SDS

ManualsBrandsBernzomatic ManualsToolsTS3500KC Multi-Use Torch Kit

SAFETY DATA SHEET

1. Identification

Product identifier Propane

Other means of identification

SDS number

WC002

Product code

UN1075

Recommended use

Portable fuel.

Recommended restrictions

None known.

Manufacturer/Importer/Supplier/Distributor information

Manufacturer/Supplier

Worthington Cylinder Corporation

Address

300 E. Breed St., Chilton, WI 5301

United States

Contact person

Ann Stiefvater

E-mail address

Ann.Stiefvater@worthingtonindustries.com

Telephone number

1-920-849-1740

Emergency telephone

number

1-703-527-3887 International / CHEMTREC 1-800-424-9300 Domestic

2. Hazard(s) identification

Category 1Flammable gases

Physical hazards

Liquefied gasGases under pressure

Not classified.

Health hazards

Not classified.

OSHA defined hazards

Label elements

Signal word

Danger

Hazard statement

Extremely flammable gas. Contains gas under pressure; may explode if heated.

Precautionary statement

Prevention

Keep away from heat/sparks/open flames/hot surfaces. - No smoking.

Response

Leaking gas fire: Do not extinguish, unless leak can be stopped safely. Eliminate all ignition

sources if safe to do so.

Storage

Protect from sunlight. Store in a well-ventilated place.

Disposal

Dispose of waste and residues in accordance with local authority requirements.

Hazard(s) not otherwise

classified (HNOC)

May displace oxygen and cause rapid suffocation.

3. Composition/information on ingredients

Mixtures

74-98-6 87.5-100Propane

CAS number %Chemical name

74-84-0 0-7Ethane

115-07-1 0-5Propylene

106-97-8 0-2.5Butane

SDS US

Propane

919503 Version #: 02 Revision date: 11-September-2014 Issue date: 05-May-2014

1 / 8

Summary of content (8 pages)

PAGE 1
SAFETY DATA SHEET 1. Identification Product identifier Propane Other means of identification SDS number WC002 UN1075 Product code Recommended use Portable fuel. Recommended restrictions None known. Manufacturer/Importer/Supplier/Distributor information Manufacturer/Supplier Address Contact person E-mail address Telephone number Emergency telephone number Worthington Cylinder Corporation 300 E. Breed St., Chilton, WI 5301 United States Ann Stiefvater Ann.Stiefvater@worthingtonindustries.
PAGE 2
Additives Chemical name Ethyl Mercaptan Composition comments CAS number % 75-08-1 <0.005 All concentrations are in percent by weight unless ingredient is a gas. Gas concentrations are in percent by volume. 4. First-aid measures Move to fresh air. If breathing is difficult, give oxygen. If not breathing, give artificial respiration. Call a physician or poison control center immediately. Remove contaminated clothing immediately and wash skin with soap and water.
PAGE 3
Conditions for safe storage, including any incompatibilities Store in accordance with local, regional, national, and international regulations. Secure cylinders in an upright position at all times, close all valves when not in use. Store in a cool, dry, well-ventilated place. Keep container tightly closed and sealed until ready for use. Protect cylinders from damage. 8. Exposure controls/personal protection Occupational exposure limits US. OSHA Table Z-1 Limits for Air Contaminants (29 CFR 1910.
PAGE 4
Odor threshold Not available. pH Not applicable. Melting point/freezing point -306.4 °F (-188 °C) Initial boiling point and boiling range -43.6 °F (-42 °C) 14.7 psia Flash point -155.2 °F (-104.0 °C) Evaporation rate Not applicable. Flammability (solid, gas) Extremely flammable gas. Upper/lower flammability or explosive limits Explosive limit - lower (%) 2.15 % Explosive limit - upper (%) 9.6 % Vapor pressure 127 psig (21°C / 70°F) Vapor density Not available. Relative density 0.
PAGE 5
Components Species Test Results Mouse 680 mg/l, 2 Hours Rat 658 mg/l, 4 Hours Rat > 1442 mg/l, 15 Minutes Mouse 680 mg/l, 2 Hours Rat 658 mg/l, 4 Hours Species Test Results Acute Dermal LD50 Rat > 2000 mg/kg Inhalation LC50 Mouse 4420 mg/l, 4 Hours Oral LD50 Rat 682 mg/kg Butane (CAS 106-97-8) Acute Inhalation LC50 Propane (CAS 74-98-6) Acute Inhalation LC50 Propylene (CAS 115-07-1) Acute Inhalation LC50 Additives Ethyl Mercaptan (CAS 75-08-1) Skin corrosion/irritation Contact with
PAGE 6
None known. Other adverse effects 13. Disposal considerations Use the container until empty. Do not dispose of any non-empty container. Empty containers have residual vapor that is flammable and explosive. Cylinders should be emptied and returned to a hazardous waste collection point. Do not puncture or incinerate even when empty. Dispose in accordance with all applicable regulations.
PAGE 7
TSCA Section 12(b) Export Notification (40 CFR 707, Subpt. D) Not regulated. US. OSHA Specifically Regulated Substances (29 CFR 1910.1001-1050) Not listed. CERCLA Hazardous Substance List (40 CFR 302.
PAGE 8
US - California Proposition 65 - Carcinogens & Reproductive Toxicity (CRT): Listed substance Not listed.