Owner`s manual

29843-5-1012 Page 37
MAINTENANCE INSTRUCTIONS
MAINTENANCE
Maintenancefrequencymustbedeterminedindividuallyforeach
application.Someconsiderationsare:
• Exposuretowater,dirt,chemicalsandheatcandamagethe
gascontrolandshutdownthecontrolsystem.
• Cycling frequency.Appliances that may cycle 20,000 times
annuallyshouldbecheckedmonthly.
• Intermittentuse.Appliancesthatareusedseasonallyshould
becheckedbeforeshutdownandagainbeforethenextuse.
• Dusty,wetorcorrosiveenvironment.Becausetheseenviron-
mentscancausethegascontroltodeterioratemorerapidly,
thesystemshouldbecheckedmoreoften.
• Anycontrolshouldbereplacedifitdoesnotperformproperly
oncheckoutorservice.Inaddition,replaceanymoduleifitis
wetorlookslikeithasbeenwet.
SERVICE
Donotdisassemblethegas control; it contains non-replaceable
components. Attempted disassembly or repair can damage the
control.
Exactlyfollowthewarningsandthelightinginstructions.
1. Before lighting, smell around the appliance area for gas. If
theapplianceusesLP(bottled)gas,besuretosmellnextto
theoorbecauseLPgasisheavierthanair.Ifyousmellgas,
immediatelyshutoffthemanualvalveinthegaspipingtothe
applianceoronLPatthetank.Donottrytolightanyappli-
ance. Do not touch any electrical switch or use the phone.
Leavethebuildingandcallyourgassupplier.Ifyourgassup-
pliercannotbereached,calltheredepartment.
2. Thegascontrolmustbereplacedifithasbeenoodedwith
water.Callaqualiedservicetechnician.
3. Thegascontrolisasafetydevice.Itmustbereplacedincase
ofanyphysicaldamagesuchasbentterminals,missingparts,
strippedthreads,orevidenceofexposuretoexcessiveheat.
Followtheoperatinginstructionsprovidedbythemanufacturerof
yourheatingappliance.
OPERATING INSTRUCTIONS
POWER SUPPLY SYSTEM
The Gas Control system is powered by a standard 110 voltAC
througha6.0voltDCadaptor.TheACadaptorisconnectedtothe
ControlModulewithtwo1/4in.(6.35mm)femaleterminals.
ThiscontrolsystemalsoincludesaBatteryBack-uppackthatal-
lows the Gas Control system only to operate in the event of a
poweroutage.
NOTE:TheAccentLightand/orBlowerfeatureswillnot operate
duringapoweroutage.
NOTE:AllBatteriesshouldbereplacedatleastonceeachyear,
preferablyatthebeginningoftheheatingseason.
CAUTION:Fireorexplosionhazard.Cancausepropertydamage,
severinjuryordeath.
Donotattempttotakeapartthegascontrolortocleanit.Improper
assemblyandcleaningcancauseunreliableoperation.
ThiscontrolsystemalsoincludesaBatteryBack-uppackthatal-
lows the Gas Control system only to operate in the event of a
poweroutage.
NOTE:TheAccentLightand/orBlowerfeatureswillnot operate
duringapoweroutage.
NOTE:AllBatteriesshouldbereplacedatleastonceeachyear,
preferablyatthebeginningoftheheatingseason.
CAUTION:Fireorexplosionhazard.Cancausepropertydamage,
severinjuryordeath.
Donotattempttotakeapartthegascontrolortocleanit.Improper
assemblyandcleaningcancauseunreliableoperation.
REMOTE CONTROL FEATURE:TheControlModulehasabuilt
inremote control receiverwhich allows theuser to program the
handheldremotetransmitter.
1. ThereisaswitchlocatedontherightsideoftheControlMod-
ulethatreadsREMOTE/OFF.
2. Whentheremote/offswitchisintheOFFpositiontheappli-
ancewilloperatefromanappliancemountedrockerswitchor
optionalwallswitchconnectedtothetwo(2)BROWNwires
ontheControlModule.
3. When the remote/off switch is in the REMOTE position the
appliancewilloperatefromtheRemoteControltransmitter.
TheControlModulemustbeprogrammedtotheRemoteControl.
1. To program, located the learn button on the left side of the
Control Module Note: Press and release the learn button.
There will be a beep sound from the Control Module, then
press any key on the remote transmitter. Once the internal
receiveracceptsthetransmittercodetherewillbeaseriesof
conrmingbeeps.
2. Theremotesystemisreadyforuse.Pleaserefertothesepa-
rateMulti-functionRemoteControlInstructionmanualforpro-
gramminganddetailedoperationalinformation.
REMOTE CONTROL OPERATION
1. TheMODEbuttontogglesbetweenON,THERMOandOFF.
2. TheFLAMEMAINbuttonwillcontrolthelevelofthe burner
withlevel7beingthelargestameand1beingthesmallest
ame.
3. The LIGHTS button will control the level of intensity of the
medialightontheDVLLwithlevel6beingthebrightestand
level0beingoff.
4. TheFANbuttonwillcontrolthelevelofthefanspeedafterthe
rst12minutesofoperationwithlevel6beingthehighestand
0beingoff.