Operating instructions

ManualsBrandsBerghoff ManualsDomestic AppliancesK 1024A-KC3

grill

Assembly

▲ WARNING

Improper installation, adjustment, alteration, service or

maintenance can cause injury or property damage.

Read the installation, operation and maintenance

instructions thoroughly before installing or using this

equipment.

▲ DANGER

Not following these instructions could result in ﬁ re or

explosion, that could cause property damage, personal

injury or death.

▲ DANGER

DO NOT use this barbecue for indoor cooking or

heating. TOXIC fumes can accumulate and cause

asphyxiation. DO NOT use it in or on boats or

recreational vehicles.

▲ PROP 65 WARNING

Chemicals, known to the state of California, to cause

cancer, birth defects or other reproductive harm are

created by the combustion of propane.

▲ WARNING FOR YOUR SAFETY:

for outdoor use only (outside any enclosure)

KEEP THESE INSTRUCTIONS NEAR AT HAND FOR FUTURE

REFERENCE. IF YOU HAVE BOUGHT THIS UNIT FOR SOMEONE

ELSE, MAKE SURE THAT YOU ALSO GIVE HIM OR HER THIS

MANUAL.

grill

Installation & operating instructions

The perfect barbecue!

Model: K 1024A-KC3

Art.: 2415238 BBQ Brevio

Berghoff recommend propane gas as fuel for our BBQ’s, as propane

supplies the best heating conditions for BBQ’s.

Therefore, this BBQ has a gas regulator of 37 mbar.

Although using butane gas by changing the gas regulator is possible,

we strongly recommend to stick to propane as the complete manual is

based on propane gas.

If you still insist to change to butane gas please contact your local gas

specialist for a suitable butane gas regulator (28-30 mbar) and for the

correct installation of the regulator.

Note: All defects or problems caused or related to this change to

butane gas are not longer part of the product warranty.

Summary of content (20 pages)

PAGE 1
grillgrill Assembly Installation & operating instructions The perfect barbecue! Model: K 1024A-KC3 Art.: 2415238 BBQ Brevio ! ▲ WARNING Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage. Read the installation, operation and maintenance instructions thoroughly before installing or using this equipment. ! ▲ DANGER Not following these instructions could result in fire or explosion, that could cause property damage, personal injury or death.
PAGE 2
IMPORTANT: READ ALL INSTRUCTIONS AND OPERATIONS BEFORE OPERATING THIS UNIT. FOLLOW ALL STEPS IN ORDER. NEVER ALLOW CHILDREN TO OPERATE THIS UNIT. ▲ ! WARNINGS Only to be used outdoors. Read the instructions before using the appliance. Accessible parts maybe very hot, keep young children away. Do not move the appliance during use. Turn off the gas supply at the gas container after use. Any modification of the appliance may be dangerous.
PAGE 3
2.
PAGE 4
3. Single part list seq. NO. 1. appellation lid qty 1 seq. NO. 2. appellation lid handle qty 1 3. thermometer 1 4. firebox right panel 1 5. shutter right panel 1 6 warming rack bracket 2 7. shutter left panel 1 8. shutter cover board 1 9. Crossover bracket assembly 4 10. main burner tube assembly 5 11. firebox left panel 1 12. inner control panel 1 13. Door spring hinge 2 14. grease tray 1 15. control panel assembly 1 16. control knob 3 17.
PAGE 5
. Mounting steps Make sure your grill is assembled properly. Detailed assembly instructions are packed with each grill giving specific assembly procedures for each model. Follow these instructions carefully to ensure the correct and safe assembly of the grill. ! ▲ CAUTION: Although we take every effort to ensure that the assembly process is as easy as possible, it is inherent with fabricated steel parts that corners and edged can cause cuts if improperly handled during assembly procedures.
PAGE 6
STEP 2: Use 2x B screws to connect the cart right side panel and cart bottom panel. (See figure 2 for reference) Figure 2 B STEP 3: Use 4x B screws to connect the cart back panel and cart assy.
PAGE 7
STEP 4: Fix 4x wheels on the pipes of the cart assy. (See figure 4 for reference) Figure 4 STEP 5: Use 2x B screws to fix the door beam on the cart assy.
PAGE 8
STEP 6: Utilize the wedges to put the front hood assy on the cart assy. (See figure 6 for reference) Figure 6 STEP 7: Put the grease tray into the brace.
PAGE 9
STEP 8: Assemble 2 doors on the cart assy. Pls note the spring hinges under the control panel , first hold down the spring hinge, then push it into the hole of door. (See figure 8 for reference) Figure 8 STEP 9: Put 2 pipes into the right side table .
PAGE 10
STEP 10: Utilize the wedges to assemble the right side table assy on the firebox assy. (See figure 10 for reference) Figure 10 STEP 11: Use 2x C screws to fix the side table with the firebox firmly.
PAGE 11
STEP 12: Put 2 pipes into the left side burner. (See figure 12 for reference) Figure 12 STEP 13: Utilize the wedges to assemble the left side burner assy on the firebox assy.
PAGE 12
STEP 14: Use 2x C screws to fix the side burner with the firebox firmly. (See figure 14 for reference) Figure 14 C STEP 15: Use 2x A screws to fix the nozzle of side burner on the side burner insert tray bracket. Remember the nozzle should aim at the gas inner hole.
PAGE 13
STEP 16: All assembly is finished. (See figure 16 for reference) Figure 16 6. Preparation BergHOFF recommends propane gas as fuel for our BBQ’s, as propane supplies the best heating condition for BBQ’s. Therefore, this BBQ is equiped with a propane regulator 37 mbar. Not included is the LP gas tank. This can be obtained from your nearest gas retailer.
PAGE 14
7. Installation After purchasing your gas bottle you will be ready to set up your gas grill. a) Changing the gas bottle shall be carried out away from any source of ignition. Position the gas bottle at the side of your gas grill, not underneath, keeping in mind that the bottle must be kept away from heat and in a safe position.
PAGE 15
Ensure that the hose is not subjected to twisting which will affect the gas flow when using your gas grill. Also the hose must not have undue tension and must not touch any part of the gas grill which may be hot. Please choose for a flexible hose whose heatproof is higher than 80° C Best change every 2 years the flexible hose or when the national conditions require it. 8. Connecting the Gas Cylinder LP (Liquid Propane) Gas Supply Connection 1.
PAGE 16
9. General safety instructions ! DANGER ▲ ! WARNING ▲ FOR YOUR SAFETY 1. Do not store or use gasoline or other flammable liquids or vapors in the vincinity of this or any other appliance. 2. An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance. you smell gas 1. Shut off gas to appliance. 2. Extinguish any open flame. 3. Open lid. 4. If odor continues, keep away from the appliance and immediately call your gas supplier or your fire department.
PAGE 17
! ▲ ! ▲ We would recommend that this gas grill be serviced by your local gas retail outlet at least once a year by a competent engineer. Do not attempt to service this appliance yourself. Any modification of the appliance may be dangerous. Do not attempt any unauthorized interference of the main controls on this gas grill, i.e. gas taps, injectors, valves etc.
PAGE 18
11. Lighting instructions !! ▲ CAUTION: The lid must be open when lighting the burner! Do not stand with your face directly over the gas grill when lighting it.Your gas grill will have the following method of ignition: Pilot Gas Control Ignition: Put all gas controls (knobs) on the Gas grill in the “OFF” position, turn the gas cylinder valve to the on position at the regulator.
PAGE 19
12. Storage Your Gas Bottle must be stored outdoors in a well ventilated area and must be disconnected from your gas grill when not being used. Ensure that you are outdoors and away from any sources of ignition before attempting to disconnect your gas bottle from your gas grill. When you are using your gas grill after a period of storage, please ensure to check for gas leaks and check for any obstructions in the burner etc. before using. Also follow the cleaning instructions to ensure gas grill is safe.
PAGE 20
14. Gas grill Safety Hints Position your gas grill on a safe level surface, away from inflammable items such as wooden fences or overhanging tree branches. Never use your gas grill indoors! Once lit do not move your gas grill or leave it unattended. Keep children and pets at a safe distance from the gas grill. Keep a fire extinguisher handy. The gas grill will become hot when in use, so handle lids etc. with the help of gloves. Ensure that the appliance has completely cooled down before storing.