R INSTALLATION AND OPERATING INSTRUCTIONS Models: DMXS-H DMXS-S DMXD-H DMXD-S RACER MERCHANDISERS INTENDED FOR OTHER THAN HOUSEHOLD USE RETAIN THIS MANUAL FOR FUTURE REFERENCE UNIT MUST BE KEPT CLEAR OF COMBUSTIBLES AT ALL TIMES ! FOR YOUR SAFETY: Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. ! ! WARNING: Improper installation, adjustment, alteration, service or maintenance can cause property damage, injury or death.
APW Wyott takes pride in the design and quality of our products. When used as intended and with proper care and maintenance, you will experience years of reliable operation from this equipment. To ensure best results, it is important that you read and follow the instructions in this manual carefully. Installation and start-up should be performed by a qualified installer who thoroughly read, understands and follows these instruction.
1. IMPORTANT SAFETY INSTRUCTIONS ! IMPORTANT: Read the following important safety instructions to avoid personal injury or death, and to avoid damage to the equipment or property. ! ! WARNING: Plug unit into a properly grounded electrical outlet of the correct voltage, size and plug configuration. If the plug and receptacle do not match, contact a qualified electrician to determine the proper voltage and size and install the proper electrical outlet. ! ! WARNING: Unit is not waterproof.
2. INSTALLATION ALL MODELS All APW/Wyott Racer Merchandisers are shipped with most components pre-assembled. Care should be taken when unpacking shipping carton to avoid damage to unit and components enclosed. 1. 2. 3. 4. Remove unit from box. Remove information packet. Remove tape and protective packaging from all surfaces of unit. The unit is supplied with product divider bars. To install them, simply place the bars in the channels provided.
DMX UNIT DIMENSIONS DMX RACER MERCHANDISERS MODEL # WIDTH HEIGHT DEPTH MODEL # WIDTH HEIGHT DEPTH DMXS-30H DMXS-36H DMXS-42H DMXS-48H DMXS-54H DMXS-60H DMXD-30H DMXD-36H DMXD-42H DMXD-48H DMXD-54H DMXD-60H 30" 36" 42" 48" 54" 60" 30" 36" 42" 48" 54" 60" 18" 18" 18" 18" 18" 18" 29" 29" 29" 29" 29" 29" 27.25" 27.25" 27.25" 27.25" 27.25" 27.25" 27.25" 27.25" 27.25" 27.25" 27.25" 27.
Line 20 AMPS Neutral Line Earth Ground Line 125/250V ! 72.000 CAUTION: Electrical outlet must be configured the same as the plug configuration. Consult your electrician before installing the unit. If the plug configuration is not correct the unit will not function correctly and may damage the unit. ! 4.
WIRING DIAGRAM 120V UNITS, DMXS-30 THRU 42 15 13 4 11 10 5 7 3 26 14 25 24 22 14 21 1 8 6 9 16 15 23 13 12 2 23 17 BUTT SPLICE BUTT SPLICE BUTT SPLICE 27 18 BUTT SPLICE WIRING DIAGRAM 120V UNITS, DMXS-48 THRU 60 15 4 11 10 30 5 32 7 13 3 14 26 25 22 24 14 21 9 29 6 31 8 1 15 23 12 16 2 23 17 SPLICE 120 VOLT 7 18 SPLICE 13
WIRING DIAGRAM 120V UNITS, DMXD-30 THRU 42 15 4 13 11 10 5 7 3 14 26 25 24 22 14 21 9 6 1 8 15 23 12 16 13 2 23 17 20 19 BUTT SPLICE BUTT SPLICE BUTT SPLICE 27 BUTT SPLICE 18 15 13 BUTT SPLICE 19 20 23 2 12 9 23 6 8 1 21 14 22 14 4 11 10 5 7 16 3 13 15 8 25 24 26
WIRING DIAGRAM 120/208V UNITS, DMXD-48 THRU 60 15 4 11 10 30 5 32 7 13 3 14 25 26 22 24 14 21 9 29 6 31 8 1 15 23 12 16 13 2 23 19 17 SPLICE 18 SPLICE 20 15 13 SPLICE 28 23 2 12 9 23 29 6 31 8 14 22 14 4 11 10 30 5 32 7 3 13 15 9 16 1 21 25 26 24 SPLICE 19
WIRING DIAGRAM 240V, 50HZ UNITS 24 24 25 25 31 31 22 22 HEATERS & LIGHTS FOR TOP SHELF 26 26 21 21 20 20 27 27 34 34 23 23 28 28 28 28 EXISTING WIRE 32 32 BLANKET HEATER FOR MIDDLE SHELF 23 23 30 30 29 29 29 29 30 30 77 88 13 13 31 31 99 44 3 3 10 10 32 32 55 HEATERS & LIGHTS FOR MIDDLE SHELF 66 14 14 34 34 11 11 11 11 EXISTING WIRE BLANKET HEATER FOR BOTTOM SHELF 14 14 1515 12 12 15 15 16 16 13 13 30 30 66 EXISTING WIRE 32 32 THERMOSTAT PILOT LIGHT EXISTING WIRE
5. MAINTENANCE GENERAL The APW/Wyott Racer Merchandisers are designed for maximum durability and performance, with minimum maintenance. ! WARNING: To avoid any injury, turn the power switch off at the fuse disconnect switch/circuit breaker or unplug the unit from the power source and allow to cool completely before performing any maintenance or cleaning. ! ! WARNING: To avoid electrical shock or personal injury, do not steam clean or use excessive water on the unit.
7.
EXPLODED VIEW DMXS-H 12 “B” 25 6 15 14 20 13 8 21 19 13 22 DETAIL “A” 17 18 4 10 7 9 8 24 1 11 3 2 DETAIL “B” “A” 23 5 16
PARTS LIST DMXS-S ITEM P/N 1 2 3 4 5 1481510 1301900 8700700 45653000 21779885 21779601 21779886 21779887 21779888 21779889 21779880 21779602 21779881 21779882 21779883 21779884 21779860 21779761 21779861 21779862 21779863 21779864 21779865 21779766 21779866 21779867 21779868 21779869 21779715 21779620 21779716 21779717 21779718 21779624 21779720 21779671 21779724 21779726 21779728 21779730 6 7 14 N/S N/S N/S N/S N/S N/S N/S N/S N/S N/S N/S N/S N/S N/S N/S N/S N/S N/S DESCRIPTION THERMOSTAT TOGGLE S
EXPLODED VIEW DMXS-S 8 11 12 1 26 9 2 7 8 18 15 6 10 20 13 19 17 DETAIL “A” “A” 16 22 15 21 24 5 4 3 25 “B” 14 23 DETAIL “B”
PARTS LIST DMXD-H ITEM P/N 1 2 3 4 5 1481510 1301900 8700700 45653000 21779885 21779601 21779886 21779887 21779888 21779889 21779880 21779602 21779881 21779882 21779883 21779884 21779860 21779761 21779861 21779862 21779863 21779864 21779865 21779766 21779866 21779867 21779868 21779869 21779715 21779620 21779716 21779717 21779718 21779624 21779720 21779671 21779724 21779726 21779728 21779730 21779625 8816300 21779605 6 7 16 N/S N/S N/S N/S N/S N/S N/S N/S N/S N/S N/S N/S N/S N/S N/S N/S N/S N/S 8 9 10
EXPLODED VIEW DMXD-H 8 12 24 10 1 26 18 4 2 19 27 8 9 16 17 7 3 DETAIL “A” 6 5 15 6 17 21 25 11 10 14 23 “B” “A” 20 13 22 DETAIL “B”
PARTS LIST DMXD-S ITEM P/N 1 2 3 4 5 1481510 1301900 8700700 45653000 21779885 21779601 21779886 21779887 21779888 21779889 21779880 21779602 21779881 21779882 21779883 21779884 21779860 21779761 21779861 21779862 21779863 21779864 21779865 21779766 21779866 21779867 21779868 21779869 21779715 21779620 21779716 21779717 21779718 21779624 21779720 21779671 21779724 21779726 21779728 21779730 21779625 8816300 21779608 21779607 6 7 18 N/S N/S N/S N/S N/S N/S N/S N/S N/S N/S N/S N/S N/S N/S N/S N/S N/S N/
EXPLODED VIEW DMXD-S 11 8 25 12 27 1 8 4 2 7 19 9 3 19 DETAIL “A” 28 10 18 5 16 6 22 15 14 20 17 13 “B” 24 26 21 “A” DETAIL “B” 23
8. APW WYOTT EQUIPMENT LIMITED WARRANTY APW Wyott Foodservice Equipment Company warrants it's equipment against defects in materials and workmanship, subject to the following conditions: This warranty applies to the original owner only and is not assignable. Should any product fail to function in its intended manner under normal use within the limits defined in this warranty, at the option of APW Wyott such product will be repaired or replaced by APW Wyott or its Authorized Service Agency.