The information in this Owner’s Manual Supplement relates to 2000 & 2001 2302 DX/LX, 2352 DX/LX 2359, DX/LX Bayliner Trophy Fishing Boats. Hull Identification Number___________________________________________ Engine Serial Number _______________________________________________ Hull Identification Number: The Hull Identification Number (HIN) is located on the starboard side of the transom. Record the HIN and the engine serial number in the space provided above.
Contents Chapter 1: Welcome Aboard! 1 Dealer Service 1 Boating Experience 1 Qualified Maintenance 2 Special Care For Moored Boats 2 Engine & Accessories Guidelines 3 Safety Standards 3 Hazard Warning Symbols Chapter 2: Specifications & Features 4 2302FP 10 2352 FN Features and Systems 16 2359 FB Features and Systems 29 Fuel System 29 Fuel Fills and Vents 29 Fuel Filters 29 Oil Injection System (2302 FP) 30 Trim Tabs 30 Power Trim and Tilt 31 Navigation and Communication Equipment 31 VHF R
Chapter 4: Electrical Routings 39 2302 FP Electrical Routings 39 Deck Harness Routing 40 Hull Harness Routing 40 2352 FN Electrical Routings 40 Hull Harness Routing 41 Deck Harness Routing 42 2359 FB Electrical Routings 42 43 44 44 45 45 Hull Harness Routing Battery Cable Routings Forward Deck Harness Routing Mid Deck Harness Routing Aft Deck AC Panel Routings Chapter 5: Wiring Diagrams 46 2302 FP Electrical System 47 2352 FN Electrical System 48 2359 FB AC Electrical System 49 2359 FB DC Electrical Sys
1 Chapter 1: Welcome Aboard! Welcome aboard! This owner’s manual supplement provides specific information about your boat that is not covered in the owner’s manual. Please study the owner’s manual and this supplement carefully, paying particular attention to Appendix A: Limited Warranty in this supplement. Keep the owner’s manual and this supplement on your boat in a secure, yet readily available place.
2 Chapter 1: Welcome Aboard! ! WA R N I N G ! To maintain the integrity and safety of your boat, only qualified personnel should perform maintenance on, or in any way modify: The steering system, propulsion system, engine control system, fuel system, environmental control system, electrical system or navigational system. Special Care For Moored Boats If moored in saltwater or fresh water, your boat will collect marine growth on its hull bottom.
Chapter 1: Welcome Aboard! 3 Safety Standards Your boat’s mechanical and electrical systems were designed to meet safety standards in effect at the time it was built. Some of these standards were mandated by law; all of them were designed to insure your safety, and the safety of other people, vessels and property. In addition to this supplement, read the owner’s manual and all accessory instruction sheets included in your owner’s packet for important safety standards and hazard information.
4 Chapter 2: Specifications & Features 2302FP Dimensions and Tank Capacities Overall Length Bridge Clearance Beam Draft (Drive Up) Water Capacity Fuel Tank Capacity 23’5" 7’11" 8’5" 1’7" 8 gal. 101 gal.
Chapter 2: Specifications & Features 5 Transom Hardware TRANSOM STERN EYE (TYPICAL) GARBOARD DRAIN DECK DRAIN (TYPICAL) TRIM TAB (TYPICAL) Foredeck Hardware HORN ANCHOR ANCHOR STORAGE ROLLER BOW CLEAT NAV. LIGHT (TYPICAL) FWD. STBD.
6 Chapter 2: Specifications & Features Helm Dash TACHOMETER VOLTMETER FUEL SPEEDOMETER ACCESSORY SWITCHES ACCESSORY SWITCHES STEERING WHEEL CIRCUIT BREAKERS Cockpit Features TRIM TAB PUMP ACCESS FUEL FILL LOCATION ROD HOLDERS HAWSE PIPE (TYPICAL) ROD HOLDER (TYPICAL) FISHWELL (TYPICAL) 23’ Trophy • Owner’s Manual Supplement ENGINE BATTERY ACCESS
Chapter 2: Specifications & Features 7 Warning Labels FUEL FILL & FUELING WARNING LABELS STBD. FWD. EMERGENCY SHUTDOWN WARNING LABEL TRIM TAB WARNING LABEL AFT CAPACITY WARNING LABEL Bilge Pump Routing FWD. BILGE PUMP ROUTING BILGE PUMP & FLOAT SWITCH AFT BILGE PUMP ROUTING BILGE PUMP & FLOAT SWITCH THRU-HULL FWD. STBD.
8 Chapter 2: Specifications & Features Head & Waste Tank System (LX Only) HEAD SYSTEM ROUTING VENTED LOOP PORT FWD. SEA WATER PICK-UP TOILET (OPTIONAL) MACERATOR ROUTING TO PUMP- OUT FITTING IN DECK PORT DECK MACERATOR WASTE PUMPOUT FITTING HOLDING TANK FWD. SEA WATER PICK-UP FWD.
Chapter 2: Specifications & Features 9 Fuel System VIEW OF AFT DECK STBD. AFT FUEL FILL DECK AFT FUEL TANK STBD. TO MOTOR TO VENT HOSE FUEL FILL Freshwater System FRESHWATER ROUTING WATER WATER FILL TO GALLEY TANK ON DECK SINK PORT WATER FILL LOCATION WATER TANK FITTING PORT SIDE OF DECK FWD. FWD.
10 Chapter 2: Specifications & Features 2352 FN Features and Systems Dimensions and Tank Capacities Overall Length Bridge Clearance Beam Draft (Drive Up) Water Capacity Fuel Tank Capacity 23’5" 7’11" 8’5" 1’7" 8 gal. 101 gal.
Chapter 2: Specifications & Features 11 Transom Hardware TRANSOM DECK DRAIN (TYPICAL) GARBOARD DRAIN STERN EYE (TYPICAL) TRIM TAB (TYPICAL) Foredeck Hardware HORN ANCHOR STORAGE ANCHOR ROLLER BOW CLEAT NAV. LIGHT (TYPICAL) FWD. STBD.
12 Chapter 2: Specifications & Features Helm Dash TACHOMETER VOLTMETER FUEL SPEEDOMETER ACCESSORY SWITCHES ACCESSORY SWITCHES STEERING WHEEL CIRCUIT BREAKERS Cockpit Features BAITWELL ENGINE ACCESS FISHWELL (TYPICAL) ROD HOLDER (TYPICAL) HAWSE PIPE PORT AFT 23’ Trophy • Owner’s Manual Supplement
Chapter 2: Specifications & Features 13 Warning Labels STB D. FUEL FILL & FUELING WARNING LABELS AFT FOREDECK WARNING LABEL FWD. TRIM TAB WARNING LABEL CAPACITY WARNING LABEL EMERGENCY SHUTDOWN WARNING LABEL STBD. Bilge Pump Routing FWD. BILGE PUMP ROUTING BILGE PUMP & FLOAT SWITCH AFT BILGE PUMP ROUTING THRUHULL STBD. FWD.
14 Chapter 2: Specifications & Features Fuel System TO FUEL FITTING ON STBD. DECK TO FUEL VENT IN HULL FUEL FILL ON STBD. DECK FUEL LINE TO ENGINE AFT FWD. ENGINE COMPARTMENT STBD. FUEL TANK Freshwater System FRESHWATER ROUTING WATER WATER FILL TO GALLEY TANK ON DECK SINK PORT WATER FILL LOCATION WATER TANK FITTING FWD. FWD.
Chapter 2: Specifications & Features 15 Head & Waste Tank System (LX Only) VENTED LOOP PORT FWD. TOILET SEA WATER PICK-UP (OPTIONAL) MACERATOR ROUTING TO PUMP- OUT FITTING IN DECK MACERATOR HOLDING TANK PORT SEA WATER PICK-UP TOILET FWD. TO WASTE PUMPOUT FITTING WASTE TANK PORT DECK HOSE TO WASTE TANK WASTE PUMPOUT FITTING FWD. PORT FWD.
16 Chapter 2: Specifications & Features 2359 FB Features and Systems Dimensions and Tank Capacities Overall Length Bridge Clearance Beam Draft (Drive Up) Water Capacity Fuel Tank Capacity 23’5" 7’4" 8’5" 1’7" 20 gal. 87 gal. Layout View coaming cap removable jumpseat fishwell dinette area head baitwell sink removable jumpseat fishwell stove storage helm area coaming cap Hull Exterior Hardware AFT BILGE PUMP DRAIN FISH WELL FUEL VENT SINK DRAIN FWD.
Chapter 2: Specifications & Features 17 Transom Hardware MIDSHIP STORAGE DRAIN TRANSOM STERN EYE (TYPICAL) GARBOARD DRAIN TRIM TAB (TYPICAL) Foredeck Hardware DECK CLEAT (TYPICAL) BOW HATCH FWD. PORT BOW CLEAT ANCHOR ROLLER NAV.
18 Chapter 2: Specifications & Features Helm ACCESSORY SWITCHES TROPHY PUMPS LIGHTS ACCY PORT WIPER STBD. WIPER COCKPIT NAV. ANCHOR STBD. FISH WELL PORT FISH WELL BAIT WELL FWD.
Chapter 2: Specifications & Features 19 Warning Labels “DO NOT BOARD POTABLE WATER FOREDECK” WARNING LABEL LABEL FUEL FILL & FUELING WARNINGS STBD. AFT Fuel System FUEL TANK VENT TO FUEL FITTING ON DECK AFT CABIN ENTRY DOOR AFT FUEL TANK STB D. . BD ST TO ENGINE STBD.
20 Chapter 2: Specifications & Features Bilge Pumps AFT BILGE PUMP ROUTING FWD. BILGE PUMP & FLOAT SWITCH FWD. BILGE PUMP ROUTING FWD. BILGE PUMP & FLOAT SWITCH THRU-HULL THRU-HULL Baitwell System D A B A. B. C. D. E. F. G. H. I.
Chapter 2: Specifications & Features 21 Freshwater System BREAKAWAY VIEW OF PORT HULLSIDE PORT SIDE OF DECK FWD.
22 Chapter 2: Specifications & Features Head & Waste System (LX Only) TOILET RAW WATER PICK UP VENTED LOOP AFT DECK WASTE PUMPOUT FITTING FWD. TRANSOM WASTE TANK SYSTEM (MACERATOR OPTION SHOWN) WASTE TANK LOCATION HOSE FROM HEAD UNDERWATER DISCHARGE HOSE TO MACERATOR STBD.
23 Chapter 3: General Systems Electrical System Read this section and the electrical sections of the owner’s manual and all accessory manuals included in your boat owner’s packet. Electrical system drawings are provided in Chapter 4 and Chapter 5 of this supplement. ! D A N G EDANGER R! EXTREME FIRE, SHOCK & EXPLOSION HAZARD! • To minimize the risks of fire and explosion, NEVER install knife switches or other arcing devices in the fuel compartments. • NEVER substitute automotive parts for marine parts.
24 Chapter 3: General Systems 12-Volt DC Electrical System Your boat is equipped with a 12-volt DC (direct current) system. Fuses and Circuit Breakers • Fuses and circuit breakers for engines and main accessory power may be on the DC main distribution panel and on the battery switch panel (if installed). • Electronics power is provided at the helm. • Some equipment may have secondary fuse protection at the unit. • Wires are color-coded to indicate which accessory each fuse services.
Chapter 3: General Systems ! 25 CAUTION! SYSTEM DAMAGE HAZARD! NEVER disconnect battery cables or turn off the battery switch while your engine is running as this can cause damage to your boat’s electrical components. Battery Charger (2359 FB LX) Your boat may be equipped with a battery charger located in the aft port cabin. Read and understand the battery charger instructions included in your owner’s packet before using the charger.
26 Chapter 3: General Systems AC Electrical System (2359 FB) Your boat may come equipped with an optional AC (alternating current) system which is energized from shore power. Shore power is supplied to your boat using a 120v/30 amp shore power receptacle. ! D A N G EDANGER R! FIRE, EXPLOSION & SHOCK HAZARD! • DO NOT alter shore power connectors and use only compatible connectors.
Chapter 3: General Systems ! 27 CAUTION! SHOCK & ELECTRICAL SYSTEM DAMAGE HAZARD! • DO NOT pinch shore power cords in doors or hatches, or coil the shore power cord too tightly. These situations can create enough heat to start a fire. • If a shore power cord should accidently become immersed in water, THOROUGHLY dry the blades and contact slots before reusing. NOTICE Some dockside installations may be rated less than 30 amps, therefore, you may need to purchase lower amp adapters.
28 Chapter 3: General Systems Propulsion Engine The owner’s packet contains detailed engine operation and maintenance manuals. Read these manuals before operating or performing maintenance to the engine. Bilge Blower Your boat may feature a bilge blower system. The bilge blower removes fumes from the engine compartment and draws fresh air into the compartment through the deck vents.
Chapter 3: General Systems 29 Fuel System Read the fuel section of the owner’s manual and the engine operation manual, paying special attention to the subject of fuel recommendations. ! WA R N I N G ! FIRE, EXPLOSION AND OPEN FLAME HAZARD! • It is very important that the fuel system be inspected thoroughly the first time it is filled and at each subsequent filling. • The fueling instructions in the owner’s manual and the fuel grade recommendations in the engine operation manual must be followed.
30 Chapter 3: General Systems Trim Tabs The trim tabs may be used to help keep your boat level at cruising speeds. Trim tabs are controlled by two rocker switches located at the helm station. Before using the trim tabs, read the trim tab operation manual included in your yacht’s owner’s packet and observe the following: TYPICAL TRIM TAB ROCKER SWITCHES (LOCATED AT HELM) • Once cruising speed is reached, the port or starboard trim switch may be used (one at a time) to level the boat.
Chapter 3: General Systems 31 Navigation and Communication Equipment The owner’s packet contains operation manuals for all navigation & communication equipment installed on your boat. Read and understand these manuals before using these systems. Additionally, read the warnings below carefully and follow all safety instructions. VHF Radio (LX only) Your boat may include a VHF (Very High Frequency) radio at the helm.
32 Chapter 3: General Systems AM/FM Cassette Stereo NOTICE AM radio reception may be impaired in areas where reception is limited or anytime the engines are running. Alcohol Stove NOTICE Always keep an approved ABC-type fire extinguisher in your boat. ! WA R N I N G ! SEVERE BURN AND FIRE HAZARD! • DO NOT operate the stove unless you have read the owner’s manual from the manufacturer.
Chapter 3: General Systems 33 Bilge Pump Testing Bilge pumps must be tested often to verify they are working properly. To test a bilge pump, activate the dash-mounted switch and verify that the bilge water is being pumped overboard. If bilge water is present and the pump motor is running but not pumping, inspect the discharge hose for a kink or collapsed area. If no problems are found, check the bilge pump housing for clogging debris as follows: Checking for clogging debris: 1.
34 Chapter 3: General Systems Fresh Water System Your boat is equipped with a pressure-demand freshwater (potable) system. Refer to the Systems and Diagrams section of this supplement, and read the following; • Open your taps and depressurize the system when not in frequent use to increase the life of your freshwater system. • Drain the freshwater system during freezing conditions and when not in use to prevent damage and to keep stored water from becoming stagnant and distasteful.
Chapter 3: General Systems 35 Head System Portable Head Your boat may feature a portable head (toilet). Read the manufacturer’s operating instructions supplied in your owner’s packet before using your portable head. Marine Head with Holding Tank (LX Only) Your boat may come equipped with a marine head (toilet) and 15 gallon waste holding tank system.
36 Chapter 3: General Systems Fishwells Your boat features two fishwells in the aft cockpit. The fishwells can be drained by activating the switches at the helm. If the fishwells do not draining properly, check for clogging or kinks in the drain hoses. UNDERSIDE OF FISHWELL FISHWELL DRAIN PUMP ACCESS HATCH IN AFT COCKPIT DRAIN IN HULLSIDE Bait Well System Your boat features a Baitwell system. Read Chapter 11 in the Owner’s Manual before using your baitwell.
Chapter 3: General Systems 37 Recirculation System (2352 FN, 2302 FP) I A D J B B C H RECIRCULATION SYTEM D G E F A. B. C. D. E. F. G. H. I. J. TANK OVERFLOW DRAIN AERATOR WAND AERATOR BAITWELL PUMP SEACOCK Y - VALVE TO HULLSIDE DRAIN LED LIGHT RECIRCULATION DRAIN Your baitwell may feature a recirculation system. The recirculation system keeps your bait or catch alive when outside water is unavailable (i.e. trailering, boating in foul water).
38 Chapter 3: General Systems Canvas Top Installation (2302 FP, 2352 FN) 1. Slide the eye ends of the forward legs (A) into the forward deck hinges and insert the pins. 2. Unfold the canvas top and slide the eye ends of the middle legs (B) into the middle deck hinges and insert the pins. 3. Slide the eye ends of the aft legs (C) into the aft deck hinges and insert the pins. No adjustments to the bow jaw slides (D) should need to be made as they are preset during manufacturing.
39 Chapter 4: Electrical Routings 2302 FP Electrical Routings Deck Harness Routing SPEAKER SHIFTER COMPASS WINDSHIELD WIPER (OPTION) LIGHTS TO AFT SECTION HORN BAITWELL NAV. LIGHTS PORT. FWD.
40 Chapter 4: Electrical Routings Hull Harness Routing BILGE PUMP & FLOAT SWITCH FUEL TANK SENDER UNIT AFT MACERATOR (OPTION) BILGE PUMP & FLOAT SWITCH STBD. STARTING POINT 2352 FN Electrical Routings Hull Harness Routing BILGE PUMP & FLOAT SWITCH FUEL TANK SENDER UNIT AFT STARTING POINT BLOWER 23’ Trophy • Owner’s Manual Supplement MACERATOR (OPTION) STBD.
Chapter 4: Electrical Routings 41 Deck Harness Routing SHIFTER DASH WINDSHIELD WIPER (OPTION) HORN NAV. LIGHTS PORT FWD. STEREO COMPASS WINDSHIELD WIPER (OPTION) STBD. COURTESY LIGHT LIGHTS FUEL FILL GROUND PORT FISHWELL TRIM TAB PUMP TO ENGINE PORT ACCESSORY AFT STBD.
42 Chapter 4: Electrical Routings 2359 FB Electrical Routings Hull Harness Routing FWD. BILGE PUMP TO DASH PORT FUEL TANK SENDING UNIT FWD.
Chapter 4: Electrical Routings 43 Battery Cable Routings POSITIVE BATTERY CABLE ROUTINGS MOTOR TRIM PORT BATTERIES AFT ENGINE STARTER BATTERY SWITCH NEGATIVE BATTERY CABLE ROUTING PORT MOTOR TRIM AFT BATTERIES ENGINE STARTER 23’ Trophy • Owner’s Manual Supplement
44 Chapter 4: Electrical Routings Forward Deck Harness Routing SHIFTER ST BD DASH QUARTER BERTH LIGHT COMPASS SPEAKER HORN FWD. NAV. LIGHTS V-BERTH LIGHT NOTE; VIEW IS OF UNDERSIDE OF DECK Mid Deck Harness Routing BATTERY SWITCH STBD.
Chapter 4: Electrical Routings 45 Aft Deck FUEL FILL GROUND COCKPIT LIGHT COCKPIT LIGHT AFT FISHWELL PUMP FISHWELL PUMP ENGINE PLUG ENGINE GROUND TRIM PUMP NOTE; VIEW IS OF UNDERSIDE OF DECK AC Panel Routings AC PANEL FROM SHORE POWER TO OUTLET TO REFRIGERATOR TO BATTERY CHARGER FWD.
46 Chapter 5: Wiring Diagrams 2302 FP Electrical System 23’ Trophy • Owner’s Manual Supplement
Chapter 5: Wiring Diagrams 47 2352 FN Electrical System 23’ Trophy • Owner’s Manual Supplement
48 Chapter 5: Wiring Diagrams 2359 FB AC Electrical System 23’ Trophy • Owner’s Manual Supplement
Chapter 5: Wiring Diagrams 49 2359 FB DC Electrical System 23’ Trophy • Owner’s Manual Supplement
50 Appendix A: Limited Warranty Bayliner warrants to the original purchasers of its 2000 and 2001 model Trophys, purchased from an authorized dealer, operated under normal, noncommercial use that the selling dealer will: (A) Repair any structural hull defect which occurs within ten (10) years of the date of delivery; and (B) Repair or replace any parts found to be defective in factory material or workmanship within one (1) year of the date of delivery.
Owner’s Notes
Owner’s Notes
Part Number 1693938 Bayliner • P.O.
