Instructions / Assembly

ManualsBrandsBond Manufacturing ManualsOutdoorsGalleon 60 in. x 20 in. Rectangular Propane Fire Pit

Design certified under ANSI Z21.97 • CSA

2.41-(2012)

Requirements for Outdoor Gas

Fireplaces

WARNING

For Outdoor Use Only! Use Propane Gas Only !

Propane cylinders sold

separately.

WARNING

Improper

installation,

adjustment, alteration, service

or maintenance can

cause

injury or property damage.

Read the owner's

manual

thoroughly before installing

or servicing this equipment.

the information in this

manual is not followed exactly,

a fire

or explosion

may result causing property

damage,

personal injury

or loss of

life.

WARNING

The propane cylinder must be disconnected

when

this fire table is not

use.

DANGER

If you smell

gas:

1. Shut off gas to the

appliance.

2. Extinguish any open

flame.

3. If odor continues, keep away from the appliance

and

immediately call your gas supplier or fire

department.

WARNING

This fire table must be attended at all

times!

WARNING

An LP-cylinder not connected for use shall not be

stored

in the vicinity of this or any other

appliance.

READ BEFORE

USE!

OWNER'S MANUAL

Factory No.: BH70 0 1-4 Item No.:66696

WARNING

USE PROPANE GAS

ONLY!

-Do not store or use gasoline or

other

flammable vapors in the vicinity of this or any

other

appliance.

- Service must be performed by a qualified installer,

service

agency

the

gas

supplier.

WARNING

For use with cylinders marked PROPANE only. DO

NOT

connect to a remote gas

supply.

If the fire table is stored indoors, detach and leave

propane

cylinder

outdoors.

Summary of content (8 pages)

PAGE 1
OWNER'S MANUAL READ BEFORE USE! Factory No.: BH70 0 1-4 Item No.:66696 WARNING For Outdoor Use Only! Use Propane Gas Only ! Propane cylinders sold separately. WARNING Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage. Read the owner's manual thoroughly before installing or servicing this equipment. If the information in this manual is not followed exactly, a fire or explosion may result causing property damage, personal injury or loss of life.
PAGE 2
DANGER Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual may result in serious bodily injury or death, or in a fire or an explosion causing damage to property. WARNING *Do not use this fire table for cooking. *Remove the PVC cover from the fire table before opening the appliance. *Do not lay the PVC cover over the fire table until it is turned off and completely cooled down. *Do not burn any other materials than are supplied with and intended for use in this fire table.
PAGE 3
FOR PROPANE GAS UNITS *The gas pressure regulator provided with the propane fire table must be used. *Do not attempt to disconnect the gas regulator or any gas fitting while your fire table is in operation. *A dented or rusty propane cylinder may be hazardous and should be checked by your gas supplier prior to use. *Do not use a propane cylinder with a damaged valve and any other worn out parts. *Transit and store the empty gas cylinders carefully and properly.
PAGE 4
Inspect the hose before each use of the appliance. If the hose shows signs of cracks, abrasions, cuts or damage of any kind, do not operate the appliance. Fix or replace the hose as required before using the appliance. For assistance with repair or replacement of the hose, call Bond Manufacturing at 1-866-771-2663. Use only replacement parts from the manufacturer. WARNING ! * Do not light or use gas unit if pumice stone are wet.
PAGE 5
13 ITEM SPECIFICATION QTY 1 Body 1 2 Tank seat 1 3 Burner 1 4 Fire bowl 1 5 Ignition pin 1 6 Thermocouple 1 7 Corrugated pipe 1 8 Injector Gas valve 1 9 ITEM 15 16 17 18 19 1 10 Control knob 1 11 12 Pulse ignition 1 Regulator 1 13 Guard 1 14 Grounding wire 1 5 SPECIFICATION M6X8 screws M6 nuts Ø12 washer Adjustable foot Pilot QTY 10 10 10 4 1
PAGE 6
ASSEMBLY INSTRUCTIONS * Please keep these owner's manual for future reference. *If you have opened the carton and removed all packages, please disregard the STEP 1 and 2. See the STEP 3 directly. STEP 1. (1) Open the carton and turn it upside down, make sure the 4 pieces of the cartons open up as below in Figure A. (2) Lift off the carton carefully and be wary of the accessories inside falling away. Take away the box containing pumice stones.
PAGE 7
See WARNING and Figures: WARNING This screen must be clear and free of obstructions at all times to insure proper operation. Perform leak test in a well-ventilated area outside and where no source of spark can occur. Remove battery from igniter. Open tank valve fully (counter-clockwise). Turn the on/off valve at the unit to the “OFF” position to pressurize the hose assembly. Use a soapy water solution to check all the connections f or leaks before attempting to light the appliance.
PAGE 8
TO EXTINGUISH A. Turn Control Knob clockwise to Pilot. (Normally, burner will make a slight popping sound when extinguished.) Burner will extinguish but Pilot burner will remain ON. B. To extinguish Pilot, depress Control Knob and continue to turn it clockwise to OFF. C. Turn the cylinder valve on the gas tank clockwise to close the gas supply if not in use for a long time. ROUTINE CARE • Keep your fire table free and clear from combustible materials.