Candy Apple Stoves Part No.
SAFETY PRECAUTIONS This equipment is designed and sold for commercial use only. This equipment is not to be used by the consumer in home use. Do not allow direct contact of this equipment by the public when used in food service locations. Only personnel trained and experienced in the equipment operation may operate this equipment. Carefully read all installation instructions before operating the equipment. Always wear safety glasses when servicing this equipment.
Candy Apple / Caramel Corn Stoves INSTRUCTION MANUAL CANDY APPLE STOVES MODEL MODEL MODEL MODEL MODEL MODEL 2083............................................... 240 V, 2600 W 2080BG ............... Propane Gas, 20,610 BTU/HR 2080NG .................. Natural Gas, 19,700 BTU/HR 4002...................................... 230 V, 3380/4500 W 4110BG ................. Propane Gas, 20,610 BTU/HR 4110NG ..................
Candy Apple / Caramel Corn Stoves DIPPING Make sure apples are cleaned and sticks inserted. When temperature is 275º F, turn heat off. Pick up apple by stick, with thumb and index finger, insert into candy apple coating (immersing entire apple), remove from candy and spin excess candy. Place on greased cooling rack. GROUND PEANUT COATINGS Rolling candy apples in ground peanuts makes them very attractive. You must roll apples immediately after dipping. Otherwise nuts may not stick.
Candy Apple / Caramel Corn Stoves GAS MODEL SPECIAL INSTRUCTIONS When installing your new gas Candy Apple or Caramel Corn Stove, obey local codes or, in the absence of local codes, obey the National Fuel Gas Code, ANSI Z223.1-1992, or latest edition. Gas is safe when used properly, but dangerous when used improperly. We suggest that installation be made by qualified personnel only. Gas companies have competent service personnel to provide safe installation.
Candy Apple / Caramel Corn Stoves GAS PRESSURE We recommend 10 inches of water column (6 oz/sq in) for propane and 4 inches of water column (2 oz/sq in) for natural gas. The pressure is measured at the stove while the main burner is ignited. A pressure regulator is supplied to deliver optimum pressure for both types of gas when the stove is changed from the original factory specification. Be sure to use properly sized pipe to supply needed pressure. LIGHTING AND SHUT-DOWN INSTRUCTIONS 1. 2. 3. 4.
Candy Apple / Caramel Corn Stoves MAINTENANCE INSTRUCTIONS THE FOLLOWING SECTIONS OF THIS MANUAL ARE INTENDED ONLY FOR QUALIFIED SERVICE PERSONNEL WHO ARE FAMILIAR WITH ELECTRICAL EQUIPMENT. THESE ARE NOT INTENDED FOR THE OPERATOR. Adequate eye protection must be used when servicing this equipment to prevent the possibility of injury. Do NOT immerse the equipment in water. Unplug your machine before servicing. ORDERING SPARE PARTS 1.
Candy Apple / Caramel Corn Stoves ELECTRIC STOVE ASSEMBLY 6 ALL MODELS #2080, #2083, #4002 AND #4110
Candy Apple / Caramel Corn Stoves ELECTRIC STOVE ASSEMBLY TOP VIEW with KETTLE REMOVED 7 ALL MODELS #2080, #2083, #4002 AND #4110
Candy Apple / Caramel Corn Stoves PARTS LIST – ELECTRIC STOVES MODEL #4002 Item No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 Part No.
Candy Apple / Caramel Corn Stoves PARTS LIST - ELECTRIC STOVES (not shown) MODEL #2083 Part No.
Candy Apple / Caramel Corn Stoves ELECTRICAL SCHEMATIC 10 ALL MODELS #2080, #2083, #4002 AND #4110
Candy Apple / Caramel Corn Stoves GAS STOVE ASSEMBLY MODELS #2080BG & NG AND #4110BG & NG 11 ALL MODELS #2080, #2083, #4002 AND #4110
Candy Apple / Caramel Corn Stoves PARTS LIST - GAS STOVES Model #2080BG Model #2080NG Item No. Part No. Part No.
Candy Apple / Caramel Corn Stoves PARTS LIST - GAS STOVES Model #4110BG Model #4110NG Item No. Part No. Part No.
Candy Apple / Caramel Corn Stoves PARTS LIST - GAS STOVES (not shown) MODEL #2080BG For Parts Not Listed – See Model #2083 (Page 10) Part No. 27010 32013 32014 33003 33006 33008 33009 33010 33012 33014 33026 33027 46207 57030 57032 74027 74029 74115 74125 74575 Description ¼" OD Aluminum Tubing Close Nipple, 3/8" x 1" Coupling, 3 /8" NPT Leg, 17" Long Burner Gas Nipple Burner MT Nipple, 3/ 8" NPT x 7" Lg .
Candy Apple / Caramel Corn Stoves PARTS LIST - GAS STOVES (not shown) MODEL #2080NG For Parts Not Listed – See Model #2083 (Page 10) Part No. 27007 27010 32013 32014 33006 33008 33009 33010 33026 33027 46207 57030 57032 74027 74029 74115 Description Burner Jet Natural Gas ¼" OD Aluminum Tubing Close Nipple, 3/8" x 1" Coupling, 3 /8" NPT Burner Gas Nipple Burner MT Nipple, 3/ 8" NPT x 7" Lg.
Candy Apple / Caramel Corn Stoves OTHER ACCESSORIES Part No. 2091 46128 46625 46626 2082 32003 32010 33005 74133 Description Corn Baller - Parts Listing Corn Baller Finished Shoulder Screw Acorn Nut 3 /8-16 19" Aluminum Kettle - Parts Listing Carriage Bolt ¼-20 Handle Kettle Stove Candy Corn Kettle Hex Nut, ¼-20 CATALOG ITEMS Part No.
WARRANTY WE WARRANT to the original purchaser the Gold Medal equipment sold by us to be free from defects in material or workmanship under normal use and service.