Submittal
Standard
Features
Heater Data
Factory
Mounted
Options
MAGNATHERM
®
Date:
Project #:
Engineer:
Prepared By:
Bid Date:
Project Name:
Location:
Contractor:
Volume Water Heater
MGV Volume Water Heater
Indoor / Outdoor, Sizes 1600 - 4000
HLW
Submittal Data
MGV 5:1 WITH LAARS LINC CONTROL
Standard
• ASME "HLW" stamp •
Electronic PID modulating • "Knock-down" feature: Removable
Features
• 160 psi maximum working pressure control with large touchscreen top section for easy handling
• Meets NSF/ANSI-372 Low Lead and color display and installation
Content certification
• Multiple independent heat demands • High and low gas pressure switches
•
Certified for Category IV vent • Controller cascades with up to • Vent temperature cutoff
• Indoor / Outdoor eight MagnaTherm heaters
• Normally open alarm contact
• Low NOx system exceeds the with Laars Linc controls
• Air filter
most stringent regulations for air
• Accepts 4-20ma or 0-10VDC • Built-in condensate trap
quality - 9ppm NOx external modulation or external
• Water flow switch
• High condensing efficiency set point control • Temperature & pressure gauge
•
Modulation down to 20% of full fire • Modbus RTU & BACnet MSTP •
Low water cutoff
(5:1 turndown) on board
• 125 psi (861kPa) ASME rated
• Sophisticated gas/air valve • Domestic water pump control with pressure relief valve
allows for constant control time delay
• Groove lock fittings
of modulation
• Sensor for DHW tank (optional flange adapter)
• Sealed combustion chamber •
Horizontal or vertical direct vent
•
Burner site glass
• Pre-mix stainless steel burner
•
Vent and air pipe lengths of up to • 10-Year limited warranty
• Stainless steel heat exchanger 100 equivalent feet (each)
with welded construction
Heater
Number of Units Voltage
Data 120V, single ph (1600-2000) 208V, three ph (2000-4000)
208V, single ph (1600-2000) 480V, three ph (2000-4000)
Fuel 220/240V, single ph (1600-2000) 600V, three ph (2000-4000)
Natural
Propane
Factory ASME CSD-1 Additional auto & manual 125 psi pressure relief valve (std)
Mounted ASME "H" Stamp (instead of reset high limit switches 30 psi pressure relief valve
Options standard "HLW" Stamp) Alarm bell with silence switch 50 psi pressure relief valve
BACnet IP gateway Groove lock to flange connections 60 psi pressure relief valve
LonWorks gateway 75 psi pressure relief valve
150 psi pressure relief valve
Accessories Gateway for BACnet IP Screen for vertical stainless Screen/adapter for vertical or
for Field Gateway for LonWorks steel vent horizontal PCV ducted air
Mounting Condensate neutralizer Screen for horizontal CPVC vent Screen for horizontal galvanized
Condensate neutralizer with pump Screen for vertical CPVC vent or vertical ducted air
Vent terminal for outdoor unit Screen for horizontal Screen for horizontal
Screen for outdoor unit air polypropylene vent polypropylene ducted air
Vent terminal for horizontal Screen for vertical Screen for vertical
stainless steel vent polypropylene vent polypropylene ducted air
MGV 5:1 WITH LAARS LINC CONTROL
Standard • ASME "HLW" stamp •
Electronic PID modulating • "Knock-down" feature: Removable
Features • 160 psi maximum working pressure control with large touchscreen top section for easy handling
• Meets NSF/ANSI-372 Low Lead and color display and installation
Content certification
• Multiple independent heat demands • High and low gas pressure switches
• Certified for Category IV vent • Controller cascades with up to • Vent temperature cutoff
• Indoor / Outdoor eight MagnaTherm heaters
• Normally open alarm contact
• Low NOx system exceeds the with Laars Linc controls
• Air filter
most stringent regulations for air
• Accepts 4-20ma or 0-10VDC • Built-in condensate trap
quality - 9ppm NOx external modulation or external
• Water flow switch
• High condensing efficiency set point control • Temperature & pressure gauge
• Modulation down to 20% of full fire • Modbus RTU & BACnet MSTP •
Low water cutoff
(5:1 turndown) on board
• 125 psi (861kPa) ASME rated
• Sophisticated gas/air valve • Domestic water pump control with pressure relief valve
allows for constant control time delay
• Groove lock fittings
of modulation
• Sensor for DHW tank (optional flange adapter)
• Sealed combustion chamber • Horizontal or vertical direct vent • Burner site glass
• Pre-mix stainless steel burner
•
Vent and air pipe lengths of up to • 10-Year limited warranty
• Stainless steel heat exchanger 100 equivalent feet (each)
with welded construction
Heater
Number of Units Voltage
Data 120V, single ph (1600-2000) 208V, three ph (2000-4000)
208V, single ph (1600-2000) 480V, three ph (2000-4000)
Fuel 220/240V, single ph (1600-2000) 600V, three ph (2000-4000)
Natural
Propane
Factory
ASME CSD-1 Additional auto & manual 125 psi pressure relief valve (std)
Mounted
ASME "H" Stamp (instead of reset high limit switches 30 psi pressure relief valve
Options
standard "HLW" Stamp) Alarm bell with silence switch 50 psi pressure relief valve
BACnet IP gateway Groove lock to flange connections 60 psi pressure relief valve
LonWorks gateway 75 psi pressure relief valve
150 psi pressure relief valve
Accessories Gateway for BACnet IP Screen for vertical stainless Screen/adapter for vertical or
for Field Gateway for LonWorks steel vent horizontal PCV ducted air
Mounting Condensate neutralizer Screen for horizontal CPVC vent Screen for horizontal galvanized
Condensate neutralizer with pump Screen for vertical CPVC vent or vertical ducted air
Vent terminal for outdoor unit Screen for horizontal Screen for horizontal
Screen for outdoor unit air polypropylene vent polypropylene ducted air
Vent terminal for horizontal Screen for vertical Screen for vertical
stainless steel vent polypropylene vent polypropylene ducted air
MGV 5:1 WITH LAARS LINC CONTROL
Standard • ASME "HLW" stamp •
Electronic PID modulating • "Knock-down" feature: Removable
Features • 160 psi maximum working pressure control with large touchscreen top section for easy handling
• Meets NSF/ANSI-372 Low Lead and color display and installation
Content certification
• Multiple independent heat demands • High and low gas pressure switches
• Certified for Category IV vent • Controller cascades with up to • Vent temperature cutoff
• Indoor / Outdoor eight MagnaTherm heaters
• Normally open alarm contact
• Low NOx system exceeds the with Laars Linc controls
• Air filter
most stringent regulations for air
• Accepts 4-20ma or 0-10VDC • Built-in condensate trap
quality - 9ppm NOx external modulation or external
• Water flow switch
• High condensing efficiency set point control • Temperature & pressure gauge
•
Modulation down to 20% of full fire • Modbus RTU & BACnet MSTP •
Low water cutoff
(5:1 turndown) on board
• 125 psi (861kPa) ASME rated
• Sophisticated gas/air valve • Domestic water pump control with pressure relief valve
allows for constant control time delay
• Groove lock fittings
of modulation
• Sensor for DHW tank (optional flange adapter)
• Sealed combustion chamber •
Horizontal or vertical direct vent
•
Burner site glass
• Pre-mix stainless steel burner
•
Vent and air pipe lengths of up to • 10-Year limited warranty
• Stainless steel heat exchanger 100 equivalent feet (each)
with welded construction
Heater
Number of Units
Voltage
Data
120V, single ph (1600-2000) 208V, three ph (2000-4000)
208V, single ph (1600-2000) 480V, three ph (2000-4000)
Fuel
220/240V, single ph (1600-2000) 600V, three ph (2000-4000)
Natural
Propane
Factory ASME CSD-1 Additional auto & manual 125 psi pressure relief valve (std)
Mounted ASME "H" Stamp (instead of reset high limit switches 30 psi pressure relief valve
Options standard "HLW" Stamp) Alarm bell with silence switch 50 psi pressure relief valve
BACnet IP gateway Groove lock to flange connections 60 psi pressure relief valve
LonWorks gateway 75 psi pressure relief valve
150 psi pressure relief valve
Accessories Gateway for BACnet IP Screen for vertical stainless Screen/adapter for vertical or
for Field Gateway for LonWorks steel vent horizontal PCV ducted air
Mounting Condensate neutralizer Screen for horizontal CPVC vent Screen for horizontal galvanized
Condensate neutralizer with pump Screen for vertical CPVC vent or vertical ducted air
Vent terminal for outdoor unit Screen for horizontal Screen for horizontal
Screen for outdoor unit air polypropylene vent polypropylene ducted air
Vent terminal for horizontal Screen for vertical Screen for vertical
stainless steel vent polypropylene vent polypropylene ducted air
Brute MagnaTech
®
• Controller cascades with up to
eight (total) MagnaTech units, if
equipped with the same controller
Submittal Data
BMGV
MAGNATECH