Call 1-800-667-8721 anywhere in the US and Canada - www.rangehoods.com at :: rangehoods . com B Y B R O A N - N U T O N E RM60000 SERIES RANGE HOOD INSTALLATION INSTRUCTIONS AND USER MANUAL HB0026 RESIDENTIAL USE ONLY READ AND SAVE THESE INSTRUCTIONS INSTALLER: LEAVE THIS MANUAL WITH HOMEOWNER. HOMEOWNER: USE AND CARE INFORMATION ON PAGE 11. V05527 rev B Broan at :: rangehoods .
:: rangehoods . com ! Call 1-800-667-8721 anywhere in the US and Canada - www.rangehoods.com WARNING ! TO REDUCE THE RISK OF FIRE, ELECTRIC SHOCK, OR INJURY TO PERSON(S) OBSERVE THE FOLLOWING: 1. 2. 3. 4. 5. 6. 7. 8. 9. Use this unit only in the manner intended by the manufacturer. If you have questions, contact the manufacturer at the address or telephone number listed in the warranty.
:: rangehoods . com Call 1-800-667-8721 anywhere in the US and Canada - www.rangehoods.com TABLE OF CONTENTS 1.0 2.0 3.0 4.0 5.0 6.0 7.0 8.0 9.0 10.0 11.0 12.0 13.0 14.0 15.0 16.0 17.0 SELECT BLOWER OPTION AND INSTALL DUCTWORK . .5 MEASURE INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . .6 PREPARE THE INSTALLATION . . . . . . . . . . . . . . . . . . . . . .6 INSTALL BACKSPLASH . . . . . . . . . . . . . . . . . . . . . . . . . . .7 INSTALL WOOD MOUNTING STRIP . . . . . . . . . . . . . . . . .
:: rangehoods . com Call 1-800-667-8721 anywhere in the US and Canada - www.rangehoods.com Wall & Roof Caps, Ext. Blowers MODEL 331H MODEL 335 MODEL 437 MODEL 441 (600 cfm) OR (1200 cfm) OR (High Capacity (10” Rd. 332H (900 cfm) 336 (1500 cfm) Wall Cap) Roof Cap) (Exterior Blower) (Exterior Blower) MODEL 647 (7” Rd. Wall Cap) MODEL 634 OR 644 (Roof Cap) Elbows & In-Line Dampers MODEL 418 (10” Rd. Adjustable Elbow) MODEL 421 (10” Rd. Vert. In-Line Damper) MODEL 415 (7” Rd.
:: rangehoods . com Call 1-800-667-8721 anywhere in the US and Canada - www.rangehoods.com 1. SELECT BLOWER OPTION AND INSTALL DUCTWORK Either an interior or exterior blower may be used with this hood. The RM60000 Series hood must be installed with blower models RM325H, RM326H, 331H, 332H, 335 or 336 only. Other blowers cannot be substituted. (Blowers sold separately). NOTES:1. The 331H, 332H, 335 or 336 exterior blower MUST BE installed with the rough-in kit model 332KR (sold separately). 2.
:: rangehoods . com Call 1-800-667-8721 anywhere in the US and Canada - www.rangehoods.com 2. MEASURE INSTALLATION Dimensions for the most common installations are shown below. Adjust your measurements for various heights of ceilings, soffits, cabinets or cooktops. For proper operation, the hood must be a minimum of 24" and a maximum of 30" above the cooktop. Standard 8 ft. (2.
:: rangehoods . com Call 1-800-667-8721 anywhere in the US and Canada - www.rangehoods.com 4. INSTALL BACKSPLASH (OPTIONAL) RMP Series Backsplash must be installed before the hood shell because the hood shell covers the backsplash top mounting screws. In order to be able to install the backsplash, make sure you have at least 18” (457 mm) clearance between bottom of hood and range control panel or cooktop. (Refer to instructions included with backsplash.) 5.
:: rangehoods . com Call 1-800-667-8721 anywhere in the US and Canada - www.rangehoods.com 7. INSTALL TRANSITION TO ROUGH-IN PLATE Model 423, 424, 427, 453, or 454 Attach transition (if required) to blower rough-in plate. Use duct tape to make all joints secure and air-tight. NOTE: Model RM325H blower plate connects directly to 7" round ductwork without a transition. Exterior blower models utilize a model 332KR rough-in plate which connects directly to 10” round ductwork without a transition. HD0049 8.
:: rangehoods . com Call 1-800-667-8721 anywhere in the US and Canada - www.rangehoods.com 8. INSTALL THE ROUGH-IN PLATE TO THE HOOD (CONT’D) Wiring ! WARNING Risk of electrical shock. Electrical wiring must be done by qualified personnel in accordance with all applicable codes and standards. Before connecting wires, switch power off at service panel and lock service disconnecting means to prevent power from being switched on accidentally. Remove wiring cover from rough-in plate and set aside.
:: rangehoods . com Call 1-800-667-8721 anywhere in the US and Canada - www.rangehoods.com 12. INSTALL FILTERS CAUTION Remove protective plastic film covering filters before installing them. It is recommended to install side filters first and finish with center one(s). 1. Insert upper end of filter into the hood (finger sized cup side). 2. Raise lower end toward the inside of hood. 3. Position rear part of filter into channel and pull. 4.
:: rangehoods . com Call 1-800-667-8721 anywhere in the US and Canada - www.rangehoods.com 13. USE AND CARE Grease Filters The grease filters should be cleaned frequently. Use a warm detergent solution. Grease filters are dishwasher safe. Wash more often if our cooking style generates greater grease - like frying foods or wok cooking. Remove filters by pushing filters towards the back of hood and rotating filters downward. Blower Cleaning Remove the filters in order to access the blower.
:: rangehoods . com Call 1-800-667-8721 anywhere in the US and Canada - www.rangehoods.com 14. OPERATION Always turn ON your hood before you begin cooking in order to establish an air flow in the kitchen. Let the blower run for a few minutes to clear the air after you turn off the range. This will help keep the whole kitchen cleaner and brighter. 4 6 5 3 3 1 3 1 2 1. Warming lamps 2. Warming lamp switches 3. Halogen lights 4. Halogen light switches 5. ON/OFF Blower switch 6.
:: rangehoods . com Call 1-800-667-8721 anywhere in the US and Canada - www.rangehoods.com 15. WIRING DIAGRAM RIGHT HEAT LAMP SWITCH 120V 60HZ B IN TO FAN MOTOR RIGHT HEAT LAMP SOCKET W B B B W G HS B SPEED THERMOSTAT NEMA 5-15P W FAN SWITCH B CONTROL RIGHT LIGHT PLUG SOCKET W B W B LIGHTS SWITCH B CENTER LIGHT SOCKET W B LEFT LIGHT SOCKET B LEFT B W HEAT LAMP SWITCH LEFT HEAT LAMP SOCKET B W TERMINAL BLOCK W W W W W W W - 13 Broan at :: rangehoods .
:: rangehoods . com Call 1-800-667-8721 anywhere in the US and Canada - www.rangehoods.com 16. SERVICE PARTS 1 20 21 19 17 11 14 13 12 18 16 20 3 4 6 8 15 7 7 2 HL0031 22 5 9 10 2 - 14 Broan at :: rangehoods .
:: rangehoods . com Call 1-800-667-8721 anywhere in the US and Canada - www.rangehoods.com 16. SERVICE PARTS (CONT’D) KEY NO.
:: rangehoods . com Call 1-800-667-8721 anywhere in the US and Canada - www.rangehoods.com 17. WARRANTY BROAN-NUTONE ONE YEAR LIMITED WARRANTY Broan-NuTone warrants to the original consumer purchaser of its products that such products will be free from defects in materials or workmanship for a period of one year from the date of original purchase. THERE ARE NO OTHER WARRANTIES, EXPRESS OR IMPLIED, INCLUDING, BUT NOT LIMITED TO, IMPLIED WARRANTIES OR MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE.
