Bright White 5X5 Matrix Blizzard Lighting, LLC www.blizzardlighting.
TABLE OF CONTENTS COBZilla™ Bright White 5X5 Matrix 1 1. Getting Started 3 What’s In The Box? 3 Getting It Out Of The Box 3 Powering Up! 3 Getting A Hold Of Us 3 Safety Instructions (Don’t Stick Your Hand In The Toaster!) 4 2. Meet The COBZilla™ Bright White 5X5 Matrix 6 5 Features 5 DMX Quick Reference 5 The COBZilla™ Bright White 5X5 Matrix Pin-up Picture 3.
1.
SAFETY INSTRUCTIONS • Please keep this User Guide for future use. If you sell the unit to someone else, be sure that they also receive this User Guide. • ALWAYS make sure that you are connecting to the proper voltage, and that the line voltage you are connecting to is not higher than that stated on the decal or rear panel of the fixture. • This product is intended for indoor use only. • To prevent risk of fire or shock, do not expose fixture to rain or moisture.
2.
Figure 1: The COBZilla™ Bright White 5X5 Matrix Pin-Up Picture 25 High Power Cool White COB LED’s Tough Steel Enclosure Figure 2: The Rear Connections LED Control Panel Fixture Link Bracket Mount Adjustment Knobs Safety Cable Attachment Point DMX In DMX Out AC Power IN/ Power Out Page 6 CobZilla™ Bright White 5X5 Matrix Manual Rev.
3. SETUP Fuse Replacement CAUTION! The COBZilla™ Bright White 5X5 Matrix utilizes a highoutput switch-mode power supply with an internal fuse. Under normal operating conditions, the fuse should not require replacement. The fuse is field replaceable, however it is an advanced procedure suited to qualified individuals. Should your COBZilla™ Bright White 5X5 Matrix™ fuse require replacement, please contact Blizzard Lighting for instructions, or to return your unit for service.
Cable Connectors Cables must have a male XLR connector on one end and a female XLR connector on the other end. (Duh!) CAUTION: Do not allow contact between the common and the fixture’s chassis ground. Grounding the common can cause a ground loop, and your fixture may perform erratically. Test cables with an ohm meter to verify correct polarity and to make sure the pins are not grounded or shorted to the shield or each other.
Fixture Linking (Master/Slave Mode) 1. Connect the (male) 3 pin connector side of the DMX cable to the output (female) 3 pin connector of the first fixture. 2. Connect the end of the cable coming from the first fixture which will have a (female) 3 pin connector to the input connector of the next fixture consisting of a (male) 3 pin connector. Then, proceed to connect from the output as stated above to the input of the following fixture and so on.
4. OPERATING ADJUSTMENTS The Control Panel All the goodies and different modes possible with the COBZilla™ Bright White 5X5 Matrix are accessed by using the control panel on the rear of the fixture. There are 4 control buttons below the LED display which allow you to navigate through the various control panel menus. Is used to navigate to the previous higher-level menu item. Scrolls through individual menu options Scrolls through menu items and numbers in Ascending order.
Control Panel Menu Structure d001 DMX Mode 1-ch 4-ch, 25ch, 28ch Soud SU.00-31 1, 4, 25, 28-Channel Modes Sound Active Mode Sound Sensitivity Char Character Mode LEtt Individual Letter Mode PA A-Z nUbe Individual Number Mode PA 0-9 TEST Test Mode AUTO Auto Play Pr01-27 SLAv Slave Mode Built In Programs Page 11 CobZilla™ Bright White 5X5 Matrix Manual Rev.
DMX Mode Allows the unit to be controlled by any universal DMX controller. If you are unfamiliar with DMX, please read the DMX Primer on page #16. 1.) The COBZilla™ Bright White 5X5 Matrix is capable of operating with 1, 4, 25, or 28 DMX channels. To select the channel mode that you desire, First press the button to select d001 on the LED Readout. Then press the button to select channel mode, 1-ch, 4-ch, 25ch or 28ch. Use the or to select desired channel.
DMX Values In-Depth (1-Channel Mode) Channel Channel Value Does... 1 000 <-> 255 Dimmer 0%-100% DMX Values In-Depth (4-Channel Mode) Channel Channel Value Does...
DMX Values In-Depth (28-Channel Mode) Channel Channel Value Does...
Troubleshooting Symptom Solution Fixture AutoShut Off Check the fan in the fixture. If it is stopped or moving slower than normal, the unit may have shut itself off due to high heat. This is to protect the fixture from overheating. Clear the fan of obstructions, or return the unit for service. Beam is Dim Check optical system and clean excess dust/grime. Also ensure that the 220V/110V switch is in the correct position, if applicable.
5. APPENDIX A Quick Lesson On DMX DMX (aka DMX-512) was created in 1986 by the United States Institute for Theatre Technology (USITT) as a standardized method for connecting lighting consoles to lighting dimmer modules. It was revised in 1990 and again in 2000 to allow more flexibility. The Entertainment Services and Technology Association (ESTA) has since assumed control over the DMX512 standard. It has also been approved and recognized for ANSI standard classification.
Keeping Your COBZilla™ Bright White 5X5 Matrix As Good As New The fixture you’ve received is a rugged, tough piece of pro lighting equipment, and as long as you take care of it, it will take care of you. That said, like anything, you’ll need to take care of it if you want it to operate as designed. You should absolutely keep the fixture clean, especially if you are using it in an environment with a lot of dust, fog, haze, wild animals, wild teenagers or spilled drinks.
Tech Specs! Weight & Dimensions Length 17.75 inches (451 mm) Depth 11.5 inches (292.1 mm) including bracket Height 17.75 inches (451 mm) Weight 12.95 lbs (5.86 kg) Power Operating Voltage 100-240V AC, 50-60 Hertz Fuse 2A 125V Power Consumption 110W .38A Inrush, 1.70A Max. Operating Power Factor: .63 Light Source COB 25x 3W 700ma, 50,000 hours. Optical Beam Angle 55 degrees Luminous Intensity 5,600 Lux @ 1m 2,000 Lux @ 2m Thermal Max. Operating Temp.
This page intentionally left blank. Page 19 CobZilla™ Bright White 5X5 Matrix Manual Rev.
Enjoy your product! Our sincerest thanks for your purchase! --The team @ Blizzard Lighting