Technical information

ManualsBrandsBriggs & Stratton ManualsAutomobile Parts80000

Model 90000

Classic 450 Series

Sprint 475 Series

Quattro 475 Series

Model 100000

Sprint 500 Series

Quattro 500 Series

LX 500 Series

SQ 500 Series

Q 500/550 Series

BRIGGSandSTRATTON.com

E Copyright Briggs & Stratton Corporation

Milwaukee, Wisconsin 53201 U.S.A.

Form No. MS-3479-9/06

Printed in U.S.A.

Operating & Maintenance Instructions

Betriebsanleitung & Wartungsvorschriften

Drifts- og vedligeholdelsesvejledning

Instrucciones de Mantenimiento & Operación

Instructions d’utilisation et de maintenance

Ïäçãßåò Ëåéôïõñãßáò & ÓõíôÞñçóçò

Istruzioni per l’uso e la manutenzione

Anvisninger for bruk og vedlikehold

Gebruiksaanwijzing

Instruções de operação e de manutenção

Instruktionsbok

Käyttö & Huolto-ohjeet

Summary of content (10 pages)

PAGE 1
GB D DK E F GR I N NL P S SF Model 90000 Classic 450 Series Sprint 475 Series Quattro 475 Series BRIGGSandSTRATTON.
PAGE 2
5 4 3 6 2 1 7 Ê 13 Ë 8 9 10 12 11 ** * °F °C -20 -30 32 20 0 -20 -10 0 40 60 10 80 20 Ë Ê Ì 100 30 40
PAGE 3
GB Note: (This note applies only to engines used in the U.S.A.) Maintenance, replacement or repair of the emission control devices and systems may be performed by any nonroad engine repair establishment or individual. However, to obtain no charge repairs under the terms and provisions of the Briggs & Stratton warranty statement, any service or emission control part repair or replacement must be performed by a factory authorized dealer. Engine Components (see fig.
PAGE 4
GB WARNING WARNING WARNING Gasoline and its vapors are extremely flammable and explosive. Engines give off carbon monoxide, an odorless, colorless, poison gas. Running engines produce heat. Engine parts, especially muffler, become extremely hot. Fire or explosion can cause severe burns or death. Breathing carbon monoxide can cause nausea, fainting or death. Severe thermal burns can occur on contact. WHEN ADDING FUEL • Turn engine OFF and let engine cool at least 2 minutes before removing gas cap.
PAGE 5
GB Oil Recommendations (see fig. ) Engine shipped from Briggs & Stratton without oil. Before starting engine, fill with oil. Do not over-fill. Use a high quality detergent oil classified For Service SF, SG, SH, SJ" or higher such as Briggs & Stratton 30W, Part Number 100005. Use no special additives with recommended oils. Do not mix oil with gasoline. Choose the SAE viscosity grade of oil from this chart that matches the starting temperature anticipated before the next oil change.
PAGE 6
GB Maintenance Cont’d Spark plug service (see fig. ) DO NOT check for spark with spark plug removed. Use only Briggs & Stratton Spark Tester , to check for spark. DO NOT crank engine with spark plug removed. If engine is flooded, place throttle in FAST and crank until engine starts. Spark plug gap should be .76 mm or 0.030 in. Replace spark plug every 100 hours or every season, whichever occurs first. Spark plug wrench is available from any Authorized Briggs & Stratton Service Dealer.
PAGE 7
GB Storage Service Engines stored over 30 days need to be protected or drained of fuel to prevent gum from forming in fuel system or on essential carburetor parts. For engine protection, we recommend use of Briggs & Stratton Fuel Stabilizer available from an Authorized Briggs & Stratton Service Dealer. Mix stabilizer with fuel in fuel tank or storage container. Run engine for a short time to circulate stabilizer through carburetor. Engine and fuel can be stored up to 24 months.
PAGE 8
GB BRIGGS & STRATTON ENGINE OWNER WARRANTY POLICY Effective September 1, 2006 LIMITED WARRANTY Briggs & Stratton Corporation will repair or replace, free of charge, any part(s) of the engine that is defective in material or workmanship or both. Transportation charges on parts submitted for repair or replacement under this warranty must be borne by purchaser. This warranty is effective for and is subject to the time periods and conditions stated below.
PAGE 9
Ë Ì Ê Í Ê ÏÏÏÏÏÏÏ Ë ÏÏÏÏÏÏÏ ÏÏÏÏÏÏÏ ÏÏÏÏÏÏÏ ÏÏÏÏÏÏÏ ÏÏÏÏÏÏÏ ÏÏÏÏÏ ÏÏÏÏÏÏÏ ÏÏÏÏÏ ÏÏÏÏÏ Ê ÏÏÏÏÏÏ ÏÏÏÏÏÏ ÏÏÏÏÏÏ ÏÏÏÏÏÏ ÏÏÏÏÏÏ ÏÏÏÏ ÏÏÏÏÏÏ ÏÏÏÏ ÏÏÏÏ Ê Í Ï Ì Ë Ê 0.030” (.
PAGE 10
(This page applicable in the U.S.A. and Canada only.) Briggs & Stratton Corporation (B&S), the California Air Resources Board (CARB) and the United States Environmental Protection Agency (U.S. EPA) Emissions Control System Warranty Statement (Owner’s Defect Warranty Rights and Obligations) The California Air Resources Board (CARB), U.S.