Installation manual

. .

TABLE OF CONTENTS

INSTALLATION DIAGRAM ..........................................................7-8

H1: 6 PIN HEAVY GAUGE WIRING CONNECTION...........................9

H1/1 Violet Wire  Starter Output...................................................9

H1/2 & H1/3 Red Wire  +12V Power Input .....................................9

H1/4 Yellow Wire  Ignition 1 Output ..............................................9

H1/5 Pink Wire  Ignition 2 Output .................................................9

H1/6 Brown Wire  Accessory Output (Heater /ACC Output) .............10

H2: 5 PIN WIRE HARNESS ..........................................................10

H2/1 Red / White wire  Parking Light Relay Power Input.................10

H2/2 White wire  Parking Light Relay Output ................................10

H2/3 Black wire  System Ground.................................................10

H2/4 Brown wire  (-) 200ma Horn Output ....................................11

H2/5 Red wire  System Power.....................................................11

H3: BLACK 4-PIN CONNECTOR

FOR TWO-WAY TRANSCEIVER/ANTENNA MODULE......................11

H5: 9 PIN BLACK WIRE HARNESS ...............................................11

H5/1 Grey wire  (-) Negative Safety Shut Down For Hood Pin Switch11

H5/2 Brown / Red wire  (+)

Positive Safety Shut Down Brake or Handbrake...........................12

H5/3 Black / White wire (-)

Neutral Safety Switch or (-) Remote Toggle Switch Input .............13

H5/4 Blue /White wire Not Used..................................................13

H5/5 Grey / Black wire  (-) Diesel Wait - To - Start Input ...............13

H5/6 Green wire  (-) Negative Door Pin Switch Input (Zone 3) ........13

H5/7 Violet Wire  (+) Positive Door Pin Switch Input (Zone 3).........14

H5/8 White / Black wire  (-) Instant Start & Turn Off Input .............14

H5/9 Violet / White wire  Tach Input or Oil Sensor Connection....14-15

H6. 6 PIN DOOR LOCK CONNECTOR ............................................15

Installing New Door Lock Actuator ................................................15

Type A Negative Trigger Door Lock System ..................................15

Type B Positive Trigger Door Lock System ...................................15

Type C 5-wire Door Lock System ................................................15

2 Steps Door Unlock Wire Connection

Type C 5 Wires Alternating Door Lock System ..............................16

Vacuum Operate Door Locking System ..........................................16

2 Steps Door Unlock Wire Connection

Type B Negative Switched Door Lock System ...........................16

D500IM 6/04