Submittal

Standard
Features
Heater Data
Factory
Mounted
Options
MAGNATHERM
®
HTD
Volume Water Heater
MGV Volume Water Heater
Indoor / Outdoor, Sizes 1600 - 4000
HLW
Submittal Data
MGV 2165
Standard
• ASME "HLW" stamp •
Pre-mix stainless steel burner • Vent and air pipe lengths of up to
Features
• 160 psi maximum working pressure • Stainless steel heat exchanger 100 equivalent feet (each)
• Meets NSF/ANSI-372 Low Lead with welded construction • "Knock-down" feature: Removable
Content certification
• Electronic PID modulating top section for easy handling
• Certified for Category II and control with large touchscreen and installation
Category IV vent systems and color display
• High and low gas pressure switches
• Indoor / Outdoor • Multiple independent heat demands
• Vent temperature cutoff
• Low NOx system exceeds the • Controller cascades with up to • Normally open alarm contact
most stringent regulations for air eight MagnaTherm heaters
• Air filter
quality - 9ppm NOx equipped with Laars Linc control
• Built-in condensate trap
• High condensing efficiency • Accepts 4-20ma or 0-10VDC •
Water flow switch
• Modulation down to 5% of full fire external modulation or external • Temperature & pressure gauge
(20:1 turndown) set point control
• Low water cutoff
• Sophisticated gas/air valve • Modbus RTU & BACnet MSTP • 125 psi (861kPa) ASME rated
allows for constant control on board pressure relief valve
of modulation
•
Domestic water pump control with • Groove lock fittings
•
Tru Trac
TM
real-time O
2
sensing time delay (optional flange adapter)
maintains efficiency throughout • Sensor for DHW tank • Burner site glass
the modulation range
• Horizontal or vertical direct vent • 10-Year limited warranty
•
Sealed combustion chamber
Heater Number of Units Voltage
Data 120V, single ph (1600-2000) 208V, three ph (2000-4000)
208V, single ph (1600-2000) 480V, three ph (2000-4000)
Fuel 220/240V, single ph (1600-2000) 600V, three ph (2000-4000)
Natural
Factory ASME CSD-1 Additional auto & manual 125 psi pressure relief valve (std)
Mounted ASME "H" Stamp (instead of reset high limit switches 30 psi pressure relief valve
Options standard "HLW" Stamp) Alarm bell with silence switch 50 psi pressure relief valve
BACnet IP gateway Groove lock to flange connections 60 psi pressure relief valve
LonWorks gateway 75 psi pressure relief valve
150 psi pressure relief valve
Accessories Gateway for BACnet IP Screen for vertical stainless Screen/adapter for vertical or
for Field Gateway for LonWorks steel vent horizontal PCV ducted air
Mounting Condensate neutralizer Screen for horizontal CPVC vent Screen for horizontal galvanized
Condensate neutralizer with pump Screen for vertical CPVC vent or vertical ducted air
Vent terminal for outdoor unit Screen for horizontal Screen for horizontal
Screen for outdoor unit air polypropylene vent polypropylene ducted air
Vent terminal for horizontal Screen for vertical Screen for vertical
stainless steel vent polypropylene vent polypropylene ducted air
MGV 2165
Standard • ASME "HLW" stamp •
Pre-mix stainless steel burner • Vent and air pipe lengths of up to
Features • 160 psi maximum working pressure • Stainless steel heat exchanger 100 equivalent feet (each)
• Meets NSF/ANSI-372 Low Lead with welded construction • "Knock-down" feature: Removable
Content certification
• Electronic PID modulating top section for easy handling
• Certified for Category II and control with large touchscreen and installation
Category IV vent systems and color display
• High and low gas pressure switches
• Indoor / Outdoor • Multiple independent heat demands
• Vent temperature cutoff
• Low NOx system exceeds the • Controller cascades with up to • Normally open alarm contact
most stringent regulations for air eight MagnaTherm heaters
• Air filter
quality - 9ppm NOx equipped with Laars Linc control
• Built-in condensate trap
• High condensing efficiency • Accepts 4-20ma or 0-10VDC •
Water flow switch
• Modulation down to 5% of full fire external modulation or external • Temperature & pressure gauge
(20:1 turndown) set point control
• Low water cutoff
• Sophisticated gas/air valve • Modbus RTU & BACnet MSTP • 125 psi (861kPa) ASME rated
allows for constant control on board pressure relief valve
of modulation
• Domestic water pump control with • Groove lock fittings
•
Tru Trac
TM
real-time O
2
sensing time delay (optional flange adapter)
maintains efficiency throughout • Sensor for DHW tank • Burner site glass
the modulation range
• Horizontal or vertical direct vent • 10-Year limited warranty
•
Sealed combustion chamber
Heater Number of Units Voltage
Data
120V, single ph (1600-2000) 208V, three ph (2000-4000)
208V, single ph (1600-2000) 480V, three ph (2000-4000)
Fuel 220/240V, single ph (1600-2000) 600V, three ph (2000-4000)
Natural
Factory
ASME CSD-1 Additional auto & manual 125 psi pressure relief valve (std)
Mounted ASME "H" Stamp (instead of reset high limit switches 30 psi pressure relief valve
Options standard "HLW" Stamp) Alarm bell with silence switch 50 psi pressure relief valve
BACnet IP gateway Groove lock to flange connections 60 psi pressure relief valve
LonWorks gateway 75 psi pressure relief valve
150 psi pressure relief valve
Accessories Gateway for BACnet IP Screen for vertical stainless Screen/adapter for vertical or
for Field Gateway for LonWorks steel vent horizontal PCV ducted air
Mounting Condensate neutralizer Screen for horizontal CPVC vent Screen for horizontal galvanized
Condensate neutralizer with pump Screen for vertical CPVC vent or vertical ducted air
Vent terminal for outdoor unit Screen for horizontal Screen for horizontal
Screen for outdoor unit air polypropylene vent polypropylene ducted air
Vent terminal for horizontal Screen for vertical Screen for vertical
stainless steel vent polypropylene vent polypropylene ducted air
MGV 2165
Standard • ASME "HLW" stamp • Pre-mix stainless steel burner • Vent and air pipe lengths of up to
Features • 160 psi maximum working pressure • Stainless steel heat exchanger 100 equivalent feet (each)
• Meets NSF/ANSI-372 Low Lead with welded construction • "Knock-down" feature: Removable
Content certification
• Electronic PID modulating top section for easy handling
• Certified for Category II and control with large touchscreen and installation
Category IV vent systems and color display
• High and low gas pressure switches
• Indoor / Outdoor • Multiple independent heat demands
• Vent temperature cutoff
• Low NOx system exceeds the • Controller cascades with up to • Normally open alarm contact
most stringent regulations for air eight MagnaTherm heaters
• Air filter
quality - 9ppm NOx equipped with Laars Linc control
• Built-in condensate trap
• High condensing efficiency • Accepts 4-20ma or 0-10VDC •
Water flow switch
• Modulation down to 5% of full fire external modulation or external • Temperature & pressure gauge
(20:1 turndown) set point control
• Low water cutoff
• Sophisticated gas/air valve • Modbus RTU & BACnet MSTP • 125 psi (861kPa) ASME rated
allows for constant control on board pressure relief valve
of modulation
•
Domestic water pump control with • Groove lock fittings
•
Tru Trac
TM
real-time O
2
sensing time delay (optional flange adapter)
maintains efficiency throughout • Sensor for DHW tank • Burner site glass
the modulation range
• Horizontal or vertical direct vent • 10-Year limited warranty
•
Sealed combustion chamber
Heater Number of Units Voltage
Data 120V, single ph (1600-2000) 208V, three ph (2000-4000)
208V, single ph (1600-2000) 480V, three ph (2000-4000)
Fuel 220/240V, single ph (1600-2000) 600V, three ph (2000-4000)
Natural
Factory
ASME CSD-1 Additional auto & manual 125 psi pressure relief valve (std)
Mounted
ASME "H" Stamp (instead of reset high limit switches 30 psi pressure relief valve
Options
standard "HLW" Stamp) Alarm bell with silence switch 50 psi pressure relief valve
BACnet IP gateway Groove lock to flange connections 60 psi pressure relief valve
LonWorks gateway 75 psi pressure relief valve
150 psi pressure relief valve
Accessories Gateway for BACnet IP Screen for vertical stainless Screen/adapter for vertical or
for Field Gateway for LonWorks steel vent horizontal PCV ducted air
Mounting Condensate neutralizer Screen for horizontal CPVC vent Screen for horizontal galvanized
Condensate neutralizer with pump Screen for vertical CPVC vent or vertical ducted air
Vent terminal for outdoor unit Screen for horizontal Screen for horizontal
Screen for outdoor unit air polypropylene vent polypropylene ducted air
Vent terminal for horizontal Screen for vertical Screen for vertical
stainless steel vent polypropylene vent polypropylene ducted air
Date:
Project #:
Engineer:
Prepared By:
Bid Date:
Project Name:
Location:
Contractor:
Brute MagnaTech
®
HTD
• Controller cascades with up to eight
MagnaTech units, if equipped with
the same controller
• Real-Time O
2
sensing maintains
e󰀩ciency throughout the
modulation range
Submittal Data
BMGV
MAGNATECH