MSDS

ManualsBrandsCarlon ManualsAdhesivesQuart Low Voc Cement W/dauber 31388

SAFETY DATA SHEET

Carlon Low-VOC Solvent Cement for PVC Plastic Pipe

SDS-00060

VC9965C, VC9964, VC9963, VC9963C, VC9962, VC9961P, VC9924-24, VC9924, VC9923,

VC9922, VC9941P, VC9LV4, VC9LV4-24, VC9LV4L-24, VC9LV3L-12, VC9LV2, VC9LV3

Low-VOC solvent cement for PVC plastic pipe

None known.

1. Identification

Product identifier

Other means of identification

SDS number

Product code

Manufacturer/Importer/Supplier/Distributor information

Category 2

Category 4

2. Hazard(s) identification

Physical hazards

Health hazards

Category 4

Category 2

Flammable liquids

Acute toxicity, oral

Acute toxicity, inhalation

Skin corrosion/irritation

Category 2ASerious eye damage/eye irritation

Category 2Carcinogenicity

Category 3 respiratory tract irritationSpecific target organ toxicity, single exposure

Not classified.

OSHA defined hazards

Label elements

Signal word

Danger

Hazard statement

Highly flammable liquid and vapor. Harmful if swallowed. Causes serious eye irritation. Causes

skin irritation. Harmful if inhaled. May cause respiratory irritation. Suspected of causing cancer.

Precautionary statement

Prevention

Obtain special instructions before use. Do not handle until all safety precautions have been read

and understood. Keep away from heat/sparks/open flames/hot surfaces. - No smoking. Keep

container tightly closed. Ground/bond container and receiving equipment. Use explosion-proof

electrical/ventilating/lighting equipment. Use only non-sparking tools. Take precautionary

measures against static discharge. Avoid breathing mist or vapor. Wash thoroughly after

handling. Do not eat, drink or smoke when using this product. Use only outdoors or in a

well-ventilated area. Wear protective gloves/protective clothing/eye protection/face protection.

Response

If swallowed: Call a poison center/doctor if you feel unwell. Rinse mouth. If on skin (or hair): Take

off immediately all contaminated clothing. Rinse skin with water/shower. If inhaled: Remove

person to fresh air and keep comfortable for breathing. If in eyes: Rinse cautiously with water for

several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. Immediately

call a poison center/doctor. If skin irritation occurs: Get medical advice/attention. Take off

contaminated clothing and wash before reuse. In case of fire: Use alcohol-resistant foam, carbon

dioxide, dry powder or water fog for extinction.

SDS USCarlon Low-VOC Solvent Cement for PVC Plastic Pipe

933443 Revision: 0 Revision date: - Issue date: 06-May-2016

1 / 10

Company name

Address

Telephone

E-mail

Emergency phone number

Thomas & Betts Corporation

8155 T & B Boulevard

Memphis, TN 38125

901-252-5000 ext.8324

Not available.

For Hazardous Materials [or Dangerous Goods] Incident

Spill, Leak, Fire, Exposure, or Accident

Call CHEMTREC Day or Night

+1 703-741-5970

Recommended use

Recommended restrictions

Summary of content (10 pages)

PAGE 1
SAFETY DATA SHEET 1. Identification Product identifier Carlon Low-VOC Solvent Cement for PVC Plastic Pipe Other means of identification SDS number Product code Recommended use SDS-00060 VC9965C, VC9964, VC9963, VC9963C, VC9962, VC9961P, VC9924-24, VC9924, VC9923, VC9922, VC9941P, VC9LV4, VC9LV4-24, VC9LV4L-24, VC9LV3L-12, VC9LV2, VC9LV3 Low-VOC solvent cement for PVC plastic pipe None known.
PAGE 2
Storage Store in a well-ventilated place. Keep container tightly closed. Store in a well-ventilated place. Keep cool. Store locked up. Disposal Dispose of contents/container in accordance with local/regional/national/international regulations. Hazard(s) not otherwise classified (HNOC) None known. Supplemental information None. 3.
PAGE 3
6. Accidental release measures Personal precautions, protective equipment and emergency procedures Methods and materials for containment and cleaning up Keep unnecessary personnel away. Keep people away from and upwind of spill/leak. Eliminate all ignition sources (no smoking, flares, sparks, or flames in immediate area). Wear appropriate protective equipment and clothing during clean-up. Avoid inhalation of vapors and spray mists.
PAGE 4
US. OSHA Table Z-1 Limits for Air Contaminants (29 CFR 1910.1000) Components Type Value Form Ethene, chloro-, homopolymer, Polyvinyl chloride; PVC; (CAS 9002-86-2) PEL 5 mg/m3 Respirable fraction. PEL 15 mg/m3 590 mg/m3 Total dust. Furan, Tetrahydro- (CAS 109-99-9) 200 ppm US. OSHA Table Z-3 (29 CFR 1910.1000) Components Type Value Form Ethene, chloro-, homopolymer, Polyvinyl chloride; PVC; (CAS 9002-86-2) TWA 5 mg/m3 Respirable fraction. 15 mg/m3 50 mppcf 15 mppcf Total dust.
PAGE 5
Biological limit values ACGIH Biological Exposure Indices Components Value Determinant 2-Butanone (Methyl ethyl ketone) (CAS 78-93-3) Acetone (CAS 67-64-1) Cyclohexanone (CAS 108-94-1) 2 mg/l MEK 50 mg/l 80 mg/l Acetone 1,2-Cyclohexan ediol, with hydrolysis 8 mg/l Cyclohexanol, with hydrolysis Furan, Tetrahydro- (CAS 2 mg/l Tetrahydrofura n 109-99-9) * - For sampling details, please see the source document.
PAGE 6
Initial boiling point and boiling range 56 °C Flash point - 20 °C Evaporation rate > 1.0 (Butyl acetate = 1) Flammability (solid, gas) Not applicable. Upper/lower flammability or explosive limits Not available. Flammability limit - lower (%) Flammability limit - upper (%) Not available. Explosive limit - lower (%) 1.8 % Explosive limit - upper (%) 12.8 % Vapor pressure 190 mm Hg @ 20 °C Vapor density 2.5 (Air = 1) Relative density 0.
PAGE 7
Components Species Test Results Acute Dermal LD50 Rabbit 20 ml/kg Inhalation LC50 Rat 76 mg/l, 4 Hours Acetone (CAS 67-64-1) 50.1 mg/l, 8 Hours Cyclohexanone (CAS 108-94-1) Acute Dermal LD50 Rabbit 948 mg/kg Inhalation LC50 Rat 8000 ppm, 4 hours Oral LD50 Rat 800 mg/kg Skin corrosion/irritation Causes skin irritation. Serious eye damage/eye irritation Causes serious eye irritation. Respiratory or skin sensitization Not a respiratory sensitizer.
PAGE 8
Bioaccumulative potential Partition coefficient n-octanol / water (log Kow) 2-Butanone (Methyl ethyl ketone) (CAS 78-93-3) 0.29 Acetone (CAS 67-64-1) -0.24 Cyclohexanone (CAS 108-94-1) 0.81 Furan, Tetrahydro- (CAS 109-99-9) 0.46 The product is partly soluble in water. Mobility in soil Other adverse effects No other adverse environmental effects (e.g. ozone depletion, photochemical ozone creation potential, endocrine disruption, global warming potential) are expected from this component. 13.
PAGE 9
Transport in bulk according to Annex II of MARPOL 73/78 and the IBC Code Not established. 15. Regulatory information US federal regulations This product is a "Hazardous Chemical" as defined by the OSHA Hazard Communication Standard, 29 CFR 1910.1200. TSCA Section 12(b) Export Notification (40 CFR 707, Subpt. D) Not regulated. OSHA Specifically Regulated Substances (29 CFR 1910.
PAGE 10
US. New Jersey Worker and Community Right-to-Know Act 2-Butanone (Methyl ethyl ketone) (CAS 78-93-3) Acetone (CAS 67-64-1) Cyclohexanone (CAS 108-94-1) Ethene, chloro-, homopolymer, Polyvinyl chloride; PVC; (CAS 9002-86-2) Furan, Tetrahydro- (CAS 109-99-9) US. Pennsylvania Worker and Community Right-to-Know Law 2-Butanone (Methyl ethyl ketone) (CAS 78-93-3) Acetone (CAS 67-64-1) Cyclohexanone (CAS 108-94-1) Furan, Tetrahydro- (CAS 109-99-9) US.