Installation Instructions WF2605, WF2608 Terrazzo WF2705, WF2708 Stainless Steel WF2605 Classic Circular 36"/54" Washfountain with Foot Control Table of Contents WF2708 Pre-Installation Information . . . . . . . . . . . . . . . . . 2 Circular Washfountain Dimensions . . . . . . . . . . 3-4 Rough-In Specifications . . . . . . . . . . . . . . . . . . . 5-6 Drain Rough-In Specifications . . . . . . . . . . . . . . . .7 Pedestal Mounting and Assembly . . . . . . . . . . . . .
Classic Circular 36"/54" Washfountain with Foot Control WF2605, WF2608 Terrazzo — WF2705, WF2708 Stainless Steel Installation Instructions Pre-Installation Information Operation Stepping on the foot rail allows the user to activate a valve starting the flow of water.
Classic Circular 36"/54" Washfountain with Foot Control WF2605, WF2608 Terrazzo — WF2705, WF2708 Stainless Steel Installation Instructions Circular Washfountain Dimensions E H D C B A F G Approximate Dimensions in Inches* Material Size A B C D Terrazzo 54 19 29-1/4 39-1/8 47-5/8 Stainless Steel 54 19 28 37-3/8 Terrazzo 36 19 29-1/4 Stainless Steel 36 19 28 E F G H 56 32 36 54 45-7/8 54-1/4 32 36 54 35-5/8 44-1/8 52-1/2 21 25 36 33-7/8 42-3/8 50-3/4 21 25
Classic Circular 36"/54" Washfountain with Foot Control WF2605, WF2608 Terrazzo — WF2705, WF2708 Stainless Steel Installation Instructions Length of Tie Pipe Required for Vent Through Washfountain Column Type Pipe Length 54" Less Soap Dispenser 21-1/2" (546mm) 36" Less Soap Dispenser 18" (457mm) 54" With Soap Dispenser 30" (762mm) 36" With Soap Dispenser 26-1/2" (673mm) 54" Less Soap Dispenser With Towel Dispenser 55-1/2" (1410mm) 36" Less Soap Dispenser With Towel Dispenser 52" (1321mm) 54"
Classic Circular 36"/54" Washfountain with Foot Control WF2605, WF2608 Terrazzo — WF2705, WF2708 Stainless Steel Installation Instructions Rough-In Specifications Type A Off-line vent with supplies from below TOP VIEW 1" NPT supplies through floor: stub up 2-1/2" (64) above floor 7-5/8" 7-5/8" (194) (194) Hot 2-1/2" (64) NOTE: UPC and IPC restrict the vertical distance from the fixture outlet to the trap weir to not more than 24". Check state and local codes for variances.
Classic Circular 36"/54" Washfountain with Foot Control WF2605, WF2608 Terrazzo — WF2705, WF2708 Stainless Steel Installation Instructions Rough-In Specifications ... Continued Type O Off-line vent with supplies from above TOP VIEW 1" NPT supplies from above must reduce to 1/2 nom. copper tube on these centers to pass thru washfountain 7/8" (22.2) Hot 1-1/4" (32) NOTE: UPC and IPC restrict the vertical distance from the fixture outlet to the trap weir to not more than 24".
Classic Circular 36"/54" Washfountain with Foot Control WF2605, WF2608 Terrazzo — WF2705, WF2708 Stainless Steel Installation Instructions Installation Instructions Step 1: Rough-In of Drain & Supplies 1. Rough in supply and drain piping as required for your installation (see pages 5-6 for rough-ins of the optional installations). 2. Assemble the drain to the dimension shown in Figure 1 and Table 1 for bowl size of the Washfountain you are installing.
Classic Circular 36"/54" Washfountain with Foot Control WF2605, WF2608 Terrazzo — WF2705, WF2708 Stainless Steel Installation Instructions Installation Instructions continued . . . Step 2: Assembling the Pedestal 1. 2. 3. 4. Assemble the leg and scuff base panels with the 5/16” carriage bolts and nuts provided (Figure 2). Attach the pedestal frame members with the 5/16” stove bolts and nuts provided (Figures 2 and 3). Add the foot levers and operating cross to the pedestal assembly (Figures 2 and 4).
Installation Instructions Classic Circular 36"/54" Washfountain with Foot Control WF2605, WF2608 Terrazzo — WF2705, WF2708 Stainless Steel Installation Instructions continued . . . Step 3: Bowl and pedestal assembly and mounting IMPORTANT: FOR PROPER DRAINAGE, THE BOWL AND PEDESTAL MUST BE LEVEL WHEN THEY ARE SECURED TO THE FLOOR . WARNING: USE SUITABLE LIFTING EQUIPMENT TO POSITION THE BOWL AND PEDESTAL ASSEMBLY. HANDLE WITH CARE! FAILURE TO DO SO COULD RESULT IN SERIOUS PERSONAL INJURIES.
Classic Circular 36"/54" Washfountain with Foot Control WF2605, WF2608 Terrazzo — WF2705, WF2708 Stainless Steel Installation Instructions Installation Instructions continued . . . Step 4: Installing drain spud in bowl NOTE: Seal between drain spud and drain hole with plumber’s putty (supplied by installer). 1. Secure drain spud with lock nut and washers as shown in Figure 7.
Installation Instructions Classic Circular 36"/54" Washfountain with Foot Control WF2605, WF2608 Terrazzo — WF2705, WF2708 Stainless Steel Installation Instructions continued . . . Step 5a: Installing Supplies with Optional Soap Dispenser for A/O drain units NOTE: See Step 5b for units with type B/H drain. NOTE: For models with optional paper towel dispensers, tie pipe assembly, or shroud, see separate instruction sheets and Step 5b for units with type B/H drain.
Classic Circular 36"/54" Washfountain with Foot Control WF2605, WF2608 Terrazzo — WF2705, WF2708 Stainless Steel Installation Instructions TYPE "O" DRAIN (Supplies from above) TYPE "A" DRAIN Acorn Nut (110-052A) & Set Screw (160-093) Dispenser Cover Soap Dispenser Lid Upper Tie Rod (176-010) Spacer (113-155A) Soap Dispenser Upper Tie Bar (159-009A) (notched at corners) Coupling Nut (110-051D) Set Screws (160-208) PARTS SHOWN IN BOX ARE FOR UNITS WITH SOAP DISPENSER.
Installation Instructions Classic Circular 36"/54" Washfountain with Foot Control WF2605, WF2608 Terrazzo — WF2705, WF2708 Stainless Steel Installation Instructions continued . . . Step 5b: Installing Supplies with Optional Soap Dispenser for B/H drain units NOTE: Flush supply lines before making connections. 1. Install the hemmed end (not sharp end) of the support tube with gasket onto the bowl. 2.
Classic Circular 36"/54" Washfountain with Foot Control WF2605, WF2608 Terrazzo — WF2705, WF2708 Stainless Steel Installation Instructions Installation Instructions continued . . . TYPE "H" DRAIN (Supplies from below) TYPE "B" DRAIN Cap Screw (160-108) 1-1/2" Vent Pipe HOT COLD Supplies 1/2" Nom.
Classic Circular 36"/54" Washfountain with Foot Control WF2605, WF2608 Terrazzo — WF2705, WF2708 Stainless Steel Installation Instructions Installation Instructions continued . . . Step 6: Installing the Valve Assembly NOTE: Flush supply lines before making connections. 1. Connect the stop-strainer-check valves, mixing valve, volume control valve, and foot valve as shown in Figure 10. 2.
Classic Circular 36"/54" Washfountain with Foot Control WF2605, WF2608 Terrazzo — WF2705, WF2708 Stainless Steel Installation Instructions Installation Instructions continued . . . Step 7: Installing the Operating Rod 1. Insert the operating rod in the operating rod lever and then into the foot lever (see Figure 11). NOTE: For normal operation, use the operating rod as shipped. The spring loaded cartridge should be adjusted so there is no play in the operating lever.
Installation Instructions Classic Circular 36"/54" Washfountain with Foot Control WF2605, WF2608 Terrazzo — WF2705, WF2708 Stainless Steel Soap Recommendations and Maintenance Tips Quality soap dispensers require good quality soap and periodic maintenance to properly operate. Bradley soap dispensers will provide dependable, consistent operation over the long term when soap with reasonable viscosity and pH levels are used and when a minimal amount of periodic maintenance is performed on the valves.
Classic Circular 36"/54" Washfountain with Foot Control WF2605, WF2608 Terrazzo — WF2705, WF2708 Stainless Steel Soap Valve - Liquid - S09-007S Installation Instructions Parts List * Not Illustrated Attaching Parts S09-007S This valve delivers a measured amount of soap with each upward stroke. The soap dispenser has been standard on washfountains since 1983 and is not well-suited for very thick lotion soaps. NOTE: Lotion soap will clog liquid soap valves. Use only lotion soap valves with lotion soap.
Classic Circular 36"/54" Washfountain with Foot Control WF2605, WF2608 Terrazzo — WF2705, WF2708 Stainless Steel Installation Instructions Stop, Strainer and Check Valve 1 Stop 2 3 4 2 5 6 3 8 1/2" NPT 1/2" NPT 9 11 5 Parts List * Part No. 7 10 6 Item 4 Strainer 1 S60-003 Parts List Item Stop Assembly S21-014 Standard Celcon Core Part No.
Classic Circular 36"/54" Washfountain with Foot Control WF2605, WF2608 Terrazzo — WF2705, WF2708 Stainless Steel Installation Instructions Sprayhead Troubleshooting and Repair Parts Problem: Water splashes over the rim of the bowl. Cause: Foreign matter has reduced the size of the sprayhead slots, causing greater pressure at the open slots. Solution: Clean the sprayhead: 1. Disassemble the sprayhead and dislodge any dirt, lime build-up and foreign debris with a wire brush. 2.
Classic Circular 36"/54" Washfountain with Foot Control WF2605, WF2608 Terrazzo — WF2705, WF2708 Stainless Steel Installation Instructions Repair Parts continued . . . S65-230 — Repair Kit for Foot Valve S07-066 S07-066 Foot Valve 6 ITEM QTY. PART NO.
Classic Circular 36"/54" Washfountain with Foot Control WF2605, WF2608 Terrazzo — WF2705, WF2708 Stainless Steel Installation Instructions Manual Mixing Valve Repair Parts Manual Mixing Valve Parts List Valve Assembly S01-038 Item 1 1 2 3 4 5 6 6 7 7 * * * * * * 22 Part No.
Classic Circular 36"/54" Washfountain with Foot Control WF2605, WF2608 Terrazzo — WF2705, WF2708 Stainless Steel Installation Instructions Volume Control Valve Repair Parts Volume Control Valve Parts List Brass Valve S02-045 Item 1 2 3 3 4 5 6 6 Part No. 125-001BC 152-038 121-016 121-016A 124-001BD 119-060 118-033 118-033B Description O-Ring Roll Pin Bonnet Bonnet Fiber Washer Valve Core Valve Body Valve Body Bradley Corporation • 215-603 Rev.
Classic Circular 36"/54" Washfountain with Foot Control WF2605, WF2608 Terrazzo — WF2705, WF2708 Stainless Steel Installation Instructions Adjusting the Vernatherm Thermostatic Mixing Valve NOTE: This valve is NOT factory preset. Upon installation, the temperature of this valve must be checked and adjusted to ensure delivery of a safe water temperature. Water in excess of 110°F (43°C) may cause scalding. 1. Check the temperature when approximately 1.
Installation Instructions Classic Circular 36"/54" Washfountain with Foot Control WF2605, WF2608 Terrazzo — WF2705, WF2708 Stainless Steel Thermostatic Mixing Valve Maintenance and Troubleshooting NOTE: Before attempting to troubleshoot the valve or disassemble the components, check for the following conditions: • If stop/check valves are used, make sure that they are fully open • Make sure that the hot and cold inlet pipes are connected properly, and that there are no crossconnections or leaking stop/che
Classic Circular 36"/54" Washfountain with Foot Control WF2605, WF2608 Terrazzo — WF2705, WF2708 Stainless Steel Installation Instructions Vernatherm Thermostatic Mixing Valve (S01-525) Parts List — Repair Kit S65-259 Parts List Item Part No.
Installation Instructions Classic Circular 36"/54" Washfountain with Foot Control WF2605, WF2608 Terrazzo — WF2705, WF2708 Stainless Steel Cleaning of Washfountains To Preserve Finish of Terrazzo Compositions Clean terrazzo Washfountain bowls daily or as often as conditions require with any standard household detergent, hot water and soft cloth. Bradley terrazzo bowls may be refurbished by cleaning with tri-sodium phosphate, two pounds per gallon, and a scrub brush.
Classic Circular 36"/54" Washfountain with Foot Control WF2605, WF2608 Terrazzo — WF2705, WF2708 Stainless Steel Installation Instructions Cleaning and Maintenance Instructions for Stainless Steel Material Description: Stainless steel is extremely durable, and maintenance is simple and inexpensive. Proper care, particularly under corrosive conditions, is essential. Always start with the simplest solution and work your way toward the more complicated.
