Induced Combustion Gas Furnace TERR _ turn to the exports ly Owner’s Manual NOTE TO INSTALLER: THIS MANUAL MUST BE LEFT WITH THE EQUIPMENT USER. USER: Please read all instructions in the manual and retain all manuals for future reference. 1509001300 Always Ask For A WARNING FIRE GR EXPLOSION HAZARD Failure to follow safety war or property damage. cold result in injury, death, Do not store or use gasoline or other flammable vapors and figures un the vicinity of this ar any other appliance.
WELCOME TO TODAY'S GENERATION OF COMFORT Congratulations! Your new. higher efficiency gas furnace is a sound. investment which will reward you and your family with years of warm monies winter after winter. Rot only is your new fum ace energy efficient, it is aso extremely reliable. Spend just a few minutes with this booklet io learn about the operation of your new fumace—and the small amount of maintenance if fakes to keep it operating at peak efficiency. Years went info the development of your new furnace.
IMPORTANT FACTS (DO'S AND DON'TS) + D0: READ AND UNDERSTAND THIS MANUAL Have your fum ace and vent system inspected annually by a died service technician, « DO: Inspect your filter monthly and clean of replace when needed. * DO: Provide adequate airflow 10 the furnace for efficient combustion und safe ventilation, » Keep D Some materials ma when the furnace is fn DO NOT: Enclose your fum ace in an airtight room or seal it our furnace free and clear of insulating material be combustible.
STARTING YOUR FURNACE Your pumice wises an automatic, hot surface ignition system to fight the boomers each time the thermostat signals the furnace © start. Follow these important safeguard = Never attempt to manually light the burners with a match or other source of flame. 492919 Fig. 3 Do Not Light Burner with Match + Read and follow the operating instructions on inside of main furnace door, especially the tent that reads as fol Tow ait 3 wines fo clear owt any gas, Then smell for gis. ear the oor.
#02287 Fig, 9 Control Switch to ON 8, Replace the outer door, Avenue Fig. 10 furnace Door Replaced 9. Turn ON the electrical supply to the fum ace. Fig. 11 Turn On Electrical Supply 10. Open the external minimal gas valve. Aimee Fig. 12 = Open Valve 11, $et the room thermostat 10 a temperate sightly above ihe room temperature. This will automatically signal the far mace fo start. The inducer motor wilt start and the hot surface ignite will energize. When hot, the ignite wife have an orange glow. 12.
PERFORMING ROUTINE MAINTENANCE With proper maintenance and care, vow furnace will operate economically and dependably. Instructions for basic maintenance are found on this and the following pages. However, before beginning maintenance. follow these safety precaution 4A WARNING ELECTRICAL SHOCK HAZARD Failure to follow this warning could result in personal injury or death. Turn off elects removing the maintenance. PLE OEN TEN LO CUT HAZARD Faille to follow this caution nay result fn personal injury.
#00207 Fig. 16 Slide Side Filter Out of Pursuance #0802 2. 18 Replace Side Filter Cabinet Door Ouzos Fig. 17 Slide Bottom Filter Out of Furnace 4. Inspect the filter. If torn, replace it, NOT Tf a washable filter has been replaced with: a. Factory specified disposable median filer — Da not clean, If dirty, replace nly with media filter having the same part burner and size. In stat! with airflow direction row pointing towards blower. b.
COMBUSTION AREA AND) VENT SYSTEM A WARNING TT OPERATION HAZARD Failure to follow this warning could result in personal injury or death. For proper and safe operation the furnace needs air for combustion and ventilation. Do not block or obstruct air openings on the famine, aif opening fo the area in which the furnace is installed, and the space around the furn 4A WARNING CARBON MONOXIDE POISONING HAZARD Failure to fallow this waning could result itr personal injury of death.
It addition to the 15) extradited service tech minimum, c of routine maintenance you might be wolfing to perform. your furnace should be specified regularly by a properly fon. You should work with your dealer or service technician 1 lassie our inspection includes the following af a MAINTENANCE CHECKLIST INSPECTION INTERVAL DESCRIPTION Monthly Semiannually Annually Furnace specific, external items: Clean or replace ai fillers. X inspect cabinet for signs of damage. X Inspect and clean dour louvers if needed.
NOTE TO EQUIPMENT OWNER: For your convenience, please record the model and serial numbers of your new equipment in the spaces provided. This information, along with the installation data and dealer contact information will be helpful should your system require maintenance or service.