Submittal

ManualsBrandsBradford White ManualsWater boilerBNTV-600

NEOTHERM

Factory

Mounted

Options

Heater Data

Number of Units: Fuel

Natural

Propane

• Electronic PID modulating control

with large color touchscreen

display

• Password-protected parameters

for installer use

• Test feature allows forced min or

 maxring

• Complete diagnostics for analog

and digital inputs

• Displays holds, alerts and errors

in clear text form

• Dry alarm contacts for ignition

failure

•Highcondensinge󰀩ciency

•Modulationdownto20%offullre

(5:1 turndown)

• Sealed combustion chamber

• Pre-mix stainless steel burner

• Low NOx system exceeds the

most stringent regulations for air

quality - less than 10ppm NOx

Standard

Equipment

• Horizontal or vertical direct vent

• Horizontal vent and air terminals

• Vent and air pipe lengths of up to

100 equivalent feet (each)

• Built-in condensate trap

•Venttemperaturecuto󰀨feature

• Direct spark ignition system

• Sensor for domestic water tank

• 160 psi maximum working

pressure

• Stainless steel heat exchanger

with welded construction

(no gaskets)

• ASME "H" stamp

• Meets NSF/ANSI-372 Low Lead

ContentCertication(NTV)

• 125 psi (861 kPa) ASME rated

pressure relief valve

•Waterowswitch(399-850 only)

• Temperature & pressure gauge

• Drain valve

• Integrated PID temperature and

ignition controls

• Alarm output

• Accepts external 4-20mA (0-10V

with optional convertor) modulation

signal

•On/o󰀨toggleswitch

• Manual reset high limit

• Burner site glass

• Zero clearance to combustible sur-

faces

• Built-in cascade function for up to

eight NeoTherms

• 8 year limited warranty

Volume Water

Heater

NTV Volume Water Heater

Indoor Sizes 150-850

Submittal Data

Pump included

No pump

Date:

Project #:

Engineer:

Prepared By:

Bid Date:

Project Name:

Location:

Contractor:

ASME "HLW" Stamp (285-850 only)

CSD-1

(covers FM & GAP) (500-850 only)

Lowwatercuto󰀨(500-850 only)

High & Low gas pressure

switches (500-850)

Additional auto reset high limit

60 psi pressure relief valve

75 psi pressure relief valve

125 psi pressure relief valve (std)

150 psi pressure relief valve

Bell for ignition failure

Submittal Data

Volume Water

Heater

Brute

BNTV

Brutes.

(BNTV)

■

Summary of content (8 pages)

PAGE 1
N EOTHERM Brute ® ® Date: Volume VolumeWater Water Heater Heater BNTV NTV Volume Water Heater Indoor Sizes 150-850 Standard Equipment • Electronic PID modulating control with large color touchscreen display • Password-protected parameters for installer use • Test feature allows forced min or max firing • Complete diagnostics for analog and digital inputs • Displays holds, alerts and errors in clear text form • Dry alarm contacts for ignition failure • High condensing efficiency • Modu
PAGE 2
Accessories for Field Mounting Sizing Data Clearances Water flow switch (285 only) Low water cutoff 0 - 10V converter for modulation control High & Low gas pressure switches Boiler pump Concentric vent terminal, 2" Concentric vent terminal, 3" Flush-mount terminal, 3" Flush-mount terminal, 4" Input Output Model BTU/h kW BTU/h kW Propane conversion kit Condensate neutralizer kit BACnet gateway LON gateway Common vent kit (150-500, one required for each unit) Gas Conn. Size inches Water Conn.
PAGE 3
For 2152 Heater Size MBH Voltage FLA MCA MOP Electrical Data Heater Circuit 150-500 600-850 120V 1PH 120V 1PH < 4 Amps 5 Amps < 4 Amps 6 Amps 5 Amps 11 Amps FLA = Full Load Amperage MCA = Minimum Circuit Ampacity MOP = Maximum Over-current Protection * Note: For any pump(s) exceeding 7.4 FLA / 120V VAC, an external pump relay / contactor must be used. Units that are purchased with pumps include the contactor if the pump exceeds this limit.
PAGE 4
Dimensional 02'(/6 02'(/6 Data, Sizes $ *$6 ,1/(7150, 199 $ *$6 ,1/(7 % 02'(/6 *$6 ,1/(7 % *This unit is shipped with adapters for the air and vent02'(/6 that accept standard pipe of the proper size and type.
PAGE 5
Dimensional Data, Sizes 285-500 *This unit is shipped with adapters for the air and vent that accept standard pipe of the proper size and type. CLOSET DOOR ALLOWABLE TO 1” FROM UNIT Dimensions shown in inches cm.
PAGE 6
Dimensional Data, Sizes 600-850 *This unit is shipped with adapters for the air and vent that accept standard pipe of the proper size and type. CLOSET DOOR ALLOWABLE TO 1” FROM UNIT Dimensions shown in inches cm. SUGGESTED SERVICE CLEARANCE SEE PAGE 2 Optional pump is shipped loose and is not shown. Optional Pump is mounted in the field.
PAGE 7
Notes:
PAGE 8
Notes: BradfordSystems White Corporation Laars Heating Company reserves the right to change specifications, components, features, or to discontinue products without notice. Customer Service and Product Support: 800.900.9276 • Fax 800.559.1583 Headquarters: 20 Industrial Way, Rochester, NH, USA 03867 • 603.335.6300 • Fax 603.335.3355 200 Lafayette St. 9 Brigden Gate, Halton Hills, Ontario, Canada L7G 0A3 • 905.203.0600 • Fax 905.636.0666 Middleville, MI 49333 www.Laars.com Warranty: (800) 531-2111 www.