ES2 User Information Manual

ManualsBrandsBurnham ManualsBoilersES2-4, 77,000 BTU Output High Efficiency Cast Iron Boiler (NG)

USER'S INFORMATION MANUAL

CAST IRON GAS-FIRED

HOT WATER AND STEAM BOILERS

109547-01 6/19

WARNING

• There are no user serviceable parts on this boiler. Attempts to service this boiler by someone other

than a qualified gas service technician could void the warranty, cause property damage, personal

injury or loss of life.

• This boiler has parts containing refractory ceramic fibers (RCF). After the boiler has been

fired, RCF may change into crystalline silica, a known carcinogen. See the safety information

in the Installation, Operating, and Service Instructions before attempting service or repair.

WARNING

If the information in this manual is not followed

exactly, a fire or explosion may result causing

property damage, personal injury or loss of life.

‐ Do not store or use gasoline or other flammable

vapors and liquids in the vicinity of this or any

other appliance.

‐ WHAT TO DO IF YOU SMELL GAS

• Do not try to light any appliance.

• Do not touch any electrical switch;

do not use any phone in your

building.

• Immediately call your gas supplier

from a neighbor's phone. Follow the

gas supplier's instructions.

• If you cannot reach your gas supplier,

call the fire department.

‐ Installation and service must be

performed by a qualified installer, service agency

or the gas supplier.

WARNING

Assurez-vous de bien suivre les instructions

données dans cette notice pour réduire au

minimum le risque d'incendie ou d'explosion

ou pour éviter tout dommage matériel, toute

blessure ou la mort.

‐ Ne pas entreposer ni utiliser d'essence ni

d'autres vapeurs ou liquides inflam-mables dans

le voisinage de cet appareil ou de tout autre

appareil.

‐ QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE

GAZ:

• Ne pas tenter d'allumer d'appareils.

• Ne touchez à aucun interrupteur. Ne

pas vous servir des téléphones dans

le bâtiment où vous vous trouvez.

• Appelez immédiatement votre

fournisseur de gaz depuis un voisin.

Suivez les instructions du fournisseur.

• Si vous ne pouvez rejoindre le

fournisseur de gaz, appelez le service

des incendies.

‐ L'installation et I'entretien doivent être assuréx

par un installateur ou un service d'entretien

qualifié ou par le fournisseur de gaz.

Summary of content (8 pages)

PAGE 1
USER'S INFORMATION MANUAL CAST IRON GAS-FIRED HOT WATER AND STEAM BOILERS ! WARNING ! If the information in this manual is not followed exactly, a fire or explosion may result causing property damage, personal injury or loss of life. ‐ Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.
PAGE 2
The following terms are used throughout this manual to bring attention to the presence of hazards of various risk levels. ! WARNING ! CAUTION Indicates a potentially hazardous situation which, if not avoided, could result in death, serious injury or substantial property damage. Indicates a potentially hazardous situation which, if not avoided, may result in moderate or minor injury or property damage. Basic Operation 1.
PAGE 3
Maintenance 1. Safe reliable operation of this boiler depends upon proper periodic maintenance. 2. The following should be done on a continuous basis: • Keep the area around the boiler free of objects, which are flammable or which could obstruct the flow of air into and around the boiler. • Do not store or use sources of hydrocarbons such as bleaches, fabric softeners, paints, cleaners, refrigerants, and cat boxes near the boiler.
PAGE 4
Figure 1: Boilers with Rear Relief Opening Figure 2: Boilers with Vertical Relief Opening Figure 3: Burner Compartment Area 4 109547-01 - 6/19
PAGE 5
LIGHTING AND SHUTDOWN INSTRUCTIONS (Boilers Equipped with Honeywell VR8204 and VR8304 Gas Valves) 109547-01 - 6/19 5
PAGE 6
LIGHTING AND SHUTDOWN INSTRUCTIONS (Boilers Equipped with Dual Honeywell VR8304 Gas Valves) POUR VOTRE SCURIT LISEZ AVANT DE METTRE EN MARCHE  If you do not follow these instructions exactly, a fire or explosion may result causing property damage, personal injury or loss of life.  Quiconque ne respecte pas  la lettre les instructions dans la prsente notice risque de dclencher un incendie ou une explosion entranant des dommages, des blessures ou la mort. A.
PAGE 7
LIGHTING INSTRUCTIONS FORSHUTDOWN BOILERS EQUIPPED WITH ROBERTSHAW LIGHTING AND INSTRUCTIONS 7000DERHC GAS VALVES (INTERMITTENT PILOT) (Boilers EquippedSERIES with Robertshaw 7000DERHC Series Gas Valves) FOR YOUR SAFETY READ BEFORE LIGHTING WARNING: If you do not follow these instructions exactly, a fire or explosion may result causing property damage, personal injury or loss of life. A. This appliance is equipped with an ignition device which automatically lights the pilot.
PAGE 8
109547-01 - 6/19