USE AND CARE GUIDE P E R F O R M A N C E S E R I E S™ SIDE BURNERS THE POWER OF PERFORMANCE TM
TABLE OF CONTENTS Introduction Warnings i ii Safety Practices and Precautions 2-4 Gas Requirements (NAT/LP) 5-6 Leak Testing 7 Built-In Clearances 8 Replacing Regulators and Hose 9 Lighting Instructions 10 Care and Cleaning 11 Troubleshooting 12 Installer's Final Checklist 13 We're here for you 14 Wiring Diagram: Wiring Diagram—PSQSB2000 15 Warranty 16 Notes
capital cooking is your friend hello and welcome to Capital... We thank you for choosing our Performance Series™ cooking equipment. Because of the unique features found in our products, we recommend spending some time to familiarize yourself with this booklet before using your product. In it you will find valuable information on how to safely operate and maintain your appliance for years of enjoyable cooking.
WARNINGS! ii read this: This Appliance is FOR OUTDOOR USE ONLY! WARNING! If the information in this manual is not followed exactly, a fire or explosion may result, causing property damage, personal injury or death. Please read the installation, operating and maintenance instructions thoroughly before use. WARNING! Do not try lighting this appliance without reading the “Lighting Instructions” section in this manual.
BE SAFE! 2 WE HOPE YOU UNDERSTAND: Damage caused by a failure to heed warnings, follow basic safety instructions, or basic safety practices ARE NOT covered by the warranty. WARNING! When in use, portions of this appliance get hot enough to cause severe burns. Children and pets should never be left alone or unattended in an area where the appliance is being used. Never allow children to sit, stand, or play on or around the Grill or Side Burner at any time.
BE SAFE! 3 BE SURE all control knobs are in the OFF position and grill or side burner is cool prior to using any aerosol cleaner on or around it. The chemical that produces the spraying action could, in the presence of heat, ignite or cause metal parts to corrode. ALWAYS use dry potholders: moist or damp potholders on hot surfaces may cause steam burns. Do not use a towel or bulky cloth in place of potholders. DO NOT let potholders touch hot portions of the Side Burner grate or burner.
BE SAFE! 4 WARNING!: Keep the area surrounding the grill free from combustible materials, trash, or combustible fluids and vapors such as gasoline or charcoal lighter fluid. DO NOT obstruct the flow of combustion and ventilation air. WARNING!: NEVER use the grill in windy conditions. If located in a consistently windy area (oceanfront, mountaintop, etc.) a windbreak will be required. Always adhere to specific clearances listed. IMPORTANT: Never use a dented or rusty LP tank.
natural gas requirements: 5 Verify the type of gas to be used, either LP (propane), or Natural gas, and make sure the marking on the appliance rating plate agrees with that of the supply. The rating plate is located on the outside back wall of NEVER connect an unregulated gas line to the appliance! the grill. An installer supplied gas shut-off valve must be installed in an easily accessible location.
lp gas requirements: 7 6 LP GAS HOOK UP (TYPE 1 OR QCC1 REGULATOR) Side Burners orificed for use with LP gas come equipped with a high capacity hose/regulator assembly for connection to a standard 20lb. LP cylinder (Type 1). The LP tank is not included. Connection: 1/2” NPT male with a 3/8” Flare adapter (included). LP hose with a quick disconnect and fittings are included. Operating Pressure: 10.0” W.C.
leak testing: 78 7 GENERAL: Although all gas connections on the PSQSB2000 Side Burner are leak tested at the factory prior to shipment, a complete gas tightness check must be performed at the installation site due to possible mishandling in shipment, or excessive pressure unknowingly being applied to the unit. Periodically check the whole system for leaks, or immediately check if the smell of gas is detected. BEFORE TESTING: Do not smoke while leak testing. Extinguish all open flames.
built in clearances: GENERAL: The PSQSB2000 Side Burner is designed for easy placement into non-combustible masonry enclosures. For non-combustible applications the grill drops into the opening and hangs from its side flanges. A deck is not required to support it from the bottom. Please review the detail drawing shown and take into account the provisions shown for gas line hook-up clearances in the right rear corner.
replacing hose & regulator: 7 9 WARNING! Before lighting, inspect the gas supply piping or hose prior to turning the gas “ON”. If there is evidence of cuts, wear, or abrasion, it must be replaced prior to use. REPLACEMENT OF REGULATORS AND HOSE: The pressure regulator and hose assembly supplied with the unit must be used. The replacement pressure regulators and hose assembly must be the type specified by the manufacturer. Do not use the grill or side burner if the odor of gas is present.
lighting instructions: WARNING: Keep hands and face away from front of burner! STAND TO THE SIDE WHEN LIGHTING. ONCE LIT MOVE HAND AWAY QUICKLY! 13 7 10 Lighting The Side Burner: Note: Open the side burner lid and/or remove the top grate cover before lighting. Turn all knobs to “OFF.” Turn the main gas supply on. If you smell gas, shut-off gas-supply and call for service. Push and hold the ignition button and turn the selected burner knob to “HIGH.
caring for your side burner: 7 11 Side Burner Cleaning: BEFORE REMOVING: ensure the gas supply is turned off and the knobs are in the “OFF” position. Make sure the grill is cool. Remove the top grate. Lift and remove the burner caps and clean sealed pan with a mild soap and warm water cleaner. Clean burner base with a soap and warm water solution. Burner ports may be cleaned with a straightened paperclip.
troubleshooting: 12 Before Calling For Service: If your PSQSB2000 Side Burner does not function properly, use the following checklist before contacting your dealer for service. You may save the cost of a service call. Troubleshooting is for general purposes only. If the problem persists and you feel you require a service call, contact your dealer or the nearest authorized service agency to perform service. Only factory authorized service agencies can perform warranty service.
final checklist: 13 installer: initial beside each item INSTALLER FINAL CHECKLIST: Specified Clearances Maintained Side Burner Grates in Place User Informed of Gas Supply Shut-Off Location Nylon Straps Removed from Burners Pressure Regulator Connected and Set for 4.0" W.C. Natural or 10" W.C.
we're here for you: 14 HOW TO OBTAIN SERVICE: For service, contact one of our PERFORMANCE SERIES SPECIALISTS at 1-866-402-4600. Before you call, please have the following information ready: • Model Number • Serial Number • Date of purchase and Installation • A brief description of the problem • Dealer name Your satisfaction is of the utmost importance to us.
PERFORMANCE SERIES SIDE BURNERS WARRANTY • One (1) Year full parts and labor covers entire product. • Five (5) Year comprehensive warranty covering the porcelain coated cast iron range-top burners and porcelain enameled cast iron top grate. Should structural deterioration occur to the degree of non-performance, a replacement will be furnished. • Limited Lifetime Warranty against rust on all stainless steel components (excludes normal heat discoloration).
