Power Xpress™ Bollard Charge Station User Guide
Power Xpress™ Bollard Charge Station User Guide Technical Support 1-877-805-EVSE (3873) Copyright © 2012 Service Solutions U.S. LLC All rights reserved. The information, specifications, and illustrations in this guide are based on the latest information available at the time of printing. Service Solutions U.S. LLC reserves the right to make changes at any time, without notice. 2 EL-50600-17 Rev.
Power Xpress™ Bollard Charge Station User Guide TABLE OF CONTENTS PRODUCT SAFETY..........................................................................................................4 PRODUCT REGULATORY INFORMATION...........................................................................5 Environmental Considerations....................................................................................5 Product Specification..................................................................................
Power Xpress™ Bollard Charge Station User Guide PRODUCT SAFETY SAVE THESE IMPORTANT SAFETY INSTRUCTIONS. This manual contains important instructions that must be followed during use of the electric vehicle supply equipment (EVSE). Read all instructions before using the EVSE. WARNING: Do not operate the EVSE with a visibly damaged cable or if the enclosure or connector is broken, open, cracked, or shows any other signs of damage. If your EVSE is damaged, please contact SPX immediately.
Power Xpress™ Bollard Charge Station User Guide PRODUCT REGULATORY INFORMATION Environmental Considerations The EVSE should be recycled according to local laws and regulations at the end of service life. Product Specification All EVSE specifications and descriptions are accurate at the time of printing. Products are constantly updated and improved, and SPX reserves the right to make changes at any time, without notice and or obligation.
Power Xpress™ Bollard Charge Station User Guide FEATURES AND SPECIFICATIONS Product Features The EVSE includes ground-fault protection, automatic reset upon power grid loss, ground assurance monitoring, and self-testing capabilities. Manual resetting of the EVSE is not necessary. Exception: European models require manual resetting after ground-fault condition. Ground-Fault Protection The EVSE continually provides a safe power supply to the vehicle.
Power Xpress™ Bollard Charge Station User Guide Product Specifications Voltage and Wiring (120V above ground) • 240VAC single-phase: L1, L2, and safety ground. • 208VAC 3-phase, wye-connected: Any 2 phases and safety ground. • 240VAC 3-phase, delta-connected: with center tap on one leg, use only the two phases on either side of the center tap. The two phases must both measure 120V AC to ground. Do not use the third leg (208V “stinger”).
Power Xpress™ Bollard Charge Station User Guide Agency Approvals: Standard Compliances through a National Registered Testing Lab (NRT NRTL) North American Operation • FCC Part 15 Class-B • UL 2594 • UL 2251 • UL 62 • UL 60950-1 • UL 1998 • UL 2231-1 & -2 • CSA C22.2 #60950-1 • CSA C22.2 #107.
Power Xpress™ Bollard Charge Station User Guide Technical Specifications Output Amperage 32A max, model dependent (See output spec. label on side of EVSE) Input Voltage Range 175 VAC–264 VAC Frequency 50/60Hz Ground Fault Trip Level 17.
Power Xpress™ Bollard Charge Station User Guide OPERATING INSTRUCTIONS CAUTION: For use with electric vehicles only. CAUTION: If the unit fails to operate per the operating instructions, do not use the device. Contact an SPX qualified technician for service or repair. CAUTION: Ventilation not required. Do not install unit in or around flammable or combustible materials. CAUTION: If the red STATUS indicator is illuminated, see Troubleshooting section for instructions. 1.
Power Xpress™ Bollard Charge Station User Guide EVSE POWER AND STATUS LED INDICATIONS POWER LED STATUS LED CONDITION (OFF) (OFF) NO SERVICE SUPPLY POWER GREEN SOLID AMBER SOLID EVSE POWERED; VEHICLE COUPLER NOT CONNECTED GREEN SOLID GREEN SOLID WAITING TO CHARGE GREEN SOLID GREEN BLINKING VEHICLE IS CHARGING GREEN SOLID 1 OR 2 RED BLINKS EVERY 2 SECONDS PILOT CHARGING ERROR* GREEN SOLID SOLID RED THEN GREEN BLINK EVERY 2 SECONDS GROUND FAULT DETECTED* GREEN SOLID RED BLINKING GROUND M
Power Xpress™ Bollard Charge Station User Guide TROUBLESHOOTING If there is a charging issue proceed with the following steps. If the issue persists after three attempts call SPX at 1-877-805-EVSE (3873) for assistance. Problem Indicated by LED Status Solution Pilot charging error 1. 2. 3. Ground fault detected 1. 2. 3. 4. 5. Ground monitor interrupted 1. 2. 3. 4. 5. Operation fault 1. 2. 3. 12 Verify supply-side power. The green POWER LED should be on.
Power Xpress™ Bollard Charge Station User Guide Ground Fault Circuit Interrupt (GFCI) Tripped If the EVSE detects a ground fault, power will be interrupted and the STATUS LED will illuminate (red flash with intermittent green). The EVSE will attempt to reset automatically and re-attempt charging (see note below on European models). If the fault condition persists after an initial automatic attempt, per the code, the EVSE waits 15 minutes before a second attempt is made.
Power Xpress™ Bollard Charge Station User Guide MAINTENANCE WARNING: Do not attempt to service the EVSE. The EVSE has no user-serviceable components. If the unit is not operating properly, contact SPX at 1-877-805-EVSE (3873) for assistance. The EVSE requires no scheduled maintenance, only periodic cleaning. Always be sure to return the charging cable and coupler to its proper storage area to avoid potential damage to the unit and to prevent potential trip hazards.
Power Xpress™ Bollard Charge Station User Guide LIMITED WARRANTY THIS WARRANTY IS EXPRESSLY LIMITED TO THE ORIGINAL PURCHASER OF SERVICE SOLUTIONS U.S. LLC EVSE PRODUCT. • Power Xpress Bollard is warranted against defects in materials and workmanship for one year from the date of installation. • EVSE Cables and Connectors are warranted against defects in materials and workmanship for 90 days from the date of delivery.
EL-50600-17 Rev. A © Service Solutions U.S.
