TANKLESS GAS WATER HEATER BD SERIES PORTABLE TANKLESS GAS WATER HEATER USE & CARE MANUAL WITH INSTALLATION INSTRUCTIONS FOR THE INSTALLER
READ THIS MANUAL Inside you will find many helpful hints on how to use and maintain your water heater properly. A little preventive care on your part can save you time and money over the life of your water heater. You’ll find many answers to common problems in the Troubleshooting Guide. If you review the chart of Troubleshooting Tips first you may not need to call for service. READ THE SAFETY INFORMATION Your safety and the safety of others are very important.
DANGER! WATER TEMPERATURE SETTING Safety and energy conservation are factors to be considered when selecting the water temperature setting. Water temperatures above 122 (50 ) can cause severe burns or death from scalding. The thermostat is adjusted to its lowest temperature position when shipped from the factory. Be sure to read and follow the warnings outlined on the label pictured below.
the water heater, as well as the warnings printed in this manual. Failure to do so can result in property damage, bodily injury or death. DANGER! D GE LIQUEFIED PETROLEUM MODELS LP gas have an odorant added to aid in detecting a gas leak. Some people may not physically be able to smell or recognize this odorant. If you are unsure or unfamiliar with the smell of LP gas, ask the gas supplier.
The Purpose and Benefits of the BD Series The Camplux BD series is a liquid propane fired water heater capable of delivering 1.58/2.64 gallons of hot water almost anywhere. The portable tankless water heater has standard 1/2”BSP pipe fittings and CAMPLUX supplied NPT adapters for using a standard garden hose for inlet water supply. The Camplux BD series gas water heater is not a toy.
Construction and parts for BD158/BD264 Getting Started 1. Check carton box for damage. Damages caused in shipment must be reported immediately. 2. Make sure you have all the parts. Please note: Included parts and accessories may vary depending on country and regulations. a. Tankless gas water heater b. ON/OFF switch shower head with 5 feet chrome hose c. Gas regulator with 5 feet hose d. Gas connector (fixed to inlet fitting already) e.
4. Install gas supply line and regulator to the portable tankless water heater. DO NOT OVER TIGHTEN. OVER TIGHTING MAY CRACK THE GAS REGULATOR CAUSING A GAS LEAK! Check for any gas smell before ignition! Make sure it is screwed all the way on. 5. Attach the shower head to the fitting marked ‘Water Outlet. Do not over tighten. 6. Install two “D”cell batteries in the compartment on the bottom left of the heater. Check that batteries are facing the correct direction. 7.
Garden hose 2 pieces Teflon tape 1 roll Washer Fixing kits 4 pieces Left: 1/2” BSP female X 3/4” GHT male Right: 1/2” BSP female X 3/4” GHT female For garden hose 1 set How To Use The Garden Hose 1.
2. Preparation ONLY USE IN WELL-VENTILATED AREAS. CARBON MOXOXIDE HAZARD-USING THIS APPLIANCE IN AN ENCLOSED SPACE WILL CAUSE DEATH-DO NOT USE IN CARAVANS, TENTS, MARINE CRAFT, CARS, MOBILE HOMES OR SIMILAR LOCATIONS. l Use appliance only with LP (propane) gas and the regulator valve assembly supplied. l Installation must conform with local codes, or in their absence with National Fuel Gas Code NFPA 54/ANSI Z223.1. Handling and storage of LP cylinder must conform to LP Gas Code NFPA/ANSI 58.
Before operate the drain plug, must be 1. Ensure that the water heater is disconnected from the gas supply. 2. Ensure that the water heater is disconnected from the water supply. 3. Ensure that the shower hose is disconnected from the water heater. Adjustment The temperature of the outgoing water is dependent on the temperature of the incoming water balanced with the amount of heat applied. Use extreme caution in setting the outlet water temperature. 1.