAGE 11
Item 34 Part # 311011 390210 390211 Description PILOT SAFETY VALVE CASTER 5" PLATE CASTER 5" PLATE WITH BRAKE 311039 314815 312613 316012 312623 316415 316210 310354 310226 311029 311044 310345 310124 310235 310366 311715 315716 311814 LEG 6" STAINESS LANDING LEDGE 24" BAKERS PRIDE LANDING LEDGE 36" BAKERS PRIDE LANDING LEDGE 48" BAKERS PRIDE LANDING LEDGE 60" BAKERS PRIDE LANDING LEDGE 24"RAISED GRIDDLE BP LANDING LEDGE 72" BAKERS PRIDE REGULATOR NAT 24"-36" RANGES REGULATOR LP 24"-36" RANGES REGULATO
PAGE 12
RAISED GRIDDLE & FLAT GRIDDLE BAKERS PRIDE – RANGE SERIES 12
PAGE 13
RAISED GRIDDLE & FLAT GRIDDLE BAKERS PRIDE – RANGE SERIES Item 1 2 Part # 310476 316410 312307 310477 316415 310478 3 4 5 6 7 318321 315728 311026 314009 314010 314011 310479 318328 310480 Description 12" RAISED GRIDDLE PLATE 1" 24" RAISED GRIDDLE PLATE 1" 36" RAISED GRIDDLE PLATE 1" 12" LANDING LEDGE RAISED GRIDDLE BP 24" LANDING LEDGE RAISED GRIDDLE BP 36" LANDING LEDGE RAISED GRIDDLE BP GREASE CAN RAISED GRIDDLE RADIANT BURNER INSIDE BURNER STRAIGHT RACK 12" RAISED GRIDDLE RACK 24" RAISED GRIDDLE RA
PAGE 14
BAKERS PRIDE LIMITED WARRANTY 2205 S.
PAGE 15
BAKERS PRIDE OVEN CO. INC 2205 S. Standard Avenue Santa Ana, CA 92707 (714) 424-9380 Phone (714) 424-9385 Fax www.bakerspride.