BRIGGS & STRATTON Models / Hodelos 030252 030297 PRECAUCION Before using this product, read this manual and follow all Safety Rules and Operating Instructions. 01 BRIGGS & STRATTON POWER JEFFERSON,WISCONSIN, 8 Antes de utilizar el producto, lea este manual y siga todas las P,eglas de Seguridad e Instrucdones de Uso. PRODUCTS U.S.A. GROUP, LLC Manual Revision No.
SAVE THESE TABLE INSTRUCTIONS OF CONTENTS Safety Rules .................................... Know Your Generator ............................. SAFETY 2-4 S Assembly ....................................... Operation .................................... Specifications ................................... Maintenance .................................... 4 Troubleshooting ................................. Notes ......................................... 5 6 V_arranty 7 ..................................
WARNING Operate generator WARNING ONLY outdoors. WHEN Keep exhaust gas from entering a confined area through windows, doors, vend[at]on intakes or other openings. . ADDING Turn generator DO NOT operate generator inside any building or enclosure (even if doors or windows are open), including the generator compartment of a recreational vehicle (RV). removing tan[<. OR DRAINING FUEL OFF and let it coo[ at [east 2 minutes before fuel cap.
CAUTION WARNING DO NOT tamper with governed speed. Generator supplies correct rated frequency and voltage when running at governed WHEN ADJUSTING GENERATOR OR MAKING REPAIRSTO¥OUR spee& DO NOT modify generator in am/way. Disconnect the spar[< plug wire from the spar[< plug and place the wire where it cannot contact spark plug. WNENTESTING FOR ENGINE SPARK * Use approved spar[< plug testen DO NOT check for spark with spark plug removed. See "Don't WARNING Overload Generator".
KNOWYOUR GENERATOR Read this the operator's and generator, safety fumes before operating yourthe generator.
ASSEMBLY Add Fuel Your generator requires some assembly and is ready for use after it has been properly serviced with the recommended oil and fuel. NOTE: This gasoline engine is certified to operate on gasoline. Exhaust Emission Control System: EP1 (Engine Modifications). If you have any problems with the assembly of your generator, please call the generator heIp[ine at [ °800°743°4 [ [ 5. [f calling for assistance, please have the mode[, revision, and serial number from the data tag available.
USING THE GENERATOR Generator Generator System Location Clearance 6; round WANNmNG The generator has a system ground that connects the generator frame components to the ground terminals on the AC output receptacles.The system ground is connected to the AC neutral wire (see '°Equipment Description", earlier in this manual).
OPERATING Starting the Disconnect following I. THE Engine all electrical start btake sure loads instruction unit WARNmNG from steps is on the generator. in numerical Use the order: DO NOT touch hot surfaces and avoid hot exhaust gases, a level surface. Allow iMPORTANT: Failure to start and operate unit on a level surface will cause the unit not to start or shut down during operation. 2. Turn fuel valve to "On" position equipment to coo[ before touching. Keep at least 5 ft.
$to$ I. the Creating Engine Turn OFF and unplug ALL electrical loads from generator panel receptacles. NEVER start or stop engine with electrical devices plugged in and turned ON. 2. Let engine run at no-load for several minutes to stabilize internal temperatures of engine and generator. 3. Hove fuel valve to'°Off' 4. Turn engine off according to instructions engine operator's manual. a Temporary Shelter [. [n an emergency, use the original shipping carton. 2.
. Start generator as described in the section "Starting the Engine", then place carton over generator. Keep at least 5 ft. (152 cm) clearance on all sides of generator including overhead with shelter in place. WARNmNG [ 20/240 Volt AC, 20 Amp Receptacle Locking Use a NEP1A LI4-20 plug with this receptacle. Connect a 4-wire cord set rated for 250Voks AC at 20 Amps (or greater) (Figure 5).You can use the same 4-wire cord if you 4an to run a 120Vok load.
CAUTmON DO NOT use any outlets on the circuit. Call or take your generator to a local service centen If the GFCI trips by itself at any time, reset and test the outlet. Jf the reset button does not pop out when the test button is pressed, do not use the outlet. Call or t_J
DON'T OVERLOAD 4. Plug in and turn on the next load. 5. Again, permit 6. Repeat the generator load. NEVER add more loads than the generator capacity.Take special care to consider surge loads in generator capacity, as described above. C acity You must make sure your generator can supply enough rated (running) and surge (starting) watts for the items you will power at the same time. Follow these simple steps: I. Select the items you will power at the same time. 2.
SPECIFICATIONS Starting Wattage ..................... VVattage ............................. Rated AC Load Current 5,300 _Vatts 4,000 _/atts At 120Volts ....................... 33.3 Amps At 240 Volts ....................... 16.6 Amps Phase .................................. Rated Frequency ....................... Fuel Tan[< Capacity .................. Shipping_^¢eight ..........................
Engine Thegenerator should be started at least once every seven days and allowed to run at least 30 minutes. If this cannot be done and you must store the unit for more than 30 days, use the following guidelines to prepare it for storage. Generator Storage Clean the generator as outlined in °°Generator Check that cooling air slots and openings are open and unobstructed. Cleaning'. on generator Storage See engine operator's Other Storage manual for instructions.
TROUBLESHOOTING Problem Cause No AC output is available, generator is running° but I. One of the 2. Fault in generator. Poor connection 3. circuit breakers or defective is open. cord I. Reset 2. Contact 3. Check Connected device 4. is bad. Generator and runs will not start; or starts I. Short 2. Generator circuit in a connected 3. Shorted is overloaded. generator Low oil level. rough, Generator operation, shuts down Generator [acks power.
1
Effective September 1, 2004 replaces a[[ undated Warranties and a[[ Warranties dated before September 1, 2004 L[MmTED WARRANTY Briggs & Stratton Power Products Group, LLC will repair or replace, free of charge, any part(s) of the equipment that is defective in material or workmanship or both. Transportation charges on parts submitted for repair or replacement under this warranty must be borne by purchaser. This warranty is effective for the time periods and subject to the conditions stated below.
CONSERVE TABLA ESTAS DE CONTEN[DOS REGLAS Reg[as De Seguridad ................................ Conozca Su Generador ................................ 18-20 21 Mont.aie ............................................. 23-28 29 AJmacenamient.o ...................................... 30 Diagnost.icos De Aver[as ................................ Garant.ia ............................................ 3[ 32 DEL DE SEGUR[DAD Este es e[ simbo[o 22 Operad6n ........................................ Mant.
ADVERTENCmA Opere el generador SOLAHENTE ADVERTENCmA a[ aire libre. CUANDO ANADA Apague eHgenerador 2 minutos NO opere el generador dentro de un edifido o [ugar cerrado (aunque haya puertas o ventanas abiertas), incluyendo el compardmiento de[ generador en un vehicu[o recreadvo o RV. Liene ovacie • NO klantenga calory • NO NO toque los alambres (GFCI) en conductiva, opere el generador la combustible encienda • un cigarrillo o fume.
ADVERTENCmA CUANDO A]USTE GENERADOR O FiAGA REPARACmONES PRECAUCmON A SU NO cambie ninguna veHocidad decerminada. EHgenerador suminiscra una frecuencia y un voHcaiecaHificado cuando funciona a una veHocidad determinada. NO modifique aHgenerador Siempre desconecte eHaHambrede Habuiia y coH6queHodonde no pueda encrar en concacco con Habuiia. CUANDO PRUEBE LA BUJiA DEL en ninguna forma. PRECAUCmON MOTOR Utihce un comprobador de bujias homoHogado. NO comprueba Hachspa sin Habujia inscaHada.
CONOZCA _/_ $U GENERADOR EA ESTE[as MANUAL Compare i[ustradones DEL con OPERARIOY su Generador Conserve este manual para referendas LASfami[iarizarse REGLAS DE DE OPERAR $U yGENERADORo para con $EGURIDAD [as ubicaciones ANTES de los diferentes contro[es ajustes, futuras, Tanque de[ Combustible Concador de HaHora V_.
HONTAJE Agregue Su generador requiere de dertos procedimientos de montaie y solo estar_t [isto para ser utilizado despues de habeHe suministrado servicio con el combustible y aceite recomendados, NOTA: Este motor Sistema de control Si usted dene probiemas con el montaje de su generadog favor [lame a la linea de ayuda para generadores a[ Combustible Modificaciones estk certificado de emisiones para funcionar de gases con gasolina. de escape: EM del motor). por ADVERTENCmA 1-800-743-4115.
U$O OEL GENERADOR Tierra deU Sistema ERgenerador dispone de una conexi6n a qerra Ubicaci6n deU Generador Espacio AIrededor Libre de[ Generador ADVERTENCmA del sistema que conecta los componentes del basddor a bs terminales de derra de bs enchufes hembra de salida de CA. La qerra del sistema es_ conectada conectado al came de CA neutro al bas'ddor del generador que, a su vez, es_ (vea"Descripi6n del Deje un espacio minimo de 152 cm (S pies) alrededor incluida la parte superior.
OPERANDO Endenda EL GENE DOR eU Motor Desconect.e todas hs cargas electricas siguient.es instrucdones numedco_ l. ADVER'rENCIA de[ generadon Use hs para encender, paso por paso, en orden AsegOrese de que [a unidad est_ en una superfide piana. INPORTANTE: Si [a unidad no se arranca y ut.ihza en una superfide plana, se pueden produdr probRemas de arranque y de parada durant.e el fundonamient.o. 2. NO Gire [a v_[vula de[ combustible a [a posid6n "On" (Figura 11).
Parado l, De[ Motor Desconecte TODAS hs cargas el6ctricas rrientes de[ panel de[ generador, NUNCA detenga el motor con los dispositivos de los tomacode arranque o electricos conectados 7 ENCENDIDOS. 2.
[201240 VoUdos AC, 20 Amperios, Recept_cu[o de Seguridad ADVERTENCmA Use un tap6n NEHA L14-20 con este recept_culo. Conecte un ]uego de cable de 4 ahmbres, dasificado corno 250Vokios AC a 20Arnperios (o mayor) (Figura {3). Usted puede usar el rnisrno cable de 4-ahrnbres si phnea trabaiar con una carga de 120%kios. Juego de Cable de 4 Alarnbres NO toque Hassuperficies cahentes y evite ios gasesdell escape a aita temperamra. Permita que ei eqopo se enfrie antes de mcario.
NOTA: Si el disyuntor desconectan. Use cada recept_cu[o bipolar sa[ta, [as tomas domes se Si [a prueba para operar 120Vokios AC, de fase send[h, de cargas de 60Hz que reqoeren hasta 1,800 ratios ( [.8 [<_vM) a corrientes de 15 Amperios. Use los ]uegos de cables que son calificados para cargas de [25Voltios AC, a [5 Amperios (o mayores).
NO SOBRECARGUE GENE DOR 4. Conecte 5, De nuevo, Capacidad 6, Usted debe asegurarse que su generador puede proveer el sufidente vataje calificado (cuando est6 fundonando) y de carga (a[ encender) para los aparatos a los cua[es va a proveer [a energ[a, a[ mismo tiempo. Siga estos pasos: Repita tenga. NUNCA aSada m_s cargas sobre [a capacidad de[ generador. Tome una atenci6n especial en considerar [as cargas de corriente segQn [a capacidad de[ generadon como se describe arriba. 1.
ESPECmFmCACmONES NOTA: Vataje que empieza ..................... 5,300 Vatios (5.3 [@_v') Vata[e 4,000 Vatios (4.0 kW) ............................... Corriente NO recomendamos [impiar e[ generador. combustible introduce de Carga de C.A.: de[ motor a[go de[ agua quedar_ retenida en los espacios vacios 16.6 Amperios y grietas de[ ais[amiento a 120Volqos 33.3 Amperios acumu[aci6n Frecuenda Nominal ....................... Fase .........................................
ALNACENANmENTO A[macenando E[ generador deber_, ser encen@do a[ menos una vez cada siete d[as 7 deber_, dejar[o funcionar a[ menos durante 30 minutos. Si no puede hacer esto y debe almacenar [a unidad por m_s de 30 d[as, siga [as siguientes instrucciones para preparar su unidad para a[macenamiento. Consuke A[macenando e[ manua[ de[ operario de c6mo preparar a[macenamiento. Otras .
DIAGNO$ITICO$ DE AVERiA$ Accion Prob[emo E[ motor exist÷ est_ fundonando pero 1, E[ interruptor esti abierto, 2. Conexi6n mar o defectuosa de cabRes, 3, E[ dispositivo 4, Averia en el generadom: no samida de AC disponsibme° 1, E[ motor "funciona fundona bien sin carga pero mar' cuando se [e contectan cargas. 2. 3, El motor no se enciende; enciende y funciona E[ motor se apaga o se Causa autom_tico conectado Corto drcuito conectadas, E[ generador Circuito [, Reposicione de.
Fecha de entrada en vigor: t de Septiembre de 2004. Sustituye a todas las garanNas GARANTiA sin fecha y alas de fecha anterior al 1 de Septiembre de 2004 LmMmTADA Briggs & Stratton Power Products Group, LLC reparara o sustituira sin cargo alguno cualquier componente del equipo que presente defectos de materiales y/o mano de obra. Los gastos de transporte de las piezas enviadas para reparar o sustituir conforme a los terminos de esta garantia correran a cargo del comprador.