Safety Data Sheet 1. 1.1 Product Name 1.2 Distributor Identification BATHWORKS® DIY Refinishing Kit - Part A Base Color Munro Products (716) 741-9450 9150 Clarence Center Road Clarence www.bath-works.net Center, NY 14032 1.3 Emergency Information CHEMTREC® Poison Control Center (800) 424-9300 (800) 854-6813 2. Hazard Identification 2.1 Classification of the substance or mixture Flam. Liq. 3; H226 Flammable liquid and vapor. Org. Perox. C; H242 Heating may cause a fire. Skin Irrit.
P331 Do NOT induce vomiting. P332+313 If skin irritation occurs: Get medical advice/attention. P333 If skin irritation or a rash occurs:. P337 If eye irritation persists:. P363 Wash contaminated clothing before reuse. P370 In case of fire: Use water spray, fog, or regular foam.. P403+233 Store in a well ventilated place. Keep container tightly closed. P410 Protect from sunlight. P420 Store away from other materials. P501 Dispose of contents / container in accordance with local / national regulations. 2.
[1] Substance classified with a health or environmental hazard. [2] Substance with a workplace exposure limit. [3] PBT-substance or vPvB-substance. *The full texts of the phrases are shown in Section 16 4. First Aid 4.1 General First Aid Measures General Remove contaminated clothing and shoes. Get medical attention immediately. Wash clothing before reuse. Thoroughly clean or destroy contaminated shoes. Inhalation If inhaled, remove to fresh air. If not breathing, give artificial respiration.
6. Accidental Release 6.1 Personal precautions, protective equipment and emergency procedures ELIMINATE ALL IGNITION SOURCES (no smoking, flares, sparks or flames in immediate area). Use only non-sparking equipment to handle spilled material and absorbent. Do not touch or walk through spilled material. Stop leak if you can do so without risk. Prevent entry into waterways, sewers, basements or confined areas. A vapor suppressing foam may be used to reduce vapors.
0000123-86-4 BUTYL ACETATE OHSA, CAN No Established Limit Mexico Brazil OSHA No Established Limit No Established Limit 150 ppm TWA; 710 mg/m3 TWA200 ppm STEL; 950 mg/m3 STEL 150 ppm TWA200 ppm STEL 150 ppm TWA; 710 mg/m3 TWA200 ppm STEL; 950 mg/m3 STEL1700 ppm IDLH (10% LEL) ACGIH NIOSH 0000614-45-9 0007631-86-9 0007727-43-7 BUTYL PEROXYBENZOATE Silica, amorphous Barium sulfate Supplier OHSA, CAN No Established Limit 150 ppm TWA200 ppm STEL Mexico Brazil OSHA ACGIH NIOSH Supplier OHSA, CAN
0041556-26-7 0082919-37-7 Bis (1,2,2,6,6-pentamethyl-4piperidinyl) sebacate Mexico Brazil OSHA ACGIH NIOSH Supplier OHSA, CAN No Established Limit No Established Limit No Established Limit No Established Limit No Established Limit No Established Limit No Established Limit DECANEDIOIC ACID, METHYL 1,2,2,6,6PENTAMETHYL-4-P Mexico Brazil OSHA ACGIH NIOSH Supplier OHSA, CAN No Established Limit No Established Limit No Established Limit No Established Limit No Established Limit No Established Limit No Est
IARC 0000110-43-0 0000122-51-0 0000123-86-4 0000614-45-9 0007631-86-9 0007727-43-7 0013463-67-7 0021645-51-2 0041556-26-7 0082919-37-7 Proprietary Proprietary Methyl n-amyl ketone Ethyl orthoformate BUTYL ACETATE BUTYL PEROXYBENZOATE Silica, amorphous Barium sulfate Titanium dioxide Aluminum hydroxide OSHA NTP IARC OSHA NTP IARC OSHA NTP IARC OSHA NTP IARC OSHA NTP IARC OSHA NTP IARC OSHA NTP IARC OSHA NTP IARC Bis (1,2,2,6,6-pentamethyl-4piperidinyl) sebacate OSHA NTP IARC DECANEDIOI
Respiratory Select equipment to provide protection from the ingredients listed in Section 3 of this document. Ensure fresh air entry during application and drying. If you experience eye watering, headache or dizziness or if air monitoring demonstrates dust, vapor, or mist levels are above applicable limits, wear an appropriate, properly fitted respirator (NIOSH approved) during and after application. Follow respirator manufacturer's directions for respirator use.
Viscosity (cSt) No Established Limit Not Measured VOC % Refer to the Technical Data Sheet or label where information is available. 10.1. Reactivity 10.2. Chemical stability 10.3. Possibility of hazardous reactions 10.4. Conditions to avoid 10.5. Incompatible materials 10.6. Hazardous decomposition products 10. Stability & Reactivity No data available This product is stable and hazardous polymerization will not occur. Not sensitive to mechanical impact.
Mixed Diamedes Compound (Proprietary) (Proprietary) Dicumyl peroxide - (80-43-3) BUTYL PEROXYBENZOATE - (614-45-9) Bis(1,2,2,6,6-pentamethyl-4-piperidinyl) sebacate - (41556-26-7) DECANEDIOIC ACID, METHYL 1,2,2,6,6PENTAMETHYL-4-P - No data available No data available No data available No data available 4,000.00, Rat - Category: 5 4,838.00, Rat - Category: 5 No data available No data available No data available 2,000.00, Rabbit - Category: 4 No data available 4.90, Rat Category: 4 2,615.
BUTYL PEROXYBENZOATE - (614-45-9) 1.50, Danio rerio Not Available Not Available Bis (1,2,2,6,6-pentamethyl-4-piperidinyl) sebacate (41556-26-7) DECANEDIOIC ACID, METHYL 1,2,2,6,6PENTAMETHYL-4-P - (82919-37-7) 1.00, Lepomis macrochirus 20.00, Daphnia magna Not Available Not Available Not Available Not Available 12.2 Persistence and degradability 12.3 Bioaccumulative potential No data available Not Measured 12.4 Mobility in soil No data available 12.
Mass RTK Substances (>1%) : Penn RTK Substances (>1%) : Penn Special Hazardous Substances (>.01%) : RCRA Status: N.J. RTK Substances (>1%) : N.J. Special Hazardous Substances (>.01%) : N.J. Env. Hazardous Substances (>.
H410 Very toxic to aquatic life with long lasting effects. H411 Toxic to aquatic life with long lasting effects. Tub Refinishing Inc.
Safety Data Sheet 1. Identification BATHWORKS® DIY Refinishing Kit – Part B Base Hardener Munro Products (716) 741-9450 9150 Clarence Center Road Clarence Center, NY 14032 www.bath-works.net 1.1 Product Name 1.2 Distributor 1.3 Emergency Information 2.1. CHEMTREC® Poison Control Center (800) 424-9300 (800) 854-6813 2. Hazard Identification Classification of the substance or mixture Flam. Liq. 3; H226 Flammable liquid and vapor. Skin Sens. 1; H317 May cause an allergic skin reaction. Resp. Sens.
P403+233 Store in a well ventilated place. Keep container tightly closed. 2.3 HMIS Rating Health: 3 Flammability: 3 Reactivity: 0 3. Ingredient Composition This product contains the following substances that present a hazard within the meaning of the relevant State and Federal Hazardous Substances regulations.
5.1. Extinguishing media 5.2. Special hazards arising from the substance or mixture 5.3. Advice for firefighters 5.4. ERG Number 5. Firefighting CAUTION: This product has a very low flashpoint. Use of water spray when fighting fire may be inefficient. CAUTION: For mixtures containing alcohol or polar solvent, alcohol-resistant foam may be more effective. SMALL FIRES: Use dry chemical, CO2, water spray or regular foam. LARGE FIRES: Use water spray, fog, or regular foam. Do not use straight streams.
0000123-86-4 BUTYL ACETATE OSHA ACGIH NIOSH Supplier OHSA, CAN Mexico 0000822-06-0 Hexamethylene diisocyanate Brazil OSHA ACGIH NIOSH Supplier OHSA, CAN 0028182-81-2 Hexamethylene diisocyanate homopolymer 0064742-95-6 Petroleum naphtha Mexico Brazil OSHA ACGIH NIOSH Supplier OHSA, CAN Mexico Brazil OSHA ACGIH NIOSH Supplier OHSA, CAN Mexico Brazil 150 ppm TWA; 710 mg/m3 TWA 200 ppm STEL; 950 mg/m3 STEL 150 ppm TWA 200 ppm STEL 150 ppm TWA; 710 mg/m3 TWA 200 ppm STEL; 950 mg/m3 STEL 1700 ppm ID
0064742-95-6 Petroleum naphtha NIOSH Ingredient BUTYL ACETATE Source OSHA NTP IARC No Established Limit Carcinogen Data CAS No. 0000123-86-4 0000822-06-0 0028182-81-2 0064742-95-6 Hexamethylene diisocyanate OSHA NTP IARC Hexamethylene diisocyanate homopolymer OSHA NTP IARC Petroleum naphtha OSHA NTP IARC 8.2.
soiled clothing and wash clothing thoroughly before reuse. Shower after work using plenty of soap and water. Appearance 9.
harmful or fatal. Ingredient Hexamethylene diisocyanate homopolymer - (28182-81-2) BUTYL ACETATE - (123-86-4) Petroleum naphtha - (64742-95-6) Hexamethylene diisocyanate (822-06-0) Oral LD50, mg/kg 5,000.00, Rat - Category: 5 10,700.00, Rat - Category: NA 6,800.00, Rat -Category: NA No data available Skin LD50, mg/kg No data available 17,600.00, Rabbit - Category: NA 3,400.
13.1 Waste treatment methods Do not allow spills to enter drains or watercourses. Dispose of in accordance with local, state and federal regulations. (Also reference RCRA information in Section 15 if listed). 14. Transportation Information 14.1 UN number 14.2 UN proper shipping name 14.3 Transport hazard class(es) Proper Shipping Name UN Number Hazard Class Packaging Group UN 1263 PAINT DOT (Domestic Surface Transportation) PAINT UN 1263 3 III CERCLA/DOT RQ: 5359 gal. / 50000 lbs. 14.
Proposition 65 - Female Repro Toxins (>0%): Proposition 65 - Male Repro Toxins (>0%): (No Product Ingredients Listed) Proposition 65 - Developmental Toxins (>0%): (No Product Ingredients Listed) SDS Revision Date: (No Product Ingredients Listed) 16. Other Information 3/11/2014 The information and recommendations contained herein are based upon data believed to be correct. However, no guarantee or warranty of any kind, expressed or implied, is made with respect to the information contained herein.
Safety Data Sheet 1. Identification BATHWORKS® DIY White High Speed Filler BATHWORKS® Chip Filler Munro Products (716) 741-9450 9150 Clarence Center Road Clarence Center, NY 14032 www.bath-works.net 1.1 Product Name 1.2 Distributor 1.3 Emergency Information CHEMTREC® Poison Control Center 2. 2.1 Classification of the substance or mixture: (800) 424-9300 (800) 854-6813 Hazard Identification Flammable Liquids 3 Skin Corrosion/Irritation 2 Eye Damage/Irritation 2B Acute Toxicity-Inhalation 4 2.
3. 3.1 Mixtures Chemical Identity Polyester Resin Unsaturated Polyester Resin Styrene Monomer Sodium Borosilicate Glass Magnesium Silicate Barium Sulfate Titanium Dioxide m-Tolyl Diethanolamine Methyl Alcohol Ingredient Composition CAS No. 28472-89-1 Proprietary 100-42-5 65997-17-3 14807-96-6 7727-43-7 13463-67-7 91-99-6 67-56-1 Concentration 20% 3% 10% 5% 40% 10% 10% 1% 1% 4. First Aid 4.
5.3 Flash Point: 5.4 Special protective actions for fire-fighters: violent rupture of the container. Combustion may produce carbon monoxide, carbon dioxide and irritating or toxic vapors and gases. 89° F (32 ° C). Wear self-contained breathing apparatus (SCBA) and full fire-fighting protective clothing. Thoroughly decontaminate all protective equipment after use. Evacuate all persons from the fire area to an explosion-protected location.
8. 8.1 Control parameters Component CAS No. Exposure Controls & Personal Protection EINECS Exposure Limits Source 100 ppm PEL OSHA Styrene 100-42-5 202-851-5 10% - 12% 20ppm TWA ACGIH 40 ppm STEL ACGIH 8.2 Appropriate engineering Local ventilation may be required during certain operations to maintain controls: concentrations below recommended exposure limits. Use explosion-proof ventilation equipment. 8.
9.16 Auto-ignition temperature: 9.17 Decomposition temperature: 9.18 Viscosity: 9.19 Volatile Organic Compounds: 10.1 Reactivity: 10.2 Chemical stability: 10.3 Possibility of hazardous reactions: 10.4 Conditions to avoid: N/A 10.5 Incompatible materials: 10.6 Hazardous decomposition products: 914° F (490° C) N/A N/A 12% by mass (186 g/liter) 10. Stability & Reactivity N/A Stable at normal temperatures and storage conditions.
assay. 11.4 Numerical measures of toxicity: Ingredient Name CAS No. m-Tolyldiethanolamine 91-99-6 % 0.5% - 1% Styrene 100-42-5 10% - 12% Test LD50 LD50 LD50 LD50 Result Route Species 0.8 – 3.1 g/kg 24 g/m3, 4 hrs. 5g/kg 5g/kg Oral Inhalation Oral Dermal Rat Rat Rat Rabbit 12. Ecological Information 12.1 Ecotoxicity: Chemical Name CAS No. % Test Concentration Result Species Styrene 100-42-5 10% - 12% LC50 23 mg/L 48 hrs.
CERCLA: SARA Title III: Section 311/312 - Hazard Communication Standard (HCS): SARA Title III: Section 313 Toxic Chemical List (TCL): TSCA Section 8(b) - Inventory Status: TSCA Section 12(b) - Export Notification: This material is classified as an IMMEDIATE HEALTH HAZARD, DELAYED HEALTH HAZARD, FLAMMABILITY HAZARD, and REACTIVITY HAZARD under the US Superfund Amendment and Reauthorization Act (Section 311/312).