TANKLESS GAS WATER HEATER PORTABLE TANKLESS GAS WATER HEATER USE & CARE MANUAL WITH INSTALLATION INSTRUCTIONS FOR THE INSTALLER
Note: Before using, please read this manual through carefully and keep this manual in a safe place for future reference. Illustrations shown in this manual are for reference only, please prevail in kind. Any questions regarding the operation, maintenance service or warranty of this water heater should be directed to Camplux, please contact via email at junskycustomerservice@outlook.com Introduction ..................................................... 1 General Safety ......................................
READ THIS MANUAL Inside you will find many helpful hints on how to use and maintain your water heater properly. A little preventive care on your part can save you time and money over the life of your water heater. You’ll find many answers to common problems in the Troubleshooting Guide. If you review the chart of Troubleshooting Tips first you may not need to call for service. READ THE SAFETY INFORMATION Your safety and the safety of others are very important.
DANGER! WATER TEMPERATURE SETTING Safety and energy conservation are factors to be considered when selecting the water temperature setting. Water temperatures above 125 (52 ) can cause severe burns or death from scalding. The thermostat is adjusted to its lowest temperature position when shipped from the factory. Be sure to read and follow the warnings outlined on the label pictured below.
the water heater, as well as the warnings printed in this manual. Failure to do so can result in property damage, bodily injury or death. DANGER! LIQUEFIED PETROLEUM MODELS LP gas have an odorant added to aid in detecting a gas leak. Some people may not physically be able to smell or recognize this odorant. If you are unsure or unfamiliar with the smell of LP gas, ask the gas supplier.
• Before attempting to light the water heater, make sure to look and smell for gas leaks. Use a soapy solution to check all gas fittings and connections. Bubbling at a connection indicates a leak that must be corrected. When smelling to detect a gas leak, be sure to sniff near the floor also. • It is recommended that more than one method, such as soapy solution, gas detectors, etc., be used to detect leaks in gas applications.
The Purpose and Benefits of the Camplux AY132 The Camplux AY132 is a liquid propane fired water heater capable of delivering 1.32 gallons of hot water almost anywhere. The portable tankless water heater has standard 1/2”BSP pipe fittings and CAMPLUX supplied GHT adapters for using a standard garden hose for inlet water supply. The Camplux AY132 gas water heater is not a toy. People around the world use similar portable tankless water heaters to heat the water around their homes, safely, and reliably.
TEMPERATURE INCREASE PER GPM MODEL GAS SETTING 0.5GPM 1.0GPM 1.5GPM 2.0GPM HIGHEST 75℃/167℉ 38℃/100℉ 25℃/77℉ 19℃/66℉ LOWEST 34℃/93℉ 17℃/63℉ 11 ℃/52℉ 9℃/48℉ AY132 *Temperature increases listed are based on use of the water heater under optimal conditions. Variable factors such as incorrect or imperfect installations and varying incoming water temperatures may yield different results. TECHNICAL SPECIFICATIONS MODEL AY132 BTU/H 34 ,000BTU/Hr DIMENSIONS 11.4x14.6x5.
Getting Started 1. Check carton box for damage. Damages caused in shipment must be reported immediately. 2. Make sure you have all the parts. Please note: Included parts and accessories may vary depending on country and regulations. a. Tankless gas water heater b. ON/OFF switch shower head with 5 feet chrome hose c. Gas regulator with 5 feet hose d. Gas connector (fixed to inlet fitting already) e. 1/2” BSP female X 3/4” GHT male, 1/2” BSP female X 3/4” GHT female to garden hose adapter f. Teflon tape g.
In The Box Description Portable tankless water heater Identification Quantity Remarks 1 piece On/off switch shower head with 5 feet chrome hose 1 set CSA Gas regulator with 5 feet hose 1 set Test for leaks after fitting 1 piece 1/2” BSP female X 5/8” NPT male flare Garden hose 2 pieces Left: 1/2” BSP female X 3/4” GHT male Right: 1/2” BSP female X 3/4” GHT female Teflon tape 1 roll Gas connector （Fixed to inlet fitting already） Washer Fixing kits 4 pieces 1 set For garden hose
How To Use The Garden Hose 1. Garden Hose GARDEN HOSE MALE GARDEN HOSE FEMALE 1/2”BSP FEMALE X 3/4”GHT MALE 1/2”BSP FEMALE X 3/4”GHT FEMALE NOTICE: MAKE SURE PUT THE RUBBER GASKET IN ALL FITTINGS BEFORE CONNECTION 2. Preparation ONLY USE IN WELL-VENTILATED AREAS. CARBON MOXOXIDE HAZARD-USING THIS APPLIANCE IN AN ENCLOSED SPACE WILL CAUSE DEATH-DO NOT USE IN CARAVANS, TENTS, MARINE CRAFT, CARS, MOBILE HOMES OR SIMILAR LOCATIONS.
before ignition as instruction. Make sure the gas inlet connector and water inlet connector are screwed all the way on. Tighten the fittings with use wrenches on both the brass adapter fitting on the appliance and the brass connector on the end of the hose l l l l l l Attach the water output apparatus (shower head) to the fitting marked “Water outlet”. DO NOT OVER TIGHTEN! Make sure to insert the supplied rubber gasket at the connections. Tighten by hand only.
setting. 7. Turn on your water output device to the “on”position and adjust to the desired water flow. 8. There will be a series of audible clicks and the burner will ignite. Should the burner not ignite after 5 seconds, shut off and go to the “Troubleshooting”section. 9. Upon completion of use or storage, open the drain valve (ribbed cylindrical stem next to the water input valve) to ensure draining of water. 10. Turn off your gas supply. 11.
knob until desired temperature is reached.
there is not enough water pressure. You need a minimum of 2.5PSI, sustained. Municipal water should supply enough water pressure. ADJUSTMENT: d. It is possible that some debris or epoxy might have entered the water inlet pipe. Check to see if the filter screen on the water inlet is clear of debris. You can also reverse the hookup by taking your water source and hooking it up to the water outlet side and back flushing the system. e.
g. The valve on the propane tank should be all the way “Open”. h. Fresh batteries are required for ignition spark. Make sure batteries are aligned in the proper polarity (+/-). The water does not get hot enough: a. You are operating the portable tankless water heater above 6,000 feet / 2,000 meters. We only recommend using it below elevations of 6,000 feet. b. Look into the viewer panes (middle horizontal windows on the front cover) to see if there is a blue flame.
