UCCDS20T UCCDS40H UCCDM36T UCCDL27H UCCDS20H UCCDM18T UCCDM36H UCCDL36T UCCDS30T UCCDM18H UCCDL18T UCCDL36H UCCDS30H UCCDM27T UCCDL18H UCCDM-10-30T UCCDS40T UCCDM27H UCCDL27T UCCDM-10-30H UCCDM-10-40T UCCDM-10-40H UCCDM-12-48T UCCDM-12-48H UCCDS-12-48T UCCDS-12-48H iPad®, Chromebook®, Tablet, and Laptop Cart, Double Frame Mobile, secure, and powered storage for up to 18, 20, 27, 30, 36, 40, or 48 computing devices. The perfect storage solution for tablets, notebooks, and laptops.
FCC and IC RFI Statements/NOM Statement FEDERAL COMMUNICATIONS COMMISSION AND INDUSTRY CANADA RADIO FREQUENCY INTERFERENCE STATEMENTS This equipment generates, uses, and can radiate radio-frequency energy, and if not installed and used properly, that is, in strict accordance with the manufacturer’s instructions, may cause interference to radio communication.
NOM Statement 4. Todas las instrucciones de operación y uso deben ser seguidas. 5. El aparato eléctrico no deberá ser usado cerca del agua—por ejemplo, cerca de la tina de baño, lavabo, sótano mojado o cerca de una alberca, etc. 6. El aparato eléctrico debe ser usado únicamente con carritos o pedestales que sean recomendados por el fabricante. 7. El aparato eléctrico debe ser montado a la pared o al techo sólo como sea recomendado por el fabricante. 8.
NOM Statement 16. El cable de corriente deberá ser desconectado del cuando el equipo no sea usado por un largo periodo de tiempo. 17. Cuidado debe ser tomado de tal manera que objectos liquidos no sean derramados sobre la cubierta u orificios de ventilación. 18.
Trademarks Used In This Manual Trademarks Used In This Manual Black Box and the Double Diamond logo are registered trademarks of BB Technologies, Inc. Any other trademarks mentioned in this manual are acknowledged to be the property of the trademark owners. UCCDM20-T 724-746-5500 | blackbox.
Table of Contents Table of Contents 1. Specifications ....................................................................................................... 7 2. Overview............................................................................................................ 14 2.1 Introduction........................................................................................ 14 2.2 What‘s Included ................................................................................. 14 2.
Chapter 1: Specifications 1. Specifications Table 1-1. Cart Specifications Part Number UCCDS20T, UCCDS30T, UCCDS20H UCCDS30H UCCDS40T, UCCDS40H Slot Dimensions Height (in.) 13" 13" 13" Height (cm) 33.02 cm 33.02 cm 33.02 cm Width (in.) 1.36" 1.3.6" 1.36" Width (cm) 3.45 cm 3.45 cm 3.45 cm Depth (in.) 10" 10" 10" Depth (cm) 25.4 25.4 cm 25.4 cm Device Capacity Number of Devices 20 30 40 External Dimensions (Including Handle)* Height (in.) 44.27" 44.27" 44.
Chapter 1: Specifications Table 1-1 (continued). Cart Specifications Part Number UCCDM18T, UCCDM18H UCCDM27T, UCCDM27H UCCDM36T, UCCDM36H Slot Dimensions Height (in.) 13" 13" 13" Height (cm) 33.02 cm 33.02 cm 33.02 cm Width (in.) 1.53" 1.53" 1.53" Width (cm) 3.89 cm 3.89 cm 3.89 cm Depth (in.) 15" 15" 15" Depth (cm) 38.1 cm 38.1 cm 38.1 cm Number of Devices 18 Device Capacity 27 36 External Dimensions (Including Handle)* Height (in.) 44.27" 44.27" 44.27" Height (cm) 112.
Chapter 1: Specifications Table 1-1 (continued). Cart Specifications Part Number UCCDL18T, UCCDL18H UCCDL27T, UCCDL27H UCCDL36T, UCCDL36H Slot Dimensions Height (in.) 13" 13" 13" Height (cm) 33.02 cm 33.02 cm 33.02 cm Width (in.) 1.53" 1.53" 1.53" Width (cm) 3.89 cm 3.89 cm 3.89 cm Depth (in.) 17" 17" 17" Depth (cm) 43.18 cm 43.18 cm 43.18 cm Number of Devices 18 Device Capacity 27 36 External Dimensions (Including Handle)* Height (in.) 44.27" 44.27" 44.
Chapter 1: Specifications Table 1-1 (continued). Cart Specifications Part Number UCCDM-10-30H, UCCDM-10-30T UCCDM-10-40H, UCCDM-10-40T Slot Dimensions Height (in.) 13" 13" Height (cm) 33.02 cm 33.02 cm Width (in.) 1.36" 1.36" Width (cm) 3.45 cm 3.45 cm Depth (in.) 13" 13" Depth (cm) 33.02 cm 33.02 cm Number of Devices 30 Device Capacity 40 External Dimensions (Including Handle)* Height (in.) 44.27" 44.27" Height (cm) 112.4 cm 112.4 cm Width (in.) 54.41" 54.
Chapter 1: Specifications Table 1-1 (continued). Cart Specifications Part Number UCCDM-12-48T, UCCDM-12-48H UCCDS-12-48T, UCCDS-12-48H Slot Dimensions Height (in.) 13" 13" Height (cm) 33.02 cm 33.02 cm Width (in.) 1.12" 1.12" Width (cm) 2.84 cm 2.84 cm Depth (in.) 15" 10" Depth (cm) 38.1 cm 25.4 cm Number of Devices 48 Device Capacity 48 External Dimensions (Including Handle)* Height (in.) 44.27" 44.27" Height (cm) 112.4 cm 112.4 cm Width (in.) 54.41" 54.41" Width (cm) 138.
Chapter 1: Specifications Table 1-2. Power Strip Specifications Part Number Timer Included Power Strips (1) 4-outlet, 4-bank timer with ”always-on outlet,” 15-minute increments, UCCDS30T, 100–125 V, 50–60 Hz, UCCDS30H, UCCDM-10-30T, 15 amp max. UCCDM-10-30H (2) 12-outlet, 15 A max. UCCDS40T, UCCDS40H, UCCDM-10-40T, UCCDM-10-40H (4) 12-outlet, 15 A max. UCCDM18T, UCCDM18H (2) 12-outlet, 15 A max. UCCDM27T, UCCDM27H (3) 12-outlet, 15 A max. UCCDM36T, UCCDM36H (3) 12-outlet, 15 A max.
Chapter 1: Specifications Table 1-3. Accessories Specifications Part Number Accessory Specs UCCSHELFS Small device shelf Number of Slots: 10; Slot Dimensions: 1.32"W x 10"D UCCSHELFM Medium device shelf Number of Slots: 9; Slot Dimensions: 1.52"W x 15"D UCCSHELFL Large device shelf Number of Slots: 9; Slot Dimensions: 1.
Chapter 2: Overview 2. Overview 2.1 Introduction The iPad®, Chromebook®, Tablet, and Laptop Cart is designed to store, charge, and transport tablets, e-readers, laptops, netbooks, and other similar devices. Units are available with capacities for 18, 20, 27, 30, 36, or 40 separate storage slots. Each unit plugs into a typical 120-volt 15-amp outlet. Carts are available with Sliding or solid-steel doors. Please read these operating instructions carefully.
Chapter 2: Overview 2.3 Hardware Description Cable Grommet or Pop-Up Power Module Laminate Top Ventilation Handle and Power Cord Wrap Removable Rear Door Sliding Door Cable Access Non-Locking Casters Locking SwivelCasters Figure 2-1. Front and back of cart with Sliding door. Ventilation Cable Grommet or Pop-Up Power Module Laminate Top Handle and Power Cord Wrap Removable Rear Door Solid Steel Door Non-Locking Casters Cable Access Locking SwivelCasters Figure 2-2.
Chapter 3: Electrical Precautions 3. Electrical Precautions • The power switch must be in the “OFF” position before plugging the iPad, Chromebook, Tablet, and Laptop Cart into a wall receptacle. • The Cart must ONLY be connected to a 120-volt AC 15- or 20-amp power supply. • The Cart must only be used by adults or with adult supervision. • Always store the power cord around the cord wraps when transporting the Cart. • Never pull the Cart by the power cord.
Chapter 4: Configuration and Setup 4. Configuration and Setup Remove and discard all packaging materials and then lock the lockable casters. Open and inspect the Cart to verify all doors, locks, and casters are working properly. Do not plug the Cart into a wall outlet until all configurations and setup are complete. 4.1 Installing the Handle The handle/cord wrap installs on the side of the cart with the locking swivel casters. NOTE: The casters swivel on one side of the Cart and are fixed on the other.
Chapter 4: Configuration and Setup 4.2 Routing the Cable (UCCDS20T, UCCDS20H, UCCDS30T, UCCDS30H, UCCDS40T, UCCDS40H) 1. A t the back of the cart, loosen the two screws on the cable manager, pull up on the top section of the cable manager, and place the device side of the charging cable into one of the slots. (See Figure 4-2.) Cable manager Loosen screws on cable manager and pull up Route cable to the front of the cart Power Strip Wrap excess cable around cable wrap Charger Figure 4-2.
Chapter 4: Configuration and Setup Loosen screws on cable manager and pull up Cable manager Route cable to the front of the cart Figure 4-3. Routing the cable. 4.3 Fastening the Power Bricks and Routing the Cable (UCCDM18T, UCCDM18H, UCCDM27T, UCCDM27H, UCCDM36T, UCCDM36H, UCCDL18T, UCCDL18H, UCCDL27T, UCCDL27H, UCCDL36T, UCCDL36H) 1. A ttach the wrapped cord and power brick to the back of the shelf using the hook and loop strap. Keep some extra cable unwrapped to plug into the power strip.
Chapter 4: Configuration and Setup Route cable to the front of the cart Loosen screws on cable manager and pull up Cable manager Power brick and cord Power strip Figure 4-4. Fastening the power brick and routing the cable.. Page 20 724-746-5500 | blackbox.
Chapter 5: Using Your iPad, Chromebook, Tablet, and Laptop Cart 5. Using Your iPad, Chromebook, Tablet, and Laptop Cart 5.1 Charging Your Computers • After the devices have been loaded into the Cart, plug the power cord of the Cart into a suitable receptacle. • Locate the internal power switches on the timer and power strips of the Cart and push the switches to the ON position. 5.2 Moving Your iPad, Chromebook, Tablet, and Laptop Cart • Turn the timer power switch to the off position.
Chapter 5: Using Your iPad, Chromebook, Tablet, and Laptop Cart Timer Power cord To wall outlet Cable access ports Figure 5-1. Plug the cart into the wall. Page 22 724-746-5500 | blackbox.
Chapter 5: Using Your iPad, Chromebook, Tablet, and Laptop Cart 5.3 Timer Instructions Before using your timer: • For your safety, we recommend that a qualified electrician test the circuit you will plug the cart into. The circuit should be checked for ground integrity and appropriate branch circuit protection. • The cart’s ground prong must be present for safe operation. If the plug is damaged or if the ground prong has been removed, it should be replaced by a qualified electrician.
Black Box Tech Support: FREE! Live. 24/7. Tech support the way it should be. Great tech support is just 60 seconds away at 724-746-5500 or blackbox.com. About Black Box Black Box Network Services is your source for an extensive range of networking and infrastructure products. You’ll find everything from cabinets and racks and power and surge protection products to media converters and Ethernet switches all supported by free, live 24/7 Tech support available in 60 seconds or less. © Copyright 2015.
Resources Appendix: Resources Do you have technical questions about this product or similar technology? Check out the Resources listed below or contact our FREE Technical Support at 724-746-5500 or info@blackbox.com. White Papers: To dowload a white paper, click on the corresponding link listed below: Whitepapers Cabinets and Racks Digital Signage and Multimedia (Continued) Retrofitting with passive water cooling at the rack level.
Resources Whitepapers Networking Testers and Tools Eliminate the need to buy and install expensive network equipment by using wireless Ethernet extension. 5 Questions You Need to Ask When Choosing Wireless Ethernet Extenders See how industrial-strength Ethernet has come of age. Ethernet in Harsh Environments Integrate fiber optic cabling to add speed, distance, and cost savings. Media Converters Add low-voltage devices and network equipment in industrial environments without running power.