Install Instructions

91
APPENDIX B - FIGURES
Figure
Number
Page
Number
Description
Section I - Product Description, Specication & dimensional Data
Figure 1A 6 V8H3 thru V8H9 Water Boiler without Tankless Heater
Figure 1B 7 V8H3 thru V8H9 Water Boiler with Front Tankless Heater
Figure 1C 8 V8H3 thru V8H9 Water Boiler with Rear Tankless Heater
Figure 1D 9 V8H3 thru V8H9 Steam Boiler with or without Tankless Heater
Section II - Pre-Installation
Figure 2 10 Minimum Installation Clearances To Combustible Materials (Inches)
Section III - Knockdown Boiler Assembly
Figure 3 12 Knockdown Boiler Removal from Skid
Figure 4 12 Boiler Canopy Installation
Figure 5 13 Boiler Tapping Locations and Usage (Knockdown Boilers Only)
Figure 6 14 Knockdown Boiler Jacket Assembly
Figure 7 15 Oil burner Installation (Beckett Burner Shown)
Figure 7A 18 Combustion Head Adjustment - 102CRD Burner
Figure 7B 18 Installation/Removal of Riello Drawer Assembly
Figure 7C 19 Riello Nozzle Replacement
Figure 7D 19 Riello Turbulator Setting
Figure 7E 19 Riello Pump Connections and Port Identication
Figure 8 21 Limit Sensor Insertion
Figure 9 22 Float-Type Low Water Cut-Off and Pressure Limit Installation
Figure 10 22 Pressure Limit Installation for Probe LWCO Equipped Boilers
Figure 11 23 Burner Disconnect Junction Box with Power Outlet Receptacle
Section IV - Packaged Boiler Assembly
Figure 12 24 Packaged Boiler Removal from Skid
Figure 13A 25 Partial Front View - Burner Swing Door Mounted to Boiler - Fully Closed and Secured
Figure 13B 26 Top View - Burner Swing Door Mounted to Cast Iron Block Assembly (Jacket Removed for Clarity)
Figure 13C 27 Top View - Burner Swing Door Fully Closed but Not Properly Secured or Sealed
Section V - Water Boiler Piping and Trim
Figure 14 29 Recommended Piping for Combination Heating and Cooling (Refrigeration) System
Figure 15A 30 Recommended Water Piping for Circulator Zoned Heating System - Supply Side Circulators
Figure 15B 31 Recommended Water Piping for Zone Valve Zoned Heating System - Supply Side Circulator
Section VI - Steam Boiler Piping and Trim
Figure 16 33 Recommended Boiler Piping for Gravity Return Steam Boiler
Section VII - Tankless and Indirect Water Heater Piping
Figure 17A 35 Schematic Tankless Heater Piping
Figure 17B 36 Indirect Domestic Water Heater Piping with V8H Steam Boiler
Section VIII - Venting and Air Intake Piping
Figure 18 38 Recommended Vent Pipe Arrangement and Chimney Requirements
Figure 19 38 Proper and Improper Locations of Draft Regulator
Figure 20 39 Optional Air Intake Piping Installation - Only Available with Beckett Burner