Owner/Operator Manual Models X13-PLUS & X13A-PLUS Slicers NOTICIA IMPORTANTE Este manual contiene importantes instrucciones de seguridad que deben ser seguidas el pie de la letra cuando utilice esta maquina. IMPORTANT NOTICE This manual contains Important Safety Instructions which must be strictly followed when using this equipment.
Before Using This Equipment Berkel’s slicers are designed to slice meat and other food products safely and efficiently. However, unless the operator is properly trained and supervised, there is the possibility of a serious injury. It is the responsibility of the owner to ensure that this slicer is used properly and safely, strictly following the instructions contained in this manual and any requirements of local law. No one should use or service this slicer without proper training and supervision.
Table of Contents Page General Safety Instructions.......................................................................................................................... 2 Equipment Description................................................................................................................................. 4 Intended Uses and Characteristics............................................................................................................... 6 Unpacking and Installation..........
PELIGRO CUCHILLA FILOSA para evitar serios accidentes a su persona siga las instrucciones de este manual y 1. NUNCA utilice esta mçquina sin previa instrucciùn y autorizaciùn de su supervisor. 2. LA MçQUINA DEBE apoyarse sobre un nivel solido y plano. 3. LOS PROTECTORES deben colocarse ANTES de enchufar y operar la mçquina. 4. SIEMPRE utilice el enchufe original proveido por el fabricante. 5. SIEMPRE utilice el utensillo para empujar la comida - nunca su mano. 6.
WARNING SHARP KNIFE BLADE to avoid serious personal injury follow all the instructions in this manual and 1. NEVER touch this machine without training and authorization by your supervisor. 2. MACHINE MUST BE on solid level support. 3. GUARDS MUST BE in place before plugging in and turning on machine. 4. ALWAYS use three pronged plug provided. 5. ALWAYS use food pusher not your hand. 6. NEVER TOUCH ROTATING KNIFE. 7. KEEP hands, arms, hair and loose clothing clear of all moving parts. 8.
Equipment Description 4 • X13-PLUS & X13A-PLUS Owner/Operator Manual
Equipment Description X13-PLUS & X13A-PLUS Owner/Operator Manual • 5
Intended Uses and Characteristics Intended Uses The model X13-PLUS and X13A-PLUS slicers are designed for cutting the following types of products: • Meat (without bones) • Cheese • Vegetables The following types of items are NOT suitable for slicing on the Model X13-PLUS or X13A-PLUS slicers: • Non-food products • Frozen foods • Bone in products Special Features/Characteristics Reduced seams and joints for better sanitation Gauge plate interlock for aid in cleaning Left hand thickness adjustment for easier
Operation General 1. Check to see that the center plate and product table are in place on the slicer and the gauge plate is completely closed. The holes in the bottom of the center plate fit over the bottom mounting studs in the ring guard and the center plate locking knob is at the top of the center plate. The product table slides completely onto the support arm and is secured with the red product table locking knob. 2.
Cleaning and Sanitizing The following cleaning procedures have been prepared with the grateful cooperation of Kay Chemical, an Ecolab company. Frequency: The slicer shall be cleaned and sanitized at intervals to comply with national, state and/or local health codes. Supplies: Dish Detergent such as KAY® Pot & Pan Detergent Sanitizer such as KAYQUAT® II Nonabrasive Pad Nylon Brush Cut-Resistant gloves Cloth wipes Note: Sanitizer concentration shall comply with Section 4-501.
10. 11. 12. 13. 14. 15. 16. 17. 18. 19. 20. Put on cut resistant gloves. Pre-scrape food from slicer. Using fresh detergent solution, clean the front side of the knife with a non-abrasive pad, nylon brush, and/or cloth wipes. Always wipe from the center of the knife to the outer edge. Clean the backside of the knife with the fresh detergent solution, non-abrasive pad, nylon brush, and/or cloth wipes.
Sharpening Sharpen only when necessary. Too frequent or prolonged sharpening will prematurely wear the knife and/or stones. The knife should be sharpened when you notice wavy slices or excessive scrap. Only sharpen the knife after it has been cleaned. You cannot effectively sharpen a dirty knife. 1. If it is an automatic slicer, make sure the engagement knob is in the manual position, by pushing in (to the left) the knob on the right side of the support arm. 2.
Troubleshooting Electrical Failure 1. Is the pilot light illuminated? If not: • Is the power cord completely plugged into the wall outlet? • Check the power cord for cuts or breaks. • Are you getting electricity from the wall outlet? Check by plugging in another piece of equipment with the same electrical requirements. 2. Is the pilot light illuminated but blinking? If so, then push the stop button and then the start button.
Specifications Machine Dimensions: Width Length Height 26-3/4" (680mm) 30-1/2" (770mm) 25-1/4" (640mm) Diameter of Knife: 13" (330mm) Slice Thickness: 0 to 1-5/16" (33mm) Slicing Speed (automatic): Low Medium High 20 slices per minute 40 slices per minute 60 slices per minute Stroke Length (automatic): Short Medium Full 5 inches 9 inches 13 inches Slicing Capacity: Square Round Rectangle 7-1/2" x 7-1/2" (190mm x 190mm) 8-1/2" (220mm) 10-1/2" x 6-3/4" (265mm x 170mm) Net Weight: Manual Automatic
Optional Accessories Vegetable Chute (4975-00463) A vegetable chute is available that fits on the product table. The vegetable chute is used for quantity slicing of various size fruit, meats or vegetables. Trays Slaw Tray (3875-00241) The slaw tray is a deep tray to receive a large quantity of product and retain the juices.
Warranty Effective: February 14, 2002 Berkel Company (“Berkel”) warrants to the Buyer of new equipment that said equipment, when installed in accordance with our instructions and subjected to normal use, is free from defects in material or workmanship for a period of one (1) year from the date of sale.1 BERKEL SPECIFICALLY DISCLAIMS ANY IMPLIED WARRANTY OF MERCHANTABILITY OR EXPRESS OR IMPLIED WARRANTY OF FITNESS FOR A PARTICULAR PURPOSE.