805 BLOOMFIELD INDUSTRIES 2 ERIK CIRCLE, P. O. Box 280 Verdi, NV 89439 Customer Service (775) 345-0444 Ext.502 fax: (775) 345-0569 www.wellsbloomfield.com ® SDS-5SB Satellite Docking Station Shown with optional drip tray part no. 3905 OWNERS MANUAL Includes OPERATING INSTRUCTIONS EXPLODED VIEW & PARTS LIST INSTALLATION INSTRUCTIONS CLEANING INSTRUCTIONS SPECIFICATIONS AGENCY APPROVALS p/n 75186 Rev.
WARRANTY STATEMENT The prices charged by Bloomfield Industries for its products are based upon the limitations in this warranty. Seller’s obligation under this warranty is limited to repair of defects without charge by a Bloomfield Industries Authorized Service Agency or one of its sub-agencies. This service will be provided on customer’s premises for non-portable models.
TABLE OF CONTENTS WARRANTY STATEMENT xi Features & Operating Controls General Information & Precautions Specifications (General Layout Data) Installation Instructions Operating instructions Cleaning Instructions Wiring Diagram Exploded View & Parts List Ordering Information / Service Procedure 2 4 5 6 8 9 10 11 12 INTRODUCTION Thank You for purchasing this Bloomfield Industries Satellite Docking Station.
FEATURES AND OPERATING CONTROLS DOCKING STATION POWER CORD OPTIONAL SATELLITE (in place) INDICATOR LIGHT CONNECTOR ADJUSTABLE LEGS DRIP TRAY (optional) OPTIONAL SATELLITE HANDLES CONNECTOR Fig 1.
FEATURES AND OPERATING CONTROLS (continued) Docking Station Adjustable Legs Allows brewer to be leveled. Also allow clearance for cleaning underneath brewer. Connector Connects to satellite. Allows satellite heater to be energized. Allows brewer to sense that a satellite is in place. Indicator Light Glows when a satellite is properly installed at that station. Nameplate (on back - not shown) Lists manufacturer, model and serial number. Also lists voltage and wattage rating of brewer.
GENERAL INFORMATION AND PRECAUTIONS WARNING: Electric Shock hazard All servicing requiring access to non-insulated electrical components must be performed by a factory authorized technician. DO NOT open any access panel which requires the use of tools. Failure to follow this warning can result in severe electrical shock. This appliance is intended for use in commercial establishments only.
SPECIFICATIONS GENERAL LAYOUT DATA BLOOMFIELD SATELLITE DOCKING STATION MODEL: SDS-5SB E9253 STD 4 E9253 LINE CORD 16 1/16 408 MM 17 9/16 446 MM OPTIONAL DRIP TRAYS 46 3/4 1188 MM OPTIONAL SATELLITES 8 11/16 221 MM 22 7/32 564 MM 5 3/8 137 MM 6 7/16 164 MM 11 7/8 302 MM 16 3/32 409 MM ELECTRICAL SPECIFICATIONS MODEL WATTS SDS-5SB 225 (with five Satellites) AMPS VOLTS 2.
INSTALLATION CAUTION: DO NOT connect or energize this appliance until all Installation Instructions are read and followed. Damage to the dispenser will occur if these instructions are not followed. WARNING: All installation procedures must be performed by a qualified technician with full knowledge of all applicable electrical and plumbing codes. Failure could result in property damage and personal injury.
INSTALLATION (continued) ELECTRICAL INSTALLATION INSTRUCTIONS This unit requires a power source capable of supplying 120 Volts AC, 50/60 Hz, 3-Wire 15 Amp. The unit is shipped from the factory with a power cord. The power cord must be plugged into a properly grounded NEMA 5-15P receptacle. INITIAL SET-UP INSTRUCTIONS Remove all satellites from the docking station. Plug power cord into an appropriate 120 volt receptacle. Install a satellite in docking position #1.
OPERATING INSTRUCTIONS GETTING STARTED Check the docking station: Check that the brewer is clean and the drip tray (if used) is empty. Check that the docking station is plugged into an appropriate receptacle. DAILY START-UP IMPORTANT: HANDLES Install satellites in any or all of the five positions of the docking station.
CLEANING INSTRUCTIONS PROCEDURE: Clean Satellite Docking Station PRECAUTIONS: Unplug docking station Remove satellites FREQUENCY: Daily TOOLS: Mild Detergent, Clean Soft Cloth or Sponge 1. Unplug docking station from electrical power. 2. Remove satellites. 3. Remove and drain the drip tray. Rinse in a sink under warm running water. Allow to air dry, then reinstall on brewer. 4. Wipe exterior of docking station with a soft clean cloth or sponge moistened with clean water. 5. Reinstall satellites.
WIRING DIAGRAM WHITE GREEN BLACK BLACK BLACK PILOT LIGHT CONNECTOR #1 #2 #3 #4 #5 1 RED CONNECTOR WIRED ASSY WHITE GREEN BLACK BLACK BLACK PILOT LIGHT CONNECTOR #4 #1 #2 #3 #4 1 RED CONNECTOR WIRED ASSY WHITE GREEN BLACK BLACK BLACK PILOT LIGHT CONNECTOR #3 #1 #2 #3 #4 1 RED CONNECTOR WIRED ASSY WHITE GREEN BLACK BLACK BLACK PILOT LIGHT CONNECTOR #2 #1 #2 #3 #4 1 RED CONNECTOR WIRED ASSY WHITE GREEN BLACK BLACK BLACK 3 CONNECTOR #1 #1 #2 #3 #4 2 1 GROUND RED MODEL: SDS
EXPLODED VIEW & PARTS LIST 5 8 2 15 7 6 12 9 14 13 1 3 4 11 10 75177 WELD ASSY BODY 1 75176 ASSY TOP HOUSING 1 ACCESSORIES (not shown) WELD ASSY BASE 1 SERVICE # WELD ASSY BOTTOM PLATE 1 3901 DRIP TRAY 1 75182 LID 1 3903 DRIP TRAY, SDS-5 1 75181 BACK PANEL 1 6407-15 CORD ASSY 1 35-210 STRAIN RELIEF 1 83105 SWITCH WITH SCREWS 1 83107 FEET, RUBBER, BLACK 4 83098 LEG, 4" BLACK, W/FLANGED FOOT 4 DESCRIPTION QTY.
ORDERING / SERVICE PROCEDURES Use only genuine Bloomfield replacement parts in this brewer. The use of replacement parts other than those supplied by Bloomfield voids the warranty. Parts are available at your Authorized Bloomfield Service Agency. Locations and phone numbers are listed in the Agency Listing provided with all equipment. To find the parts required to restore proper operation to the coffee brewer, proceed as follows: 1.
PARTS AND SERVICE For best results, use only genuine Bloomfield paper filters in this brewer. IMPORTANT: Use only factory authorized service parts. For factory authorized service, or to order factory authorized replacement parts, contact your Authorized Bloomfield Distributor, or call: Bloomfield Industries Co. 2 Erik Circle P. O. Box 280 Verdi, NV 89439 phone: (775) 345-0444 fax: (Service Parts Dept.
Bloomfield Industries, Inc. PO. Box 280 Verdi, NV. 89439 Ph. 775/345-0444 Fax 888/492-2783 Service: 1-888/492-2783 website: www.wellsbloomfield.com Bloomfield Industries Canada Limited 5850 Keaton Cresent Mississauga, Ontario, Canada L5R 3K2 Ph. 905/507-1700 Fax 905/507-1777 Toll Free 1-877-507-1700 website: www.bloomcan.com e-mail: brewinfo@bloomcan.
