Operators Manual

11
Trouble Shooting Guide
GB
Problem Cause Remedy
Engine will not start.
No fuel.
Open fuel tap.
Fill fuel tank.
Engine switched off. Switch engine on.
Spark plug fouled. Clean and reset plug gap.
Engine cold. Close choke.
Engine À ooded.
Honda, open choke, fully open throttle, pull recoil starter
until engine ¿ res.
Hatz, move speed control to stop, pull recoil starter 5 times
then repeat start procedure.
Engine still will not start. Major Fault. Contact Agent or Altrad Belle.
Unit will not move.
Engine speed too slow. Set engine speed control to fast.
Drive belt tension loose. Adjust belt tension
Air ¿ lter blocked. Clean or renew air ¿ lter.
Worn or Damaged Clutch. Repair or Replace as necessary.
Drive failure. Contact Agent or Altrad Belle.
Gearbox failure. Contact Agent or Altrad Belle.
Forward speed too slow.
Too much oil in hydraulic head. Reduce oil level.
Wrong adjustment of control system Contact Agent or Altrad Belle.
Reverse speed too slow.
Not enough oil in hydraulic head. Fill and bleed system.
Air in control system. Bleed control system.
Wrong adjustment of control system Contact Agent or Altrad Belle.
Loss of Hydraulic Oil.
Connectors leaking. Reseal connectors.
Defective hydraulic hose. Replace hose.
Piston seal in gearbox defective. Contact Agent or Altrad Belle.
Machine operates
erratically.
Shock mounts damaged. Replace all four mounts.