X-2 User Information Manual

ManualsBrandsBurnham ManualsBoilersX-2 - 146K BTU - 84% AFUE - Hot Water Propane Boiler - Chimney Vent

106637-01 - 10/15

WARNING: If the information in this

manual is not followed exactly, a re or

explosion may result causing property

damage, personal injury or loss of life.

- Do not store or use gasoline or other

ammable vapors and liquids in the

vicinity of this or any other appliance.

- WHAT TO DO IF YOU SMELL GAS

• Do not try to light any appliance.

• Do not touch any electrical switch;

do not use any phone in your

building.

• Immediately call your gas supplier

from a neighbor's phone. Follow the

gas supplier's instructions.

• If you cannot reach your gas

supplier, call the re department.

- Installation and service must be

performed by a qualied installer,

service agency or the gas supplier.

USER'S INFORMATION MANUAL

X-2™ SERIES

GAS - FIRED BOILER

Summary of content (8 pages)

PAGE 1
USER'S INFORMATION MANUAL X-2™ SERIES GAS - FIRED BOILER WARNING: If the information in this manual is not followed exactly, a fire or explosion may result causing property damage, personal injury or loss of life. - Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. - WHAT TO DO IF YOU SMELL GAS • Do not try to light any appliance. • Do not touch any electrical switch; do not use any phone in your building.
PAGE 2
The following terms are used throughout this manual to bring attention to the presence of hazards of various risk levels. WARNING CAUTION Indicates a potentially hazardous situation which, if not avoided, could result in death, serious injury or substantial property damage. Indicates a potentially hazardous situation which, if not avoided, may result in moderate or minor injury or property damage.
PAGE 3
Basic Operation CAUTION Should overheating occur or the gas supply fail to shut off, do not turn off or disconnect the electrical supply to the pump. Instead, shut off the gas supply at a location external to the appliance. Do not use this boiler if any part has been under water. Immediately call a qualified service technician to inspect the boiler and to replace any part of the control system and any gas control which has been under water. A. General.
PAGE 4
Figure 1: Control Locations
PAGE 5
Figure 2: Operating Instructions 5
PAGE 6
 Intelligent Hydronic Control display (typical) Standby Thermostat Calls for Heat Circulator Output Energizes  Self Testing  Limits Closed Checked Vent Damper Energized  Waiting For Damper to Open  Ignition Source Energized Pilot Gas On Trial For Ignition  Pilot Flame Proven  Ignition Source Off Main Gas On Call For Heat Ends Pilot Flame Not Proven  Ignition Source Off Pilot Gas Off Delay 60 Seconds Main Gas Off Vent Damper De-Energized Circulator O
PAGE 7
User Maintenance WARNING Service on this boiler should be undertaken only by trained and skilled personnel from a qualified service agency. Inspections should be performed at intervals specified in Installation, Operating and Service Instructions and this manual. Maintain manuals in a legible condition. Keep boiler area clear and free of combustible materials, gasoline and other flammable vapors and liquids.
PAGE 8
Figure 4: Pilot Burner Figure 5: Main Burner Flame All X-2 Series Repair Parts may be obtained through your local U.S Boiler Company product distributor. Should you require assistance in locating a U.S Boiler Company product distributor in your area, or have questions regarding the availability of U.S Boiler Company brand products or repair parts, please contact U.S. Boiler Company Customer Service at (717) 481-8400 or Fax (717) 481-8408.