User Guide

ManualsBrandsBurnham ManualsBoilers109,000 BTU Output Independence Steam Boiler, Power Vented (Nat Gas)

103539-02 - 8/13

LAUNAMNOITAMROFNIS'RESU

ECNEDNEPEDNI

RELIOBDERIF-SAG

WARNING: If the information in this

manual is not followed exactly, a re or

explosion may result causing property

damage, personal injury or loss of life.

Do not store or use gasoline or other

ammable vapors and liquids in the

vicinity of this or any other appliance.

WHAT TO DO IF YOU SMELL GAS

• Do not try to light any appliance.

• Do not touch any electrical switch; do

not use any phone in your building.

• Immediately call your gas supplier

from a neighbor's phone. Follow the

gas supplier's instructions.

• If you cannot reach your gas supplier,

call the re department.

Installation and service must be

performed by a qualied installer, service

agency or the gas supplier.

AVERTISSEMENT. Assurez-vous de

bien suivre les instructions données

dans cette notice pour réduire au

minimum le risque d'incendie ou

d'explosion ou pour éviter tout

dommage matériel, toute blessure ou

la mort.

- Ne pas entreposer ni utiliser d'essence

ni d'autres vapeurs ou liquides inam-

mables dans le voisinage de cet

appareil ou de tout autre appareil.

- QUE FAIRE SI VOUS SENTEZ UNE

ODEUR DE GAZ:

• Ne pas tenter d'allumer d'appareils.

• Ne touchez à aucun interrupteur. Ne

pas vous servir des téléphones dans le

bâtiment où vous vous trouvez.

• Appelez immédiatement votre

fournisseur de gaz depuis un voisin.

Suivez les instructions du fournisseur.

• Si vous ne pouvez rejoindre le

fournisseur de gaz, appelez le service

des incendies.

- L'installation et I'entretien doivent

être assurés par un installateur ou un

service d'entretien qualié ou par le

fournisseur de gaz.

Summary of content (12 pages)

PAGE 1
U S E R ' S IN F OR M AT ION MAN U AL IN D E P E N D E N C E ® GA S - F I R E D BOI L E R WARNING: If the information in this manual is not followed exactly, a fire or explosion may result causing property damage, personal injury or loss of life. - Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. - WHAT TO DO IF YOU SMELL GAS • Do not try to light any appliance. • Do not touch any electrical switch; do not use any phone in your building.
PAGE 2
The following terms are used throughout this manual to bring attention to the presence of hazards of various risk levels. WARNING Indicates a potentially hazardous situation which, if not avoided, could result in death, serious injury or substantial property damage. CAUTION Indicates a potentially hazardous situation which, if not avoided, may result in moderate or minor injury or property damage.
PAGE 3
Basic Operation CAUTION Should overheating occur or the gas supply fail to shut off, do not turn off or disconnect the electrical supply to the pump. Instead, shut off the gas supply at a location external to the appliance. En cas de surchauffe ou si I'admission de gaz ne peut être coupée, ne pas couper ni débrancher l'alimentation électrique de la pompe. Fermer plutôt le robinet d'admission de gaz à l'extérieur de I'appareil. Do not use this boiler if any part has been under water.
PAGE 4
. Flame Rollout Switch See Figure 2. A device which automatically interrupts boiler operation when flames or excessive heat are present in the vestibule. The control is a single use device. Do not attempt to place boiler in operation if control was activated to interrupt boiler operation. Contact a qualified service agency. B. Instructions to place boiler in operation and to turn off boiler are shown on the Lighting or Operating Instruction label posted on the inside of the front removable door.
PAGE 5
Figure 4: Operating Instructions, Intermittent Ignition System, VR8204 and VR8304 (except Model IN12) Gas Valves 5
PAGE 6
Figure 5: Lighting Instructions, Continuous Ignition System, 7000 ERHC Gas Valve 6
PAGE 7
Figure 6: Operating Instructions, Intermittent Ignition System, VR8304 Gas Valves (Model IN12 Only) 7
PAGE 8
User Maintenance WARNING Service on this boiler should be undertaken only by trained and skilled personnel from a qualified service agency. Inspections should be performed at intervals specified in Installation, Operating and Service Instructions and this manual. Maintain manuals in a legible condition. Keep boiler area clear and free of combustible materials, gasoline and other flammable vapors and liquids.
PAGE 9
Figure 8: Pilot Burner Flame, Continuous Ignition System, Honeywell Q327 Pilot E. Schedule Inspection by Qualified Service Agency Figure 10: 1 Inch Main Burner Flame (Annual or at Beginning of Heating Season). For continued safe operation a qualified service agency must provide a more detailed inspection of burners, heat exchanger and vent system, and provide maintenance as specified in Installation, Operating and Service Instructions.
PAGE 10
SERVICE RECORD DATE SERVICE PERFORMED 10
PAGE 11
SERVICE RECORD DATE SERVICE PERFORMED 11
PAGE 12