Manual

ManualsBrandsCarter-Hoffmann ManualsKitchenCD27

Cleaning, Operating, Maintenance Instructions, Parts List & Warranty

Enclosed Rotary Dish Cart

Model CD27

Cleaning Instructions

NOTE:

This equipment has been designed and

manufactured to meet all applicable

health and safety codes and will give

years of dependable service if used

properly. All cabinets should be thor-

oughly cleaned before using.

Cleansers, detergents,

degreasers, sanitizers

or bleaching agents

that contain chlorides

or phosphates will

cause permanent damage to stainless

steel products. The damage appears as

pits, eruptions, voids, small holes,

cracks, severe discoloration, or dulling

of the metal finish. Water with high

chloride content can also damage

stainless steel. If you are uncertain of

your water quality, we recommend you

have it tested. THIS DAMAGE IS

PERMANENT, COSTLY TO

REPAIR, AND IS NOT COVERED

BY THE WARRANTY.

Be sure the cabinet is unplugged and cool before cleaning. The

heater components should not be exposed to direct contact with

water or cleaning sprays. Permanent damage to the electrical

components will result. THIS DAMAGE IS PERMANENT,

COSTLY TO REPAIR, AND IS NOT COVERED BY THE

WARRANTY.

1. To clean stainless steel surfaces use only cleansers, detergents,

degreasers, or sanitizers that are certified to be chloride-free and phos-

phate-free, and cleansers, or sanitizers only in the recommended con-

centrations. DO NOT exceed recommended concentrations or mixing

ratios. After cleaning and sanitizing, rinse all exposed surfaces thorough-

ly with large amounts of clear water. With a clean cloth, wipe off any

standing liquid or residue from all horizontal surfaces, in corners, or near

edges.

2. If applicable, vinyl trim or laminate should be washed with a chlorine-free

detergent and water. Rinse thoroughly with clear water and allow to dry.

Never use abrasive cleaners, waxes, car polish or substances containing

strong aromatic solvents or alcohol. Caution: When using solvents, it is

essential that proper precautionary measures be observed. Refer to

solvent manufacturer’s instructions. Use of direct steam and/or hot

water cleaning at temperatures above 190

F may result in “bubbling” or

loosening of the vinyl adhesive.

RECOMMENDED TIPS FOR CLEANING STAINLESS STEEL

Purpose Frequency Cleaning Agent Method of Application

Routine Daily Soap, ammonia detergent Sponge with cloth, rinse with clear water and wipe dry.

cleaning and water

Smears/ As Needed Stainless steel cleaner Rub with cloth as directed on package. Rub in direction of grain

finger prints or similar products of stainless steel. Do not use on vinyl trim or adhesive labels.

Stubborn Daily Any chloride-free Apply with damp sponge or cloth. Rub in direction of polish

spots and As Needed or phosphate-free lines. Rinse thoroughly after use, especially if cleaner contains

stains cleaner chlorine bleach. Do not use on vinyl trim or adhesive labels.

Hard water Daily Vinegar Swab with cloth. Rinse with water and wipe dry.

spots As Needed

DO NOT use steel

wool pads - ferrous

deposits will cause

rusting.

CAUTION

WARNING

Summary of content (4 pages)

PAGE 1
Cleaning, Operating, Maintenance Instructions, Parts List & Warranty Enclosed Rotary Dish Cart Model CD27 NOTE: This equipment has been designed and manufactured to meet all applicable health and safety codes and will give years of dependable service if used properly. All cabinets should be thoroughly cleaned before using.
PAGE 2
Electrical Requirements Operates on 120 volt, 60 Hz, 1 PH, 2100 watts, 18 amps, 6 foot power cord with NEMA 5-20P plug. Installation The CD27 has been designed for warming and holding 9” diameter bowls. 1. Remove the cabinet from its shipping carton, making sure that all packing materials are removed from the cabinet. 2. Check to ensure that all separate components are present and removed from the packaging: -Equipment Manual 3.
PAGE 3
Maintenance Instructions A CASTERS Casters are equipped with Zerk grease fittings so that they may be easily lubricated with a grease gun. Recommended lubrication is at least once every six months. Lubrication will be required more often if cart is cleaned with a hot water or steam cleaning system. Casters with special bearings are recommended for frequent cart wash or steam cleaning situations. B LATCH Check frequently to insure that the door latch is secure.
PAGE 4
Carter-Hoffmann Corporation Warranty: Carter-Hoffmann Corporation (“CARTER-HOFFMANN”) warrants to the initial purchaser of its Carter Line Products that CARTER-HOFFMANN will, at its option, repair or replace, during the warranty period set forth below, any part of such products made necessary due to a defect in material or workmanship which is present when the product leaves its factory and which manifests itself during the warranty period under normal use and service.