TUNGSTEN User Manual Thank you for purchasing a BATRIBIKE Electric Bicycle from Fallowgate Limited. With care and correct usage your bicycle will give many years of service. Please read the manual fully before use.
MODEL:- TUNGSTEN SERIAL NUMBER:- PURCHASE DATE:- / DAY / MONTH YEAR IMPORTANT PLEASE READ THIS MANUAL FULLY PRIOR TO ASSEMBLY AND USE For your safety and to ensure a long and trouble free life of your bicycle, check the operation of brakes, lights, tyre pressures, bell and gears. Also check all fasteners, including quick release mechanisms, before every ride. Service & Spares Cables may stretch a little during the first few uses.
Usage Instructions Important PLEASE CHARGE THE BATTERY BEFORE FIRST USING THE BICYCLE. Even though the battery indicator will show charge this cannot be relied upon until the battery has had the initial full charge. Battery Charging. The battery can be charged either on or off the bicycle, but must be charged inside in dry conditions to avoid the risk of electrical shock. Only use the charger supplied with the bicycle. 1) 2) 3) 4) 6) Ensure the power is turned off at the battery.
Quick release fittings for seat height adjustment. With the locking lever in the loose position, tighten the nut until finger tight, The final tightening is done by moving the lever to the locked position. To undo move lever to loose position to enable height adjustment. Loose Locked Front Light To turn the light on press the red button on the handlebar. Press again to turn off. Rear Light The rear light requires 2 AA size batteries. There is a switch on the light for operation.
Riding To turn on the power, insert the key into the lock on the battery and turn to the on position. Then switch on the controller on the handlebars by pressing the power button. The display will switch all segments on and display the current settings for the wheel size. (Detailed later).
Pedal Assistance The amount of assistance from the motor can be selected using the UP and DOWN buttons. There are 7 levels of power from Pedal Only through six levels of Pedal Assistance. The amount of assistance selected is displayed by the Assist Meter. Riding Without Power When no assistance is selected the Auto indicator lights. In this mode the motor will not provide assistance when pedalling. Using the Twist Grip Throttle 6 When no assistance is selected the Auto indicator lights.
Power Level Display The amount of power actually being sent to the motor is displayed on the power meter. This is sensed by the pressure put on the pedals and is shown in 6 levels. Battery Level Display A battery meter shows the amount of power remaining in the battery. There are 4 levels to the display. When only 2 bars are shown the rider should be heading back to a suitable charging station. When one bar is shown there is very little power left and the battery should be charged as soon as possible.
Trip Meter To display the Trip Meter press the SET button twice and the KM icon will display together with the current trip value. To reset the trip to zero simply press the DOWN button when the trip distance is displayed. To leave the trip distance simply wait 5 seconds and the display will return to its normal mode. Timer To display the Timer press the SET button 3 times and the CLOCK icon will display together with the current Time value.
Speed & Distance Display The wheel size setting is used to calibrate the electronic controller which displays the speed and distance travelled. Wheel Size Settings 10 Secs To set the wheel size press and hold the SET button for 10 secs and the WHEEL SIZE icon will display together with the current wheel diameter and wheel circumference values. Use the UP and DOWN buttons to change the values.
Fault Messages Fault Display If the SPANNER icon appears together with a code on the display then it is an indication that there is a fault and you should switch off the controller at the button on the display. Then switch off the power at the battery with the key and leave for 2 minutes. When the battery and controller are turned on the unit should function correctly. If the code display persists then please contact your dealer or BATRIBIKE for assistance quoting the code shown on the display.
Notes
Warranty Please retain your receipt as this is your proof of purchase and entitlement to Warranty. The Frame of your new BATRIBIKE Tungsten is guaranteed for 2 years from date of purchase. Other main cycle parts have a warranty of 1 year. The battery is covered for 6 months as battery life is determined by User care. In the event of warranty repairs becoming necessary you should return your bicycle to BATRIBIKE at the address below. Delivery & collection charges are not redeemable under warranty.