Instructions / Assembly

ManualsBrandsBullet ManualsBuilt-In Grills5-Burner Built-In Stainless Steel Natural Gas Grill

Rialto, California 92673

_________________________________________________________________________________________________________

ASSEMBLY & OPERATING INSTRUCTIONS

Model #54658

5 Burner Stainless Steel Built-In, L.P. (Propane) Gas

Model #54659

5 Burner Stainless Steel, Built-In, Natural Gas

TABLE OF CONTENTS PAGE

SAFETY INSTRUCTIONS ………………………………………………………………………………..……………… 2

INSTALLATION INSTRUCTIONS ………………………………………………………………………….………..….. 4

LIGHTING & OPERATING INSTRUCTIONS ……………………………………………………………………....…… 9

CLEANING & MAINTENANCE …………………………...………………………………………………………..….…. 12

TROUBLESHOOTING …………………………………………………………………………………………………….. 13

PARTS LIST ……………………………………………..………………………………………………………….……… 14

WARRANTY.……………………………………………..…………………………………………………………..……... 17

READ THE FOLLOWING INSTRUCTIONS CAREFULLY AND BE SURE YOUR GRILL IS PROPERLY INSTALLED,

ASSEMBLED AND CARED FOR. FAILURE TO FOLLOW THESE INSTRUCTIONS MAY RESULT IN SERIOUS BODILY INJURY

AND/OR PROPERTY DAMAGE. IF YOU HAVE QUESTIONS CONCERNING ASSEMBLY OR OPERATION, CONSULT YOUR

DEALER, GAS APPLIANCE SERVICE REPRESENTATIVE OR YOUR GAS COMPANY

NOTE TO INSTALLER:

LEAVE THESE INSTRUCTIONS WITH THE CONSUMER AFTER INSTALLATION.

NOTE TO THE CONSUMER

RETAIN THESE INSTRUCTIONS FOR FUTURE REFERENCE.

THIS OUTDOOR COOKING GAS APPLIANCE IS NOT INTENDED TO BE INSTALLED IN OR ON RECREATIONAL VEHICLES

AND/OR BOATS.

1 Revision 6-2011

SAFETY INSTRUCTIONS

Read carefully before assembling and operating your gas grill

This gas grill must be installed in accordance with local codes or, if in an area without local codes, with the latest edition of the

National Fuel Gas Code ANSI Z223.1. In Canada, installation must conform to the standard CAN/ CGA 1-b149.1 and/or .2

(Installation Code for Gas Burning Appliances and Equipment) and any local codes.

Summary of content (17 pages)

PAGE 1
Rialto, California 92673 _________________________________________________________________________________________________________ ASSEMBLY & OPERATING INSTRUCTIONS Model #54658 5 Burner Stainless Steel Built-In, L.P. (Propane) Gas Model #54659 5 Burner Stainless Steel, Built-In, Natural Gas TABLE OF CONTENTS PAGE SAFETY INSTRUCTIONS ………………………………………………………………………………..……………… 2 INSTALLATION INSTRUCTIONS ………………………………………………………………………….………..….. 4 LIGHTING & OPERATING INSTRUCTIONS ……………………………………………………………………....
PAGE 2
WARNING: Fuels used in gas or oil-fired appliances and the products of combustion of such fuels, contain chemicals known to the State of California to cause cancer, birth defects and/or reproductive harm. This warning is issued pursuant to California Health & Safety Code Sec. 25249.6. THE LOCATION FOR YOUR GRILL DO NOT use your gas grill in garages, porches, breezeways, sheds or other enclosed areas.
PAGE 3
NATURAL GAS SAFETY Your Natural Gas grill is designed to operate on natural gas ONLY, at a pressure of 4” water column (W.C.) regulated at the natural gas regulator attached at the back of the grill. Check with your gas utility for local gas pressure and with your local municipality for building code requirements. Check with your gas utility or with local building codes for instructions to install gas supply line, or call a licensed and knowledgeable installer.
PAGE 4
INSTALLATION INSTRUCTIONS PLEASE READ THESE INSTRUCTIONS BEFORE INSTALLING YOUR GAS GRILL Your Built-in Gas Grill comes to you fully assembled. We strongly recommend professional installation and hookup of the Gas BBQ grill. These instructions will provide you with the measurements necessary for you or your builder to construct a masonry structure to house your outdoor gas grill. NOTE TO INSTALLER: Leave these instructions with the consumer for future reference.
PAGE 5
OUTDOORS NATURAL GAS BBQ INSTALLATION SPECIFICATIONS NOTE: Vents must be provided for combustion air on both sides of built-in cabinet. When choosing a location for your gas grill keep in mind that it should never be located under any overhead combustible construction. The sides and back of the grill should not be any closer than 21 inches to combustible construction. DO NOT store empty or full spare tanks under or near this or any other appliance.
PAGE 6
OUTDOORS PROPANE GAS BBQ INSTALLATION SPECIFICATIONS NOTE: Vents must be provided for combustion air on both sides of built-in cabinet. When choosing a location for your gas grill keep in mind that it should never be located under any overhead combustible construction. The sides and back of the grill should not be any closer than 21 inches to combustible construction. DO NOT store empty or full spare tanks under or near this or any other appliance.
PAGE 7
INSPECTING I CLEANING BURNERS AND GAS VALVE ORIFICES By following these cleaning procedures on a timely basis, your grill will be kept clean and working properly with minimum effort. BURNER CLEANING 1. Remove burner from the grill bowl (See drawing on right). Bend a stiff wire (a light-weight coat hanger works well) into a small hook as shown below. Run the hook through each burner tube and burner several times. 2. Use a narrow bottlebrush with a flexible handle.
PAGE 8
COOKING COMPONENT INSTALLATION IMPORTANT: Before first use wash flame tamers, cooking grids, and warming rack with warm, soapy water. Rinse and dry thoroughly. Season metal surfaces with cooking oil occasionally. (After cooking is completed, turn grill to high setting for NO MORE THAN five minutes to burn off excess grease or food residue) CAUTION: DO NOT LEAVE GRILL UNATTENDED. 1. Place stainless steel heat shields on lowest ledge under / between burners in grill bowl.
PAGE 9
LIGHTING & OPERATING INSTRUCTIONS LIGHTING PROCEDURES Lighting Main Burner(s): 1. Become familiar with safety guidelines at front of manual. DO NOT SMOKE WHILE LIGHTING GRILL OR CHECKING GAS SUPPLY CONNECTIONSI 2. If your grill fuel source is a LP gas cylinder, check to see that cylinder is filled. 3. Check the end of each burner tube is properly located over each valve orifice. 4. Make sure all gas connections are securely tightened. TEST FOR LEAKS WITH A SOAP SOLUTION, NEVER WITH A FLAME.
PAGE 10
To light Rotisserie Burner with a match, Follow steps 1 through 2 above. Insert lighted fireplace-type match or long-necked butane lighter placing flame near to the Ceramic Panel. Press in control knob and rotate left (counter clockwise) to “HI” or “ON” setting to release gas. Burner should light immediately.
PAGE 11
10 LIGHTING & OPERATING INSTRUCTIONS ROTISSERIE COOKING (sold separately) Rotisserie is mostly used to cook large pieces of meat and poultry to assure slow, even cooking. The constant turning provides a self-basting action, making food cooked on a rotisserie exceptionally moist and juicy. Rotisserie cooking generally requires 1 ½ to 4½ hrs to cook depending on the size and type of meat being cooked. You can have rotisserie cooking with indirect heat as shown or with infrared rotisserie burner.
PAGE 12
11 CLEANING & MAINTENANCE CLEANING THE COOKING GRIDS After cooking, turn control knobs to “OFF” and let grill cool before attempting to clean your cooking grids. Before first use and periodically it is suggested that you wash the cooking grids in a mild soap and warm water solution. You can use a washcloth or a vegetable brush to clean your cooking grids. Take care not to chip the porcelain coating.
PAGE 13
12 TROUBLESHOOTING If grill fails to operate properly 1. Turn off gas at source, turn control knobs to “OFF”, and wait five minutes before trying again 2. Check gas supply/connections. 3. Repeat lighting procedure and, if grill still fails to operate properly, TURN “OFF” GAS AT SOURCE, TURN CONTROL KNOBS TO “OFF”, wait for grill to cool, and check the following: a. Misalignment of burner tube(s) over orifice(s) CORRECTION: Reposition burner tube to properly seat over orifice. b.
PAGE 14
13 PARTS LIST Model#21009 Model#21011 REF # DESCRIPTION QTY 1. Lid -Front 1 2. Lid -Rear 1 2A Cover-Rear Lid 1 3. Bowl Assembly 1 4. Control Panel 1 5. Grease Tray 1 6. Grease Tray Handle 1 7. Heat Shield 4 8. Burner 5 9. Flame Tamer 5 10. Cooking Grid 5 11. Warming Rack 1 12. Lid Handle 1 13. Warming Rack Support 2 14. Flame Tamer Support 18 15. Bezel 5 16. Control Knob 5 17. Temperature Gauge 1 18. Gas Valve With Ignition 5 19.
PAGE 15
14 HOW TO ORDER REPLACEMENT PARTS Please refer to the parts list on this page. To make sure you obtain the correct replacement parts for your gas grill, the following information is required to assure getting the correct part. 1. Gas grill model number (see data sticker on grill) and type of gas hook up. 2. Reference number of replacement part needed. 3. Description of replacement part needed 4. Quantity of parts needed. IMPORTANT: Use only factory authorized parts.
PAGE 16
15 ILLUSTRATED PARTS LIST
PAGE 17
16 LIMITED WARRANTY Bull Outdoor Products, Inc. warrants to the original purchaser at the original site of delivery with proof of purchase of each Outdoor Gas Grill that when subject to normal residential use, it is free from defects in workmanship and materials for the periods specified below. This warranty excludes grills used in rental or commercial applications.