Engine Serial Number: _____________________________________________ Hull Identification Number:__________________________________________ Hull Identification Number • The Hull Identification Number (HIN) is located on the starboard side of the transom. • Record the HIN (and the engine serial numbers) in the space provided above. • Please refer to the HIN for any correspondence or orders. HIN LOCATION © 2004 Bayliner Technical Publications. All rights reserved.
CONTENTS 1 Chapter 1: Welcome Aboard! 1 Dealer Service 1 Warranty Information 1 Boating Experience 2 Engine & Accessories Guidelines 25 Bilge Blower System 2 26 Fuel System Propeller 2 Engine & Accessories Literature 3 Structural Limitation 3 Qualified Maintenance 4 Safety Standards 4 Special Care For Moored Boats 5 Carbon Monoxide (CO) 5 6 6 7 7 8 Facts about CO Where and How CO Can Accumulate How to Protect Yourself and Others From CO CO Checklists Carbon Monoxide Alarm System
36 Chapter 7: Deck Equipment 51 Chapter 10: Lights 36 Cleats and Tow Eyes 51 Care and Maintenance 36 Ski Tow Ring 51 Navigation Lights 37 Ski-Tow Tower (If Equipped) 52 Chapter 11: Electrical System 53 12-Volt DC System 37 Attaching the Ski-Tow Rope 38 Folding the Ski-Tow Tower 39 Canvas (If Equipped) 39 40 41 42 43 44 Convertible Top Side Curtains (If Equipped) 185 Bimini Top (If Equipped) 205/225 Bimini Top (If Equipped) Bow Cover (If Equipped) Canvas Care (see also, ‘Clear Vinyl Care
Hazard Boxes & Symbols The hazard boxes and symbols shown below are used throughout this supplement to call attention to potentially dangerous situations which could lead to either personal injury or product damage. Read ALL warnings carefully and follow all safety instructions. ! DANGER! This box alerts you to immediate hazards which WILL cause severe personal injury or death if the warning is ignored.
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 1: Welcome Aboard! • This Owner’s Manual Supplement provides information about your boat that is not covered in the Sport Boat Owner’s Manual. • Before using your boat, study this Owner’s Manual Supplement, the Sport Boat Owner’s Manual, and all engine and accessory literature carefully. • Keep this Owner’s Manual Supplement and the Sport Boat Owner’s Manual on your boat in a secure, yet readily available place.
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 1: Welcome Aboard! Engine & Accessories Guidelines NOTICE When storing your boat please refer to your engine’s operation and maintenance manuals. • Your boat’s engine and accessories were selected to provide optimum performance and service. • Installing a different engine or other accessories may cause unwanted handling characteristics.
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 1: Welcome Aboard! Structural Limitation The extended swim platform, if equipped, is designed to be lightweight for proper boat balance. The load limit for the extended swim platform is 30 pounds per square foot, evenly distributed.
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 1: Welcome Aboard! Safety Standards ! DANGER! FALLING and ROTATING PROPELLER HAZARD! • NEVER allow anyone to ride on parts of the boat NOT designed for such use. • Sitting on seat backs, lounging on the forward deck, bow riding, gunwale riding or occupying the transom platform while underway is especially hazardous and will cause personal injury or death.
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 1: Welcome Aboard! Carbon Monoxide (CO) ! DANGER! • Carbon monoxide gas (CO) is colorless, odorless, tasteless, and extremely dangerous. • All engines, generators, and fuel burning appliances produce CO as exhaust. • Prolonged exposure to low concentrations or very quick exposure to high concentrations will cause BRAIN DAMAGE or DEATH. • Teak surfing, dragging, or water skiing within 20 feet of a moving watercraft can be fatal.
Chapter 1: Welcome Aboard! 185, 195, 205, & 225 • Owner’s Manual Supplement Where and How CO Can Accumulate Stationary Conditions That Increase CO Accumulations Include: A. Using engine, generator, or other fuel burning device when boat is moored in a confined space. B. Mooring too close to another boat that is using its engine, generator, or other fuel burning device. To correct stationary situations A and/or B: • Close all windows, portlights and hatches.
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 1: Welcome Aboard! CO Checklists Trip Checklist ❏ Make sure you know where the exhaust outlets are located on your boat. ❏ Educate all passengers about the symptoms of CO poisoning and where CO may accumulate. ❏ When docked, or rafted with another boat, be aware of exhaust emissions from the other boat. ❏ Listen for any change in exhaust sound, which could indicate an exhaust component failure.
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 1: Welcome Aboard! More Information For more information about how you can prevent carbon monoxide poisoning on recreational boats and other ways to boat more safely, contact: United States Coast Guard Office of Boating Safety (G-OPB-3) 2100 Second Street SW Washington, DC 20593 www.uscgboating.org 1-800-368-5647 National Marine Manufacturers Association (NMMA) 200 East Randolph Drive Suite 5100 Chicago, IL 60601-9301 www.nmma.
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 2: Product Specifications 185 STANDARD SEATING LAYOUT SPORT SEATING LAYOUT Overall Bridge Draft Draft (Drive Length Clearance Beam (Drive Up) Down) 18' 0" 6' 0" 7' 7" 1' 8" 3' 0" Fuel Capacity (gal.
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 2: Product Specifications 195 STANDARD SEATING LAYOUT removable jump seat sleeper seat motor box stowage under seating walk-thru windshield ski/wakeboard removable stowage jump seat stowage under seating sleeper seat removable jump seat removable jump SPORT SEATING LAYOUT stowage engine cover ice box swivel bucket seat stowage under seating walk-thru windshield ski/wakeboard removable stowage jump seat stowage under seating swivel b
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 2: Product Specifications 205 STANDARD SEATING LAYOUT SPORT SEATING LAYOUT Overall Bridge Draft Draft (Drive Length Clearance Beam (Drive Up) Down) 20' 4" 4' 1" 8' 0" 1' 6" 3' 1" Fuel Capacity (gal.
5, 195, 205, & 225 • Owner’s Manual Supplement Chapter 2: Product Specifications 225 Overall Bridge Draft Draft (Drive Beam Length Clearance (Drive Up) Down) 22' 1" 12 7' 4" 8' 6" 1' 6" 3' 0" Fuel Capacity (gal.) Freshwater Tank Capacity (gal.
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 3: Locations Exterior Views Hull Views BILGE PUMP DRAIN STARBOARD HULLSIDE BOW EYE DASH DRAIN PORT HULLSIDE TRANSOM STERN EYE STERN EYE GARBOARD DRAIN PLUG 13
Chapter 3: Locations Extended Swim Platform (If Equipped) EXTENDED SWIM PLATFORM 14 185, 195, 205, & 225 • Owner’s Manual Supplement
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 3: Locations 185 Deck View GRAB HANDLES CLEAT BOW LIGHT CUPHOLDERS WALK-THROUGH WINDSHIELD SLEEPER SEAT LAYOUT CLEAT GRAB HANDLE SKI TOW RING ALL-ROUND LIGHT (REMOVABLE) HORN CLEAT BLOWER VENTS CLEAT GRAB HANDLE FUEL FILL/VENT DECK FITTING BOARDING LADDER GRAB HANDLES CLEAT BOW LIGHT CUPHOLDERS WALK-THROUGH WINDSHIELD SPORT SEATING LAYOUT CLEAT SKI TOW RING ALL-ROUND LIGHT (REMOVABLE) HORN CLEAT BLOWER VENTS GRAB HANDLE CLEAT
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 3: Locations 195 Deck View GRAB HANDLES BOW LIGHT SLEEPER SEAT LAYOUT ALL-ROUND LIGHT (REMOVABLE) SKI TOW RING HORN BLOWER VENTS GRAB HANDLE FUEL FILL/VENT DECK FITTING BOW LIGHT GRAB HANDLES BOARDING LADDER SPORT SEATING LAYOUT GRAB HANDLES SKI TOW RING ALL-ROUND LIGHT (REMOVABLE) HORN BLOWER VENTS GRAB HANDLE FUEL FILL/VENT DECK FITTING BOARDING LADDER 16
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 3: Locations 205 Deck View GRAB HANDLES CLEAT BOW LIGHT CUPHOLDERS CLEAT SLEEPER SEAT LAYOUT GRAB HANDLE SKI TOW RING ALL-ROUND LIGHT (REMOVABLE) HORN CLEAT BLOWER VENTS CLEAT GRAB HANDLE FUEL FILL/VENT DECK FITTING BOARDING LADDER GRAB HANDLES CLEAT BOW LIGHT CUPHOLDERS CLEAT SPORT SEATING LAYOUT SKI TOW RING ALL-ROUND LIGHT (REMOVABLE) HORN CLEAT BLOWER VENTS CLEAT GRAB HANDLE FUEL FILL/VENT DECK FITTING BOARDING LADDER 17
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 3: Locations 225 Deck View GRAB HANDLES CLEAT BOW LIGHT CLEAT ALL-ROUND LIGHT (REMOVABLE) SKI TOW RING FUEL FILL/VENT DECK FITTING HORN CLEAT BLOWER VENTS FRESHWATER FILL DECK FITTING TRANSOM SHOWER BOARDING LADDER 18 CLEAT FRESHWATER TANK VENT
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 3: Locations Helm VOLTMETER IGNITION SWITCH OIL PRESSURE GAUGE SPEEDOMETER BLOWER SWITCH TRIM/TILT GAUGE TACHOMETER BILGE PUMP SWITCH RUNNING LIGHTS SWITCH TEMPERATURE GAUGE ACCESSORY SWITCH FUEL GAUGE HORN SWITCH 19
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 3: Locations Component Locations 12-Volt Accessory Outlets - 185, 195 & 205: One on the starboard side dash panel and one next to the CD player in the port glove box. 12-VOLT OUTLETS 12-Volt Accessory Outlets - 225: One next to the CD player in the port glove box and one on the starboard side of the cockpit next to the aft bench seat.
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 3: Locations Battery - 185, 195 & 205: Located under the port jump seat cushion. BATTERY Battery - 225: Located on the port side of the engine compartment.
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 3: Locations Bilge Pump: Located in the forward area of the engine compartment bilge. 225 BILGE PUMP 185, 195 & 205 DETAIL VIEW BILGE PUMP Engine Circuit Breaker: Located on the engine. Refer to the engine manual for details. Freshwater Fill Deck Fitting (225 Only) (If Equipped): Located on the aft deck, above the boarding ladder.
185, 195, 205, & 225 • Owner’s Manual Supplement Freshwater Pump Switch (225 Only) (If Equipped): Located on the starboard side next to the aft bench seat. Fuse Block: Access is through the starboard aft seat back in the bow seating area.
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 3: Locations Fuel Fill Deck Fitting - 185, 195 & 205: Located on the starboard side of the aft deck. FUEL FILL DECK FITTING Fuel Fill Deck Fitting - 225: Located on the port side of the aft deck.
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 4: Propulsion & Related Systems Engine Read the engine operation and maintenance manuals before starting or doing any maintenance on the engine OR engines. Special Starting Instructions for Carbureted Engines (If Equipped) Carbureted engines can be difficult to start when they are cold. In addition to following all instructions and heeding all warnings in the engine manual, try the following: 1.
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 4: Propulsion & Related Systems Fuel System WARNING! ! FIRE, EXPLOSION AND OPEN FLAME HAZARD! • It is very important that the fuel system be inspected thoroughly the first time it is filled and at each subsequent filling. • The fueling instructions in the Sport Boat Owner’s Manual and the fuel recommendations in the engine operation manual must be followed. ! CAUTION Avoid the storage or handling of gear near the fuel lines, fittings and tank.
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 4: Propulsion & Related Systems Anti-siphon Valve NOTICE • If an engine running problem is diagnosed as fuel starvation, check the anti-siphon valve. • If the valve is stuck or clogged, change or replace it while the engine is shut down. • NEVER run the engine with the anti-siphon valve removed, except in an emergency. • • • • The anti-siphon valve is a vital fuel system part.
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 4: Propulsion & Related Systems Quick Oil Drain System The quick oil drain hose was attached to the engine oil pan at the factory. However, some minor assembly is still needed before you can use this system. How to install the quick oil drain system: 1. Unscrew the factory installed garboard drain plug from the garboard drain (A). Keep the factory garboard drain plug on the boat as a spare. 2.
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 5: Controls & Gauges Steering • • • • Your boat features a power assisted* rack-and-pinion steering system. For information about the 'power assist fluid reservoir', refer to the engine operation and maintenance manual. Boat steering is not self-centering. Refer to the engine manual for more steering system details. *3.0L engines feature mechanical rack-and-pinion steering.
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 5: Controls & Gauges Gauges Cleaning Gauges ! CAUTION PRODUCT or PROPERTY DAMAGE HAZARD! • Use only mild soap and water to clean the gauge lenses and bezels. • Use of other cleaners, including common window cleaning solutions, may cause the lenses to crack. • Lenses cracked in this manner will NOT be covered by our warranty. Gauge Fogging • Moisture may occasionally find its way into the gauges causing lens fogging.
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 6: Plumbing Bilge Pump NOTICE Discharge of oil, oil waste or fuel into navigable waters is prohibited by law. Violators are subject to legal action by the local authorities. • Your boat is equipped with a bilge pump for pumping water out of the bilge. • The 185, 195 & 205 bilge pumps are controlled by a switch at the helm. • On the 225 the bilge pump is controlled by a float switch (auto-float switch) and a switch at the helm.
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 6: Plumbing Auto-float Switch (225 Only) • The automatic bilge pump uses a float (autofloat) switch to automatically turn On the pump whenever water rises to a preset level in the bilge. • The autofloat switch is normally mounted next to the bilge pump it controls. • The autofloat switch should be tested often as follows. Autofloat Testing: FLOAT SWITCH TESTING 1. Lift the float switch test button up to turn On the bilge pump.
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 6: Plumbing Freshwater System (225 Only) (If Equipped) ! WARNING! • Only use safe drinking (potable) water in your boat’s freshwater system. • Only use an FDA approved, white 'drinking water safe' hose to fill the freshwater tank. • NEVER use a common garden hose for drinking water.
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 6: Plumbing Freshwater System Winterization ! CAUTION WATER SYSTEM DAMAGE HAZARD! NEVER blow compressed air through the water system when all of the faucets are Closed. 1. Turn On the freshwater pump switch. 2. Open all of the faucets and showers and let the freshwater system drain completely. 3. Turn Off the freshwater pump switch. All remaining water must be removed from the water lines.
185, 195, 205, & 225 • Owner’s Manual Supplement Transom Shower (If Equipped) • Read the manufacturer’s instructions before using the transom shower for the first time. • The freshwater pump switch must be turned On before using the transom shower. Chapter 6: Plumbing TRANSOM SHOWER FRESHWATER PUMP SWITCH Drain Systems Deck Drains • Water on the deck is drained overboard through the deck drains. • Keep the deck drains free of debris.
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 7: Deck Equipment Cleats and Tow Eyes ! WARNING! PERSONAL INJURY and /or PRODUCT or PROPERTY DAMAGE HAZARD! NEVER lift the boat using the bow and stern eyes or the cleats. Carefully read the section on towing in the Sport Boat Owner’s Manual before: • Towing anything behind the boat. • Being towed by another vessel.
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 7: Deck Equipment Ski-Tow Tower (If Equipped) ! WARNING! PERSONAL INJURY and /or PRODUCT or PROPERTY DAMAGE HAZARD! Failure to follow these guidelines can result in injury or death: • Read all warning labels on ski-tow tower. • Before each use, make sure all bolts are in place and tight. • Only tow water skis, wakeboards, or recreational towables.
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 7: Deck Equipment Folding the Ski-Tow Tower ! WARNING! PERSONAL INJURY and /or PRODUCT or PROPERTY DAMAGE HAZARD! • Folding or unfolding the ski-tow tower is a two person task. • Before each use of the folding ski-tow tower, make sure all four lock-down bolts are tightened firmly. • Read all warning labels on the ski-tow tower. To fold the ski-tow tower into the storage position: B 1.
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 7: Deck Equipment Canvas (If Equipped) CAUTION ! PRODUCT or PROPERTY DAMAGE HAZARD! Take down and securely stow the canvas top or bimini top, side curtains, and slant back cover before transporting your boat by road. NOTICE Two people are needed to do the tasks listed below and on the following pages in this section. Convertible Top SECURING PIN END EYE DECK HINGE C E F D A B SECURING PIN WINDSHIELD HINGE 1.
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 7: Deck Equipment Side Curtains (If Equipped) 1. Snap the forward corner (A) of the side curtain to the windshield frame. 2. Working your way aft, alternately snap the top snaps to the canvas top and the bottom snaps to the windshield frame and deck. 3. Insert the side curtain stud (B) into the socket on the canvas top.
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 7: Deck Equipment 185 Bimini Top (If Equipped) 1. Slide the windshield hinges of the main bow (A) over the predrilled holes in SECURING PIN the windshield A frames and END EYE secure the pins. DECK E C E 2. Insert the end HINGE eyes of the aft braces (B) into D B the deck hinges and secure them with the pins. 3. Pull the secondary bow (C) forward and insert the end eyes of the forward braces (D) into the deck hinges and secure them with the pins.
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 7: Deck Equipment 205/225 Bimini Top (If Equipped) B D D D D A C SECURING PIN END EYE WINDSHIELD HINGE SECURING PIN DECK HINGE WINDSHIELD FRAME 1. Slide the windshield hinges of the main bow (A) over the aft pre-drilled holes in the windshield frames and secure with the pins. 2. Unfold the canvas top and slide the swivel ends of the forward legs (B) over the forward pre-drilled holes in the windshield frames and secure with the pins. 3.
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 7: Deck Equipment Bow Cover (If Equipped) 1. Snap the two forward snaps (A) to the deck. 2. Snap the bow cover to the entire port side. A 3. On the starboard side, only snap the forward half of the bow cover to the deck. 4. Insert the adjustable, center support pole (B) into both the bow cover and the table base (C). 5. Adjust the support pole so that it is just high enough to stay inserted in the bow cover. C B 6.
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 7: Deck Equipment Canvas Care (see also, ‘Clear Vinyl Care’ on next page) • After each use, especially in saltwater, rinse the canvas with cold freshwater. • Before stowing, let the canvas air dry completely. • The canvas can be rolled or folded for stowage. Cleaning Canvas ! CAUTION NEVER use detergents when washing the canvas. Detergents can destroy the water repellency, and mildew/UV resistant finish of your canvas.
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 7: Deck Equipment Clear Vinyl Care • • • • • ! CAUTION NEVER store the clear vinyl pieces wet, as this will cause a milky film to develop. NEVER fold or crease the clear vinyl pieces as cracking will occur. Clear vinyl is not intended for use when the boat is in storage or being moored. Clear vinyl does not hold up well against ultraviolet rays. Under direct sunlight conditions, do NOT let the clear vinyl touch the framework.
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 8: Entertainment Systems Audio Equipment NOTICE AM radio reception may be impaired anytime the engine is running.
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 9: Convertible Seats, Beds, & Tables Sleeper Seats (If Equipped - 185, 195 & 205 Only) • The sleeper seats can be adjusted fore and aft in the upright, operating position. • The seat bottoms adjust into backrests when the seats are in the lounge position. Operating Positions To slide the seat forward: 1. Lift the forward seat at point (A). 2. Push down on the forward seat at point (B) and pull the seat forward. 3.
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 9: Convertible Seats, Beds, & Tables Jump Seat To Sunlounge Conversion (If Equipped - 185, 195 & 205 Only) ! DANGER! PERSONAL SAFETY HAZARD! Do NOT allow anyone to ride the aft sunlounge cushions while underway or anytime the engine is running. C A A C A B C D 1. 2. 3. 4. 48 Remove the jump seats (A) by lifting and pulling on their forward edges. Rotate each jump seat so that the lounge support tabs (B) face the support slots (C).
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 9: Convertible Seats, Beds, & Tables Passenger Seat to Sunlounge Conversion (225 Only) PASSENGER SEAT POSITION A A LOUNGE POSITION B 1. Remove the forward seat bottom (A) by lifting and pulling the forward edge. 2. Slide the seat backs (B) forward until they stop. 3. Use the seat bottom (A) to fill in the space.
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 9: Convertible Seats, Beds, & Tables Installing & Removing Table Leg (225 Only) Installing the Table Leg 1. Place the threaded end into the base. 2. Twist the table leg clockwise until it locks in place. Removing the Table Leg 1. Press firmly on the black release button and twist the table leg counter-clockwise. Table & Table Leg Stowage When not in use the table and table leg can be stowed in the engine compartment.
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 10: Lights Care and Maintenance All of the lights installed on your boat are of top quality, but you should be aware that failure may periodically occur for a variety of reasons: 1. 2. 3. 4. There may be a blown fuse - replace the fuse. The bulb may be burned out - carry spare bulbs for replacement. A wire may be damaged or may have come loose - repair as required.
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 11: Electrical System ! DANGER! EXTREME FIRE, SHOCK & EXPLOSION HAZARD! • To minimize the risks of fire and explosion, NEVER install knife switches or other arcing devices in the fuel compartments. • NEVER substitute automotive parts for marine parts. Electrical, ignition and fuel system parts were designed and manufactured to comply with rules and regulations that minimize risks of fire and explosion.
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 11: Electrical System 12-Volt DC System Battery The battery supplies electricity for lights, accessories, and engine starting. The Electrical section of Chapter 8, in the Sport Boat Owner’s Manual, provides battery care and maintenance instructions. Fuses • Fuses for the engine and main accessory power are on the fuse block under the helm dash. • Some equipment may have secondary fuse protection at the unit, or at the battery.
Chapter 11: Electrical System 185, 195, 205, & 225 • Owner’s Manual Supplement Electrical Routings 185, 195 & 205 Deck Electrical Harnesses NOTE: VIEW IS UNDERSIDE OF DECK BOW LIGHT FUSE BLOCK HORN STEREO 12-VOLT OUTLET DASH HARNESS SPEAKER 12-VOLT OUTLET TRIM/TILT SWITCH IN SHIFTER/THROTTLE LEVER SPEAKER ENGINE PLUG BATTERY BLOWER MOTOR TRIM PUMP ALL-ROUND LIGHT 54
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 11: Electrical System 225 Deck Electrical Harnesses NOTE: VIEW IS UNDERSIDE OF DECK BOW LIGHT SPEAKER SPEAKER FUSE BLOCK CD CHANGER (IF EQUIPPED) HORN CD STEREO DASH HARNESS TRIM/TILT SWITCH IN SHIFTER/THROTTLE LEVER 12-VOLT OUTLET 12-VOLT OUTLET & FRESHWATER PUMP SWITCH SPEAKER COURTESY LIGHT SPEAKER BATTERY FRESHWATER PUMP ENGINE PLUG BLOWER MOTOR TRIM PUMP ALL-ROUND LIGHT (REMOVABLE) 55
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 11: Electrical System Hull Electrical Harness ENGINE PLUG BILGE PUMP FLOAT SWITCH (225 ONLY) FUEL TANK SENDER 56
185, 195, 205, & 225 • Owner’s Manual Supplement Chapter 11: Electrical System Wiring Diagrams 185, 195 & 205 57
Chapter 11: Electrical System 225 58 185, 195, 205, & 225 • Owner’s Manual Supplement
185, 195, 205, & 225 • Owner’s Manual Supplement Important Records Selling Dealer Key Numbers Name Of Dealership Ignition Other Address Electronics Phone/FAX/E-mail Manufacturer Model Name/Number Sales Manager Service Manager Serial Number Engine Manufacturer Manufacturer Model Name/Number Model Name/Number Serial Number Engine Serial Number Manufacturer Oil Type/SAE Quarts per Engine Model Name/Number Filter Type Serial Number Propeller Manufacturer Pitch Model Number Manufacturer
185, 195, 205, & 225 • Owner’s Manual Supplement Float Plan Before going boating, fill out a copy of this float plan (or similar) and leave it with a reliable person whom you can depend on to contact the Coast Guard or other rescue organization, if you do not return as scheduled.
185, 195, 205, & 225 • Owner’s Manual Supplement Float Plan Survival Equipment Trip Expectations Marine Radio (Yes/No) Type Frequencies Number of PFDs Flares (Yes/No) Mirror (yes or no) Smoke Signals (Yes/No) Flashlight (Yes/No) Food (Yes/No) Departing From Departure Date Departure Time Stopover 1 Water (Yes/No) Anchor (Yes/No) Raft/Dinghy (Yes/No) Arrive No Later Than: Date Paddles (Yes/No) EPIRB (Yes/No) Other Other Other Other Arrive No Later Than: Time Stopover 2 Arrive No Lat
Float Plan 62 185, 195, 205, & 225 • Owner’s Manual Supplement
185, 195, 205, & 225 • Owner’s Manual Supplement Float Plan 63
Owner’s Notes
Owner’s Notes
Owner’s Notes
Part Number 1786916 Bayliner • P.O.
