The information provided in this Owner’s Manual Supplement relates to 1999 & 2000 Bayliner Ciera 22' - 28' Cruisers Engine Serial Number: Hull Identification Number: Hull Identification Number The Hull Identification Number (HIN) is located on the starboard side of the transom. Be sure to record the HIN (and the engine serial numbers) in the space provided above. Please refer to the HIN for any correspondence or orders. HIN LOCATION (TYPICAL) © 2000 Bayliner Marine Technical Publications.
CONTENTS Chapter 1: Welcome Aboard Chapter 2: Components/Systems 1 Dealer Service 6 1 Boating Experience 7 2 Safety Standards 2 Engine & Accessories Guidelines 7 7 2 Qualified Maintenance 3 Structural Limitations 3 Special Care For Moored Boats 3 Sacrificial Anodes (Zincs) 4 Carbon Monoxide (CO) 12 Volt DC System - Fuses and Circuit Breakers Battery Charger Shore Power/110 Volt AC System 9 Fresh Water System 9 Water Heater 9 110-Volt AC/12-Volt DC Refrigerator 10 Alcohol or Al
Chapter 3: Drawings & Diagrams 18 2252 Express (CP) 21 2355 Express (SJ) 25 2452 Express (CD) 28 2655 Sunbridge (SB) 30 2855 Sunbridge (ST) 33 2858 Command Bridge (EC) 38 2859 Express (SC) Chapter 4: Wiring Diagrams 45 2252 Express (CP) 46 2355 Sunbridge (SJ) 47 2452 Express (CD) 48 2655 Sunbridge (SB) 49 2855 Sunbridge (ST), Gas Engine 50 2855 Sunbridge (ST), Diesel Engine 51 2858 Command Bridge (EC), Gas Engine 52 2858 Command Bridge (EC), Diesel Engine 53 2859 Express (SC),
Hazard Boxes & Symbols The hazard boxes and symbols shown below are used throughout this supplement to call attention to potentially dangerous situations which could lead to either personal injury or product damage. Read ALL warnings carefully and follow all safety instructions. DANGER! ! This box alerts you to immediate hazards which WILL cause severe personal injury or death if the warning is ignored.
Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement Chapter 1: Welcome Aboard • This Owner’s Manual Supplement was prepared to provide specific information about your boat. • Study the Cruiser & Yacht Owner’s Manual and this supplement carefully. Pay particular attention to the LIMITED WARRANTY section. • Keep the Cruiser & Yacht Owner’s Manual and this supplement on your boat in a secure, yet easy to get to place.
CHAPTER 1: WELCOME ABOARD Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement Safety Standards DANGER! DANGER ! PERSONAL SAFETY HAZARD! DO NOT allow anyone to ride on parts of the boat not designated for such use. Sitting on seat backs, lounging on the forward deck, bow riding, gunwale riding or occupying the transom platform while underway is especially hazardous and will cause personal injury or death.
Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement CHAPTER 1: WELCOME ABOARD Structural Limitations If equipped, the transom platform and bow platform are designed to be lightweight for proper boat balance. The load limit for these platforms is 30 pounds per square foot, evenly distributed. Special Care For Moored Boats NOTICE • To help seal the hull bottom and reduce the possibility of gelcoat blistering on moored boats, apply an epoxy barrier coating, such as INTERLUX, Interprotect 2000E/2001E.
CHAPTER 1: WELCOME ABOARD Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement Carbon Monoxide (CO) ! DANGER! CARBON MONOXIDE POISONING HAZARD! DANGER Carbon monoxide gas (CO) is colorless, odorless, and extremely dangerous. All engines, generators, and fuel burning appliances produce CO as exhaust. Direct and prolonged exposure to CO will cause BRAIN DAMAGE or DEATH.
Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement CHAPTER 1: WELCOME ABOARD Sources of CO Sources of CO include: a. Using engine or generator when boat is moored in a confined space. b. Mooring close to another boat that is using its engine, generator or any other CO source. c. Running boat with trim angle of bow too high. d. Running boat without through ventilation (station wagon effect). To correct stationary situations (a) and/or (b): • Close all windows, portlights and hatches.
Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement Chapter 2: Components/Systems Electrical System We strongly recommend that you read and understand the Electrical Section of the Owner’s Manual. ! • • • • • DANGER E X T R E M E F IR E /E X P L O S IO N H A Z A R D ! To minimize the risks of fire and explosion, NEVER install knife switches or other arcing devices in the fuel compartments. NEVER substitute automotive parts for marine parts.
Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement CHAPTER 2: COMPONENTS/SYSTEMS 12 Volt DC System - Fuses and Circuit Breakers Both the engine and accessory circuits are protected by a large circuit breaker located on the engine. In addition, a fuse block for branch accessory circuits is located behind the helm panel. Wires are color-coded to indicate which accessory each fuse services. Some items, such as radios and bilge pumps, may be fused individually at the unit.
CHAPTER 2: COMPONENTS/SYSTEMS Ciera 22’ to 28’ Cruisers ! • Owner’s Manual Supplement WARNING F IR E /E X P L O S IO N /S H O C K /E L E C T R IC A L S Y S T E M DAM AGE HAZARD! Before connecting to shore power, all breakers and switches on the AC master panel must be in the OFF position. Always attach the shore power cord to the boat inlet first, then to the dock connection, thereby avoiding accidental submersion of the “HOT” cord into the water.
Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement CHAPTER 2: COMPONENTS/SYSTEMS Fresh Water System Fresh water systems are available on some models. These pressure-type (demand) systems operate when the water pump switch (located near the sink in the cuddy cabin) is in the ON position. Turn the pump switch OFF when the boat is not in use and when the water tank is empty. Stored water can become stagnant and distasteful.
CHAPTER 2: COMPONENTS/SYSTEMS Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement Alcohol or Alcohol/Electric Stove Operating instructions for the alcohol or alcohol/electric stove can be found in the boat’s owner’s packet. Carefully read and follow the manufacturer’s operating instructions and warnings before using the stove. ! WARNING FIRE HAZARD - Reduce the possibility of fire by removing all combustible materials away from the stove before/during use.
Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement CHAPTER 2: COMPONENTS/SYSTEMS Navigation and Interior Lights We strongly recommend that you understand navigation light usage by reading the navigation section of the Owner’s Manual. The navigation and interior lights supplied with your boat are of top quality, but you should be aware that failure may periodically occur for a variety of reasons: 1. 2. 3. 4. There may be a blown fuse (Replace the fuse in the switch panel).
CHAPTER 2: COMPONENTS/SYSTEMS Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement Portable toilet Your boat may come equipped with a portable toilet. Be sure to read and carefully follow the manufacturer’s operating instructions included in your boat’s owner’s packet. Marine Head with Holding Tank Your boat may come equipped with with a marine head and holding tank. Be sure to follow the manufacturer’s operating instructions included in the boat’s owner’s packet.
Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement CHAPTER 2: COMPONENTS/SYSTEMS Fuel System ! WARNING FIRE/EXPLOSION HAZARD - It is very important that the fuel system be inspected thoroughly the first time it is filled and at each subsequent filling. For your safety and the safety of your passengers, the fueling instructions in the Owner’s Manual must be carefully followed. NOTICE Air in the diesel supply system (if equipped) can stop an engine or severely restrict performance.
CHAPTER 2: COMPONENTS/SYSTEMS Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement Fuel Filters All tanks are equipped with a fine mesh screen filter on the fuel pickup tube (located inside or on the outside of the tank) to the fuel line fitting. In addition, when supplied by the engine manufacturer, and additional filter is installed on the engine. Fuel filters should be replaced periodically to ensure they remain clean and free of debris.
Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement CHAPTER 2: COMPONENTS/SYSTEMS Bilge Pumps Your boat is equipped with two impeller-type bilge pumps. They are controlled by a switch on the dash panel, which should be activated whenever water begins to accumulate in the bilge. Some models will also have an automatic bilge pump switch (“autofloat switch”), mounted next to the bilge pump.
CHAPTER 2: COMPONENTS/SYSTEMS Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement Autofloat Switch If applicable, the autofloat switch should also be checked often for proper operation. Lift the float by turning the plastic insert where the wires enter the housing, 1/4 turn counter-clockwise (Fig. 3). As the float is lifted, the bilge pump should turn on. If lifting the float does not turn the pump on, check the inline fuse.
Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement CHAPTER 2: COMPONENTS/SYSTEMS Typical Label Locations WINDSHIELD CLOSED LABEL STEP WARNING LABEL CAPACITY LABEL CARBON MONOXIDE POISON LABEL SUNLOUNGE WARNING MARINE CORE USM THANKS/ 5YEAR/NMMA BOARDING WARNING FUEL WARNING DO NOT STEP LABELS POTABLE WATER LABEL BATTERY LOCATION TRANSOM 17
Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement Chapter 3: Drawings & Diagram s 2252 Express (CP) Layout View Overall Length Bridge Clearance Beam Maximum Draft Fuel Tank Capacity (gal) Water Tank Capacity (gal) 22’ 3” 6’ 6” 8’ 1” 2’ 10” 55 13 Hull Exterior Hardware FISHBOX DRAIN STARBOARD HULLSIDE ANCHOR LOCKER DRAIN AFT BILGE PUMP DRAIN BOW EYE WASTE TANK VENT WATER TANK VENT PORT HULLSIDE BOW EYE GALLEY DRAIN FWD BILGE DRAIN WASTE OVER DRAIN (OPTION) FUEL TANK VENT STERN
Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement CHAPTER 3: DRAWINGS & DIAGRAMS Electrical Routing HULL ELECTRICAL ROUTING AFT BILGE PUMP & FLOAT SWITCH GROUND FUEL TANK PLUG FRESH WATER PUMP MACERATOR PUMP GROUND BLOWER DECK ELECTRICAL ROUTING FWD BILGE PUMP HARD TOP OPTION PLUG FUEL FILL BONDING WIRE SHIFTER FWD BILGE PLUG MARINE HEAD LIGHT HORN SPEAKERS STERN LIGHT DASH { WIPER BOW LIGHTS AFT BILGE ENGINE LIGHTS TRIM PUMP Fresh Water System TO WATER FILL DECK FITTING TO TANK VE
CHAPTER 3: DRAWINGS & DIAGRAMS Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement Galley Drain System SINK THRU-HULL DRAIN HOSE Marine Head (Option) WASTE DECK FITTING TO THRU-HULL TANK VENT THRU-HULL MACERATOR MACERATOR PANEL HOLDING TANK WASTE HOSE HEAD PICKUP SEACOCK VALVE HEAD TO HOLDING TANK MARINE HEAD PICKUP TO MARINE HEAD 20
Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement CHAPTER 3: DRAWINGS & DIAGRAMS 2355 Express (SJ) Layout View Overall Length Bridge Clearance Beam Maximum Draft Fuel Tank Capacity (gal) Water Tank Capacity (gal) 23’ 4” 6’ 2” 8’ 6” 2’ 10” 55 13 Hull Exterior Hardware FUEL TANK VENT AFT BILGE PUMP DRAIN OPTIONAL HOLDING TANK VENT WATER TANK VENT FWD BILGE PUMP DRAIN ANCHOR LOCKER DRAIN STARBOARD HULLSIDE OPTIONAL MACERATOR PUMP DRAIN BOW EYE STEP DRAINS COCKPIT DRAINS PORT HULL
CHAPTER 3: DRAWINGS & DIAGRAMS Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement Electrical Routing DECK ELECTRICAL ROUTING (UNDERSIDE VIEW OF DECK) CABIN LIGHTS (TYPICAL) WINDLASS TOGGLE SWITCH ENTRY STEP LIGHT AFT SPEAKER BERTH LIGHTS WINDLASS MAIN SWITCH SPEAKERS WINDLASS CIRCUIT BREAKER BOW LIGHT STERN LIGHT HORN TO WINDLASS RELAY & DECK SWITCHES WIPER MOTOR BLOWER TRIM TAB PUMP WIRE PLUG TO ENGINE COMPASS HEAD LIGHT SPEAKER SHIFTER WASTE SWITCH AFT BILGE AREA WIRE HARNESS COCKPI
Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement CHAPTER 3: DRAWINGS & DIAGRAMS Fresh Water System Option PORT HULLSIDE GALLEY BACKSIDE TO COLD WATER FAUCET TO HOT WATER FAUCET (OPTION) AFT PORT TO GALLEY TO TRANSOM SHOWER TO THRU-HULL WATER HEATER FROM SINK DRAIN AFT BILGE & STARBOARD HULLSIDE WATER HEATER TO TANK FILL DECK FITTING WATER PUMP TO TANK VENT DECK FITTING TRANSOM FRESH WATER TANK Waste System Option FWD STBD TO DOCKSIDE PUMP-OUT DECK FITTING MARINE HEAD PICKUP SEACOCK
CHAPTER 3: DRAWINGS & DIAGRAMS Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement Air Conditioning Option PICKUP SEACOCK SEA WATER STRAINER A/C WATER PUMP A/C CONTROL PANEL AFT BERTH A/C VENT DRAIN INTO BILGE A/C VENT A/C UNIT ENTRY STEPS TO THRUHULL DRAIN TO DOCKSIDE A/C PANEL PUMP JUNCTION WALL BOX A/C DUCT A/C UNIT 24
Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement CHAPTER 3: DRAWINGS & DIAGRAMS 2452 Express (CD) Layout View Overall Length Bridge Clearance Beam Maximum Draft Fuel Tank Capacity (gal) Water Tank Capacity (gal) Holding Tank Capacity (gal) 23’ 5” 8’ 4” 8’ 4” 2’ 11” 78 20 78 Hull Exterior Hardware FWD BILGE PUMP DRAIN AFT BILGE PUMP DRAIN WATER TANK VENT A/C DRAIN (OPTION) CLAM SHELL OVER ANCHOR LOCKER DRAIN STARBOARD HULLSIDE FISHBOX DRAIN SINK DRAIN BOW EYE WASTE TANK VENT M
CHAPTER 3: DRAWINGS & DIAGRAMS Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement Electrical Routing DECK ELECTRICAL ROUTING DASH HARNESS DINETTE LIGHTS STEREO FUSE BLOCK LOCATION V-BERTH LIGHT HARD TOP WIPERS DINETTE LIGHT HEAD LIGHT CABIN GALLEY LIGHTS SPEAKERS HARDTOP ELECTRICAL ROUTING DASH CONNECTION LIGHTS ANCHOR LIGHT Macerator Option MACERATOR PUMP MARINE HEAD TO WASTE TANK STBD AFT WASTE HOLDING TANK WASTE TANK TO MACERATOR TO PUMP OUT DECK FITTING 26 TO OVERBOARD THRU-HULL
Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement CHAPTER 3: DRAWINGS & DIAGRAMS Fresh Water/Marine Head System PORT FWD SIDE OF BULKHEAD VIEW HEAD PICKUP SEACOCK TO FAUCET HEAD TO WASTE TANK FWD BILGE PUMP FWD FRESH WATER TANK TO FAUCET AFT MARINE HEAD STBD MARINE MARINE HEAD HEAD TO TO WASTE WASTE TANK TANK WATER TANK VENT THRU-HULL FITTING WATER TANK VENT HOSE WASTE HOLDING TANK FWD BILGE PUMP THRU-HULL DRAIN FRESH WATER TANK FROM DECK WATER FILL FITTING Hot Water System Option TO TR
CHAPTER 3: DRAWINGS & DIAGRAMS • Ciera 22’ to 28’ Cruisers Owner’s Manual Supplement 2655 Sunbridge (SB) Layout View Overall Length Bridge Clearance Beam Maximum Draft Fuel Tank Capacity (gal) Water Tank Capacity (gal) Holding Tank Capacity (gal) 27’ 9” 7’ 0” 8’ 5” 2’ 10” 70 27 13 Hull Exterior Hardware AFT BILGE DRAIN FUEL TANK VENT HOLDING TANK VENT FWD BILGE DRAIN WATER TANK VENT SINK DRAIN ANCHOR LOCKER DRAIN STARBOARD HULLSIDE MACERATOR PUMP DRAIN STEP DRAIN SHOWER DRAIN B
Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement CHAPTER 3: DRAWINGS & DIAGRAMS Deck Electrical Routing GALLEY LIGHT SPEAKERS AFT BERTH LIGHTS ENTRY STEP LIGHT WINDLASS CIRCUIT BREAKER STERN LIGHT BOW LIGHT HORN TO DECK RELAY & WINDLASS SWITCHES DOME LIGHTS WIPER MOTOR HEAD LIGHT COMPASS SPEAKERS WINDLASS MAIN SWITCH COCKPIT STEP LIGHT Galley Details SELECTOR SWITCH DOCK SIDE PANEL (OPTION) STEREO MICROWAVE (OPTION) SINK STOVE WATER PUMP SWITCH Marine Head Holding Tank TO VENT TH
CHAPTER 3: DRAWINGS & DIAGRAMS Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement 2855 Sunbridge (ST) Layout View Overall Length Bridge Clearance Beam Maximum Draft Fuel Tank Capacity (gal) Water Tank Capacity (gal) Holding Tank Capacity (gal) 30’ 3” 7’ 5” 9’ 7” 3’ 1” 109 33 13 Hull Exterior Hardware WATER TANK VENT FUEL TANK VENT HOLDING HEAD TANK SINK VENT DRAIN MACERATOR STARBOARD HULLSIDE COCKPIT DRAINS AFT BILGE PUMP STEP DRAIN FWD BILGE PUMP SHOWER DRAIN ANCHOR DRAIN A/
Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement CHAPTER 3: DRAWINGS & DIAGRAMS Hull Electrical Routing BATTERY SWITCH TRIM TAB PUMP FUEL TANK TO MACERATOR PUMP TO BILGE PUMP FLOAT SWITCH TO ENGINE TO BATTERY SWITCH BLOWER BATTERY CHARGER FWD BILGE WIRE ROUTING TO GALLEY HULL WIRE ROUTING WINDLASS BREAKER (OPTION) HEAD OUTLET TO VANITY SHOWER BREAKOUT TO WATER PUMP TO GALLEY TO BILGE PUMP REFRIGERATOR 12 v & 110V Deck Electrical System ENTRY STEP LIGHT GALLEY LIGHT AFT BERTH LIGH
CHAPTER 3: DRAWINGS & DIAGRAMS Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement Helm Area FUSEBLOCK WINDLASS SWITCH (OPTION) WASTE PUMP SWITCH Air Conditioning System AIR CONDITIONING WATER PICKUP AIR CONDITIONING ROUTING TO HANGING LOCKER TOP TO AFT STATE ROOM AC PICKUP SEACOCK TO AC UNIT Freshwater System TRANSOM SHOWER HEAD HEATER PUMP GALLEY TANK Marine Head System and Waste Fitting TO VENT THRU-HULL TO DECK FITTING WASTE FITTING MACERATOR PUMP TO MARINE HEAD 32 DECK LOUVER TO
Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement CHAPTER 3: DRAWINGS & DIAGRAMS 2858 Command Bridge (EC) Layout View Overall Length Bridge Clearance Beam Maximum Draft Fuel Tank Capacity (gal) Water Tank Capacity (gal) Holding Tank Capacity (gal) 30’ 6” 9’ 3” 9’ 10” 3’ 6” 113 34 26 Hull Fittings and Hardware WATER TANK VENT AFT BILGE PUMP DRAIN STARBOARD HULLSIDE CLAM SHELL COVER (ANCHOR WELL DRAIN) BOW EYE FWD BILGE PUMP DRAIN GALLEY SINK DRAIN HEAD SINK DRAIN SHOWER SUMP DRAIN
CHAPTER 3: DRAWINGS & DIAGRAMS Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement 12 Volt DC Wire Routing HULL WIRE ROUTING WINDLASS CIRCUIT BREAKER BATTERY TRIM PUMP MACERATOR AFT BILGE PUMP & FLOAT SWITCH SHOWER SUMP HEAD PICKUP GROUND AFT BERTH LIGHT FUEL TANK SENDER BATTERY CHARGER TRIM TABS ENG GRND COURTESY LIGHT STEP LIGHT ENGINE WATER PUMP READING LIGHT AFT BERTH READING LIGHT FWD BILGE PUMP & FLOAT SWITCH LOWER HELM LIGHT SWITCHES GALLEY WATER PUMP SWITCH BLOWER FUEL FILL G
Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement CHAPTER 3: DRAWINGS & DIAGRAMS 110 Volt AC Wire Routing (Romex) BATTERY CHARGER HANGING LOCKER AFT BERTH CABINET WATER HEATER MICROWAVE GALLEY AC PANEL STOVE REFRIGERATOR GFI FWD HELM Fresh Water System WATER HEATER WATER FILL DECK FITTING TO HEAD FAUCET WATER TANK VENT THRU-HULL FITTING HOT WATER TO GALLEY FAUCET COLD WATER WATER PUMP FWD BILGE PUMP FRESH WATER TANK STBD FWD 35
CHAPTER 3: DRAWINGS & DIAGRAMS Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement A/C Hose Routing (OAB) SEAWATER PUMP AIR COND.
Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement CHAPTER 3: DRAWINGS & DIAGRAMS Marine Head System DOCKSIDE PUMPOUT DECK FITTING TANK VENT THRU-HULL MARINE HEAD HOLDING TANK MARINE HEAD TO HOLDING TANK MACERATOR SEAWATER PICKUP TO MARINE HEAD MACERATOR OUTLET THRU-HULL TRANSOM HEAD PICKUP SEACOCK Seawater Pickup System (Diesel Engine Option) TO DIESEL ENGINE WATER INLET FITTING TRANSOM TO GIMBAL HOUSING WATER INLET FITTING BALL VALVE SEAWATER STRAINER 37
CHAPTER 3: DRAWINGS & DIAGRAMS Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement 2859 Express (SC) Layout View Overall Length Bridge Clearance Beam Maximum Draft Fuel Capacity (gal) Water Tank Capacity (gal) Holding Tank Capacity (gal) 27’ 8” 9’ 1” 9’ 9” 3’ 0” 102 36 30 Hull Exterior Hardware AFT BILGE PUMP DRAIN FWD BILGE PUMP DRAIN HOLDING TANK VENT STARBOARD HULLSIDE BOW EYE MACERATOR PUMP OUT COCKPIT STEP DRAIN HEAD SINK DRAIN GALLEY SINK DRAIN CLAM SHELL OVER ANCHOR LOCKER
Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement CHAPTER 3: DRAWINGS & DIAGRAMS Marine Head System TANK TO MACERATOR TO VENT THRU-HULL WATER HOSE HOLDING TANK HEAD TO TANK HEAD TO HOLDING TANK DECK WASTE FITTING TANK VENT THRU-HULL SEACOCK PICK UP TO HEAD SEA STRAINER FROM MACERATOR TO THRU-HULL MACERATOR PUMP HOLDING TANK Seawater Pickup System (Diesel Engine Option) TRANSOM TO GIMBAL HOUSING WATER INLET FITTING TO DIESEL ENGINE WATER INLET FITTING SEAWATER STRAINER BALL VALVE 39
CHAPTER 3: DRAWINGS & DIAGRAMS Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement Fresh Water System WATER FILL DECK FITTING WATER HEATER TANK VENT HOT FROM WATER HEATER HOT TO HEAD COLD TO HEAD COLD TO GALLEY HOT TO HEAD SINK TO WATER HEATER COLD TO HEATER FRESH WATER TANK HOT TO GALLEY TO WATER FILL DECK FITTING FRESH WATER PUMP TO WATER TANK VENT THRU-HULL Cabin Heat T-FITTING TEMP SENSOR VALVE TO ENGINE MANIFOLD CABIN HEATER ENGINE WATER PUMP WATER HEATER 40
• Ciera 22’ to 28’ Cruisers Owner’s Manual Supplement CHAPTER 3: DRAWINGS & DIAGRAMS Shower Drain System FROM SHOWER DRAIN TO PUMP FROM PUMP TO THRU-HULL FILTER PORT AFT STBD SHOWER PUMP FWD SHOWER PUMP Galley Sink Drain SINK GALLEY HOT GALLEY COLD SINK DRAIN TO THRU-HULL 41
CHAPTER 3: DRAWINGS & DIAGRAMS Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement Deck 12 Volt DC Wire Routing COCKPIT LIGHT DASH INTERIOR LIGHT (TYPICAL PORT/STBD) HEAD LIGHT TO WINDLASS MAIN SWITCH INTERIOR LIGHTS COMPASS WIPER TO WINDLASS TOGGLE SWITCH TO BREAKER & BATTERY SWITCH SPEAKER COMPASS AFT BERTH LIGHTS SPEAKER INTERIOR LIGHTS TO WINDLASS RELAY & DECK SWITCHES AFT BERTH ENTRY LIGHT Hull 12 Volt DC Wire Harness FUEL TANK AFT BILGE PUMP ENGINE 42 TO DECK HARNESS FWD BILGE PU
Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement CHAPTER 3: DRAWINGS & DIAGRAMS Hull 110 Volt AC Harness REFRIGERATOR OUTLET AFT HANGING LOCKER OUTLET TO BATTERY CHARGER HEAD OUTLET TO GALLEY TO DECK Air Conditioning Routing SEAWATER PUMP SEA STRAINER VENT TO AFT BERTH FWD BULKHEAD HIGH SPEED PICK UP AND SEACOCK VALVE A/C UNIT HANGING LOCKER TOP 43
CHAPTER 3: DRAWINGS & DIAGRAMS Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement Helm Area WINDLASS TOGGLE SWITCH MACERATOR PANEL WINDLASS PANEL Fuel System FUEL FILL DECK FITTING FUEL VENT THRU-HULL FUEL TANK 44 FUEL FEED HOSE
Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement Chapter 4: Wiring Diagrams Please read the electrical sections included in the Owner’s Manual and this Owner’s Manual Supplement for important safeguards concerning your boat’s electrical system.
CHAPTER 4: WIRING DIAGRAMS Ciera 22’ to 28’ Cruisers 2355 Sunbridge (SJ) 5A 46 • Owner’s Manual Supplement
Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement CHAPTER 4: WIRING DIAGRAMS 2452 Express (CD) 47
CHAPTER 4: WIRING DIAGRAMS 2655 Sunbridge (SB) 48 Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement
Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement CHAPTER 4: WIRING DIAGRAMS 2855 Sunbridge (ST), Gas Engine 49
CHAPTER 4: WIRING DIAGRAMS 2855 Sunbridge (ST), Diesel Engine 50 Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement
Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement CHAPTER 4: WIRING DIAGRAMS 2858 Command Bridge (EC), Gas Engine 51
CHAPTER 4: WIRING DIAGRAMS Ciera 22’ to 28’ Cruisers TRIM/TAB SWITCH 2858 Command Bridge (EC), Diesel Engine 52 • Owner’s Manual Supplement
Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement CHAPTER 4: WIRING DIAGRAMS 2859 Express (SC), Gas Engine 53
CHAPTER 4: WIRING DIAGRAMS 2859 Express (SC), Diesel Engine 54 Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement
Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement CHAPTER 4: WIRING DIAGRAMS Single Dockside Wiring Diagram 55
CHAPTER 4: WIRING DIAGRAMS Double Dockside Wiring Diagram 56 Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement
Ciera 22’ to 28’ Cruisers • Owner’s Manual Supplement Limited Warranty Bayliner warrants to the original purchasers of its 1999 and 2000 model boats, purchased from an authorized dealer, operated under normal, noncommercial use that the selling dealer will: (A) Repair any structural hull defect which occurs within five (5) years of the date of delivery; and (B) Repair or replace any parts found to be defective in factory material or workmanship within one (1) year of the date of delivery.
Owner’s Notes
Owner’s Notes
Owner’s Notes
Part Number 1706166 Bayliner • P.O.
