Owner's Manual

ManualsBrandsCarvin ManualsAudioCarvin C1644

CAUTION

RISK OF ELECTRIC SHOCK

DO NOT OPEN

SAFETY INSTRUCTIONS (EUROPEAN)

The conductors in the AC power cord are colored in accordance with the following code.

GREEN & YELLOW—Earth BLUE—Neutral BROWN—Live

U.K. MAIN PLUG WARNING: A molded main plug that has been cut off from the cord is unsafe. NEVER

UNDER ANY CIRCUMSTANCES SHOULD YOU INSERT A DAMAGED OR CUT MAIN PLUG INTO A POWER SOCKET.

IMPORTANT! FOR YOUR PROTECTION, PLEASE READ THE FOLLOWING:

WATER AND MOISTURE: Appliance should not be used near water (near a bathtub, washbowl, kitchen

sink, laundry tub, in a wet basement, or near a swimming pool, etc). Care should be taken so that

objects do not fall and liquids are not spilled into the enclosure through openings.

POWER SOURCES: The appliance should be connected to a power supply only of the type described

in the operating instructions or as marked on the appliance.

GROUNDING OR POLARIZATION: Precautions should be taken so that the grounding or polariza-

tion means of an appliance is not defeated.

POWER CORD PROTECTION: Power supply cords should be routed so that they are not likely to

be walked on or pinched by items placed upon or against them, paying particular attention to cords

at plugs, convenience receptacles, and the point where they exit from the appliance.

SERVICING: The user should not attempt to service the appliance beyond that described in the

operating instructions. All other servicing should be referred to qualified service personnel.

FUSING: If your unit is equipped with a fuse receptacle, replace only with the same type fuse. Refer

to replacement text on the unit for correct fuse type.

REFER SERVICING TO QUALIFIED SERVICE PERSONNEL!

REF. Carvin P/N Description

Channel PCB Rev (C) 30-08248

A1 60-20430 Op Amp NJM2043D Linear Dual

A2 60-45580 Op Amp MC4558 CP1 Dual HFREQ

A3 60-45580 Op Amp MC4558 CP1 Dual HFREQ

A4 60-45580 Op Amp MC4558 CP1 Dual HFREQ

A5 60-20430 Op Amp NJM2043D Linear Dual

B1 50-00035 Jumper .35" 0.0Ω

B2 50-00035 Jumper .35" 0.0Ω

B3 50-00035 Jumper .35" 0.0Ω

B4 50-00035 Jumper .35" 0.0Ω

B5 50-00035 Jumper .35" 0.0Ω

B10 50-47005 1/4W Resistor 4.7K 5% Carbon

B12 50-00035 Jumper .35" 0.0Ω

B13 50-00035 Jumper .35" 0.0Ω

B14 50-00035 Jumper .35" 0.0Ω

B15 50-00035 Jumper .35" 0.0Ω

B16 50-00035 Jumper .35" 0.0Ω

B17 50-00035 Jumper .35" 0.0Ω

B18 50-00035 Jumper .35" 0.0Ω

B21 50-00035 Jumper .35" 0.0Ω

B22 50-00035 Jumper .35" 0.0Ω

B23 50-00035 Jumper .35" 0.0Ω

B24 50-00035 Jumper .35" 0.0Ω

B31 50-00035 Jumper .35" 0.0Ω

B32 50-00035 Jumper .35" 0.0Ω

B33 50-00035 Jumper .35" 0.0Ω

B34 50-00035 Jumper .35" 0.0Ω

B41 50-00035 Jumper .35" 0.0Ω

B42 50-00035 Jumper .35" 0.0Ω

B43 50-00035 Jumper .35" 0.0Ω

B44 50-00035 Jumper .35" 0.0Ω

B51 50-00035 Jumper .35" 0.0Ω

B52 50-00035 Jumper .35" 0.0Ω

B53 50-00035 Jumper .35" 0.0Ω

B54 50-00035 Jumper .35" 0.0Ω

B55 50-00035 Jumper .35" 0.0Ω

B61 50-00035 Jumper .35" 0.0Ω

B62 50-00035 Jumper .35" 0.0Ω

B63 50-00035 Jumper .35" 0.0Ω

B64 50-00035 Jumper .35" 0.0Ω

B71 50-00035 Jumper .35" 0.0Ω

B72 50-00035 Jumper .35" 0.0Ω

B73 50-00035 Jumper .35" 0.0Ω

B74 50-00035 Jumper .35" 0.0Ω

B81 50-00035 Jumper .35" 0.0Ω

B82 50-00035 Jumper .35" 0.0Ω

B83 50-00035 Jumper .35" 0.0Ω

B84 50-00035 Jumper .35" 0.0Ω

C1 45-39052 Capacitor 39PF 500 Volt Ceramic 5%

C2 45-39052 Capacitor 39PF 500 Volt Ceramic 5%

C3 47-22051 Capacitor 22µF 50V Electrolytic 20%

C4 47-22051 Capacitor 22µF 50V Electrolytic 20%

C5 46-47312 Capacitor 0.047µF 100V Poly 10%

C6 47-22051 Capacitor 22µF 50V Electrolytic 20%

C7 45-39052 Capacitor 39PF 500 Volt Ceramic 5%

C8 46-47312 Capacitor 0.047µF 100V Poly 10%

C9 46-33312 Capacitor 0.033µF 100V Poly 10%

C10 47-22051 Capacitor 22µF 50V Electrolytic 20%

C11 45-39052 Capacitor 39PF 500 Volt Ceramic 5%

C12 45-39052 Capacitor 39PF 500 Volt Ceramic 5%

C13 47-22051 Capacitor 22µF 50V Electrolytic 20%

C14 47-22051 Capacitor 22µF 50V Electrolytic 20%

C15 47-22051 Capacitor 22µF 50V Electrolytic 20%

C16 46-10312 Capacitor 0.01µF 100V Poly 10%

C17 47-22051 Capacitor 22µF 50V Electrolytic 20%

C18 47-47116 Capacitor 470µF 16V Electrolytic 20%

C19 47-47116 Capacitor 470µF 16V Electrolytic 20%

C20 45-39052 Capacitor 39PF 500 Volt Ceramic 5%

C21 45-56152 Capacitor 560PF 500V Ceramic 10%

C22 45-56152 Capacitor 560PF 500V Ceramic 10%

C23 46-33212 Capacitor 0.0033µF 100V Poly 10%

C24 47-22051 Capacitor 22µF 50V Electrolytic 20%

D1 60-75330 LED Green small #204GD 3mm T-1.0

D2 60-75320 LED Red small #204HD 3mm T-1.0

D10 60-75320 LED Red small #204HD 3mm T-1.0

H1 23-11008 Header 8 Pin Vert SHS 2.5mm

H2 23-11008 Header 8 Pin Vert SHS 2.5mm

H3 23-11008 Header 8 Pin Vert SHS 2.5mm

H11 23-11008 Header 8 Pin Vert SHS 2.5mm

H12 23-11008 Header 8 Pin Vert SHS 2.5mm

H13 23-11008 Header 8 Pin Vert SHS 2.5mm

J1 21-50545 Phone Jack 1/4" 5 pin H= 24mm

J2 21-40000 XLR Jack Female Vert

J3 21-50545 Phone Jack 1/4" 5 pin H= 24mm

P1 71-09253 Potentiometer B50K Vert D Shaft 9 25F

P2 71-09252 Potentiometer B50K C-C D Shaft 9 25F

P3 71-09252 Potentiometer B50K C-C D Shaft 9 25F

P4 71-09252 Potentiometer B50K C-C D Shaft 9 25F

P5 71-09253 Potentiometer B50K D Shaft 9 25F

P6 71-09253 Potentiometer B50K Vert D Shaft 9 25F

P7 71-09253 Potentiometer B50K Vert D Shaft 9 25F

P8 71-09253 Potentiometer B50K Vert D Shaft 9 25F

P9 72-13169 Potentiometer B50Kx2 C-C D 14 25F

P10 71-15065 Fader 25A50K 60mm HT= .215mm

R1 50-56231 1/4W Resistor 5.62 1% Metal

R2 59-10040 1/8W Resistor 10K x4 SIP 2% Carbon

R3 50-10045 1/4W Resistor 10K 5% Carbon

R4 50-15031 1/4W Resistor 1.51K 1% Metal

R5 50-15031 1/4W Resistor 1.51K 1% Metal

R6 50-22131 1/4W Resistor 2.21K 1% Metal

R7 59-10040 1/8W Resistor 10K x4 SIP 2% Carbon

R8 50-47025 1/4W Resistor 470Ω 5% Carbon

R9 50-68045 1/4W Resistor 68K 5% Carbon

R10 59-10040 1/8W Resistor 10K x4 SIP 2% Carbon

R11 50-10045 1/4W Resistor 10K 5% Carbon

R12 50-10045 1/4W Resistor 10K 5% Carbon

R13 50-22035 1/4W Resistor 2.2K 5% Carbon

R14 50-10025 1/4W Resistor 100Ω 5% Carbon

R15 50-12045 1/4W Resistor 12K 5% Carbon

R16 50-10035 1/4W Resistor 1K 5% Carbon

R17 50-22131 1/4W Resistor 2.21K 1% Metal

R18 50-10025 1/4W Resistor 100Ω 5% Carbon

R19 50-47045 1/4W Resistor 47K 5% Carbon

R20 50-10045 1/4W Resistor 10K 5% Carbon

R21 50-47005 1/4W Resistor 4.7K 5% Carbon

R22 50-10055 1/4W Resistor 100K 5% Carbon

R23 50-56231 1/4W Resistor 5.62 1% Metal

R24 50-47045 1/4W Resistor 47K 5% Carbon

R25 50-47005 1/4W Resistor 4.7K 5% Carbon

R26 50-10025 1/4W Resistor 100Ω 5% Carbon

R27 50-33035 1/4W Resistor 3.3K 5% Carbon

R28 50-47045 1/4W Resistor 47K 5% Carbon

R29 50-33035 1/4W Resistor 3.3K 5% Carbon

R30 50-10045 1/4W Resistor 10K 5% Carbon

R31 50-22045 1/4W Resistor 22K 5% Carbon

R32 50-18045 1/4W Resistor 18K 5% Carbon

R33 50-68035 1/4W Resistor 68K 5% Carbon

R34 50-56035 1/4W Resistor 5.6K 5% Carbon

R35 50-10045 1/4W Resistor 10K 5% Carbon

R36 50-10055 1/4W Resistor 100K 5% Carbon

R37 50-56035 1/4W Resistor 5.6K 5% Carbon

R38 50-47055 1/4W Resistor 470K 5% Carbon

R43 50-56035 1/4W Resistor 5.6K 5% Carbon

R47 50-00035 Jumper .35" 0.0Ω

R100 50-22035 1/4W Resistor 2.2K 5% Carbon

R247 50-00035 Jumper .35" 0.0Ω

R347 50-00035 Jumper .35" 0.0Ω

R447 50-00035 Jumper .35" 0.0Ω

R547 50-00035 Jumper .35" 0.0Ω

R647 50-00035 Jumper .35" 0.0Ω

R747 50-00035 Jumper .35" 0.0Ω

R847 50-00035 Jumper .35" 0.0Ω

S1 25-02201 Switch DPDT Push Vert

S2 25-02201 Switch DPDT Push Vert

S5 25-02201 Switch DPDT Push Vert

S6 25-02201 Switch DPDT Push Vert

S10 25-02201 Switch DPDT Push Vert

Z1 61-04734 Diode Zener 5.6V 1N4734A 1W

System Master PCB Rev (C) 30-16214

A1 60-20430 Op Amp NJM2043D Linear Dual

A10 60-45580 Op Amp MC4560 CP1 Dual HFREQ

A11 60-45580 Op Amp MC4560 CP1 Dual HFREQ

A12 60-45580 Op Amp MC4560 CP1 Dual HFREQ

A13 60-20430 Op Amp NJM2043D Linear Dual

A14 60-20430 Op Amp NJM2043D Linear Dual

A15 60-45580 Op Amp MC4560 CP1 Dual HFREQ

A16 60-45580 Op Amp MC4560 CP1 Dual HFREQ

A19 60-20430 Op Amp NJM2043D Linear Dual

A2 60-20430 Op Amp NJM2043D Linear Dual

A20 60-45580 Op Amp MC4560 CP1 Dual HFREQ

A21 60-45580 Op Amp MC4560 CP1 Dual HFREQ

A22 60-45580 Op Amp MC4560 CP1 Dual HFREQ

A23 60-20430 Op Amp NJM2043D Linear Dual

A24 60-20430 Op Amp NJM2043D Linear Dual

A25 60-45580 Op Amp MC4560 CP1 Dual HFREQ

A26 60-45580 Op Amp MC4560 CP1 Dual HFREQ

A28 60-45580 Op Amp MC4560 CP1 Dual HFREQ

A29 60-20430 Op Amp NJM2043D Linear Dual

A3 60-20430 Op Amp NJM2043D Linear Dual

A30 60-45580 Op Amp MC4560 CP1 Dual HFREQ

A31 60-20430 Op Amp NJM2043D Linear Dual

A32 60-20430 Op Amp NJM2043D Linear Dual

A33 60-20430 Op Amp NJM2043D Linear Dual

A35 60-45580 Op Amp MC4560 CP1 Dual HFREQ

A36 60-20430 Op Amp NJM2043D Linear Dual

A4 60-20430 Op Amp NJM2043D Linear Dual

A41 60-29010 IC DIP 14 Comparitor x4 OC

A42 60-29010 IC DIP 14 Comparitor x4 OC

A43 60-29010 IC DIP 14 Comparitor x4 OC

A44 60-29010 IC DIP 14 Comparitor x4 OC

A45 60-29010 IC DIP 14 Comparitor x4 OC

A5 60-20430 Op Amp NJM2043D Linear Dual

A6 60-45580 Op Amp MC4560 CP1 Dual HFREQ

A7 60-45580 Op Amp MC4560 CP1 Dual HFREQ

A8 60-29010 IC DIP 14 Comparitor x4 OC

C1 45-39052 Capacitor 39PF 500V Ceramic 5%

C10 47-22051 Capacitor 22µF 50V Electrolytic 20%

C100 45-39052 Capacitor 39PF 500V Ceramic 5%

C101 45-39052 Capacitor 39PF 500V Ceramic 5%

C103 47-10061 Capacitor 10µF 63V Electrolytic 20%

C104 47-10061 Capacitor 10µF 63V Electrolytic 20%

C105 48-01031 Capacitor 1µF 35V Tant 10%

C11 45-39052 Capacitor 39PF 500V Ceramic 5%

C116 47-10061 Capacitor 10µF 63V Electrolytic 20%

C118 47-10061 Capacitor 10µF 63V Electrolytic 20%

C119 45-39052 Capacitor 39PF 500V Ceramic 5%

C12 47-10061 Capacitor 10µF 63V Electrolytic 20%

C120 45-39052 Capacitor 39PF 500V Ceramic 5%

C122 47-10061 Capacitor 10µF 63V Electrolytic 20%

C124 47-10061 Capacitor 10µF 63V Electrolytic 20%

C125 45-39052 Capacitor 39PF 500V Ceramic 5%

C126 45-39052 Capacitor 39PF 500V Ceramic 5%

C13 47-22051 Capacitor 22µF 50V Electrolytic 20%

C14 47-22051 Capacitor 22µF 50V Electrolytic 20%

C15 47-10061 Capacitor 10µF 63V Electrolytic 20%

C158 47-10061 Capacitor 10µF 63V Electrolytic 20%

C159 47-10061 Capacitor 10µF 63V Electrolytic 20%

C16 45-39052 Capacitor 39PF 500V Ceramic 5%

C168 45-39052 Capacitor 39PF 500V Ceramic 5%

C169 47-10061 Capacitor 10µF 63V Electrolytic 20%

C17 45-39052 Capacitor 39PF 500V Ceramic 5%

C170 47-10061 Capacitor 10µF 63V Electrolytic 20%

C18 45-39052 Capacitor 39PF 500V Ceramic 5%

C19 46-47312 Capacitor 0.047µF 100V Poly 10%

C2 45-39052 Capacitor 39PF 500V Ceramic 5%

C20 45-82052 Capacitor 82PF 500V Ceramic 5%

C203 47-10061 Capacitor 10µF 63V Electrolytic 20%

C21 45-39052 Capacitor 39PF 500V Ceramic 5%

C22 47-10061 Capacitor 10µF 63V Electrolytic 20%

C23 45-39052 Capacitor 39PF 500V Ceramic 5%

C24 46-10212 Capacitor 0.001µF 100V Poly 10%

C25 45-39052 Capacitor 39PF 500V Ceramic 5%

C26 47-10061 Capacitor 10µF 63V Electrolytic 20%

C27 46-47412 Capacitor 0.47µF 100V Poly 10%

C28 46-22312 Capacitor 0.022µF 100V Poly 10%

C29 46-22461 Capacitor 0.22µF 63V Poly 10%

C3 45-39052 Capacitor 39PF 500V Ceramic 5%

C30 46-68312 Capacitor 0.068µF 100V Poly 10%

C31 46-33212 Capacitor 0.0033µF 100V Poly 10%

C32 46-33312 Capacitor 0.033µF 100V Poly 10%

C33 46-10212 Capacitor 0.001µF 100V Poly 10%

C34 46-22312 Capacitor 0.022µF 100V Poly 10%

C35 45-33113 Capacitor 330PF 1000V 10%

C36 46-10212 Capacitor 0.001µF 100V Poly 10%

C37 45-39052 Capacitor 39PF 500V Ceramic 5%

C38 46-10212 Capacitor 0.001µF 100V Poly 10%

C39 45-39052 Capacitor 39PF 500V Ceramic 5%

C4 45-39052 Capacitor 39PF 500V Ceramic 5%

C40 46-22212 Capacitor 0.0022µF 100V Poly 10%

C41 47-10061 Capacitor 10µF 63V Electrolytic 20%

C42 47-10061 Capacitor 10µF 63V Electrolytic 20%

C43 47-10061 Capacitor 10µF 63V Electrolytic 20%

C44 47-10061 Capacitor 10µF 63V Electrolytic 20%

C45 47-10061 Capacitor 10µF 63V Electrolytic 20%

C46 46-10312 Capacitor 0.01µF 100V Poly 10%

C47 46-10412 Capacitor 0.1µF 100V Poly 10%

C48 46-47212 Capacitor 0.0047µF 100V Poly 10%

C49 45-33113 Capacitor 330PF 1000V 10%

C5 47-10061 Capacitor 10µF 63V Electrolytic 20%

C50 45-39052 Capacitor 39PF 500V Ceramic 5%

C51 46-10212 Capacitor 0.001µF 100V Poly 10%

C52 47-22051 Capacitor 22µF 50V Electrolytic 20%

C53 46-10212 Capacitor 0.001µF 100V Poly 10%

C54 46-10212 Capacitor 0.001µF 100V Poly 10%

C55 46-68212 Capacitor 0.0068µF 100V Poly 10%

C56 46-10212 Capacitor 0.001µF 100V Poly 10%

C57 46-47212 Capacitor 0.0047µF 100V Poly 10%

C58 45-39052 Capacitor 39PF 500V Ceramic 5%

C59 45-39052 Capacitor 39PF 500V Ceramic 5%

C6 45-39052 Capacitor 39PF 500V Ceramic 5%

C60 45-39052 Capacitor 39PF 500V Ceramic 5%

C61 47-10061 Capacitor 10µF 63V Electrolytic 20%

C62 45-25152 Capacitor 250PF 500V Ceramic 5%

C63 45-39052 Capacitor 39PF 500V Ceramic 5%

C64 46-47212 Capacitor 0.0047µF 100V Poly 10%

C65 46-22212 Capacitor 0.0022µF 100V Poly 10%

C66 45-33113 Capacitor 330PF 1000V 10%

C67 45-25152 Capacitor 250PF 500V Ceramic 5%

C68 46-10212 Capacitor 0.001µF 100V Poly 10%

C69 45-33113 Capacitor 330PF 1000V 10%

C7 47-10061 Capacitor 10µF 63V Electrolytic 20%

C70 47-47125 Capacitor 470µF 25V Electrolytic 20%

C71 47-10061 Capacitor 10µF 63V Electrolytic 20%

C72 45-39052 Capacitor 39PF 500V Ceramic 5%

C73 46-47412 Capacitor 0.47µF 100V Poly 10%

C74 46-22312 Capacitor 0.022µF 100V Poly 10%

C75 46-22461 Capacitor 0.22µF 63V Poly 10%

C76 46-10312 Capacitor 0.01µF 100V Poly 10%

C77 46-10412 Capacitor 0.1µF 100V Poly 10%

C78 46-47212 Capacitor 0.0047µF 100V Poly 10%

C79 46-68312 Capacitor 0.068µF 100V Poly 10%

C8 45-39052 Capacitor 39PF 500V Ceramic 5%

C80 46-33212 Capacitor 0.0033µF 100V Poly 10%

C81 46-33312 Capacitor 0.033µF 100V Poly 10%

C82 46-10212 Capacitor 0.001µF 100V Poly 10%

C83 46-22312 Capacitor 0.022µF 100V Poly 10%

C84 46-10212 Capacitor 0.001µF 100V Poly 10%

C85 46-68212 Capacitor 0.0068µF 100V Poly 10%

C86 45-33113 Capacitor 330PF 1000V 10%

C87 45-39052 Capacitor 39PF 500V Ceramic 5%

C88 46-10212 Capacitor 0.001µF 100V Poly 10%

C89 47-22051 Capacitor 22µF 50V Electrolytic 20%

C9 47-10061 Capacitor 10µF 63V Electrolytic 20%

C90 47-47125 Capacitor 470µF 25V Electrolytic 20%

C91 46-47312 Capacitor 0.047µF 100V Poly 10%

C92 46-47312 Capacitor 0.047µF 100V Poly 10%

C93 45-82052 Capacitor 82PF 500V Ceramic 5%

C94 45-82052 Capacitor 82PF 500V Ceramic 5%

C95 45-82052 Capacitor 82PF 500V Ceramic 5%

C96 45-82052 Capacitor 82PF 500V Ceramic 5%

C97 45-39052 Capacitor 39PF 500V Ceramic 5%

C98 45-39052 Capacitor 39PF 500V Ceramic 5%

C99 45-39052 Capacitor 39PF 500V Ceramic 5%

D1 60-75320 LED Red small #204HD 3mm T-1.0

D10 60-75340 LED Yellow small #204YD 3mm T-1.0

D11 60-75340 LED Yellow small #204YD 3mm T-1.0

D12 60-75330 LED Green small #204GD 3mm T-1.0

D13 60-75330 LED Green small #204GD 3mm T-1.0

D14 60-75330 LED Green small #204GD 3mm T-1.0

D15 60-75330 LED Green small #204GD 3mm T-1.0

D16 60-75330 LED Green small #204GD 3mm T-1.0

D17 60-75330 LED Green small #204GD 3mm T-1.0

D18 60-75320 LED Red small #204HD 3mm T-1.0

D19 60-75340 LED Yellow small #204YD 3mm T-1.0

D2 61-19140 Diode 1N914 HI SPD 20mA 250mW

D20 60-75340 LED Yellow small #204YD 3mm T-1.0

D21 60-75340 LED Yellow small #204YD 3mm T-1.0

D22 60-75330 LED Green small #204GD 3mm T-1.0

D23 60-75330 LED Green small #204GD 3mm T-1.0

D24 60-75330 LED Green small #204GD 3mm T-1.0

D25 60-75330 LED Green small #204GD 3mm T-1.0

D26 60-75330 LED Green small #204GD 3mm T-1.0

D27 60-75330 LED Green small #204GD 3mm T-1.0

D28 60-75320 LED T-1.750" Lg Red #333HD 5mm

D29 61-19140 Diode 1N914 HI SPD 20mA 250mW

D3 61-19140 Diode 1N914 HI SPD 20mA 250mW

D30 61-19140 Diode 1N914 HI SPD 20mA 250mW

D31 61-19140 Diode 1N914 HI SPD 20mA 250mW

D32 61-19140 Diode 1N914 HI SPD 20mA 250mW

D4 61-19140 Diode 1N914 HI SPD 20mA 250mW

D5 61-19140 Diode 1N914 HI SPD 20mA 250mW

D6 61-19140 Diode 1N914 HI SPD 20mA 250mW

D7 60-75320 LED Red small #204HD 3mm T-1.0

D8 60-75320 LED Red small #204HD 3mm T-1.0

D9 60-75340 LED Yellow small #204YD 3mm T-1.0

E1 25-22203 Rot Encoder Vert 5-bit Vert

H1 23-11008 Header 8 Pin Vert 2.5mm

H2 23-11008 Header 8 Pin Vert 2.5mm

H3 23-11008 Header 8 Pin Vert 2.5mm

H4 23-11008 Header 8 Pin Vert 2.5mm

H5 23-11010 Header 10 Pin Vert 2.5mm

H6 23-11008 Header 8 Pin Vert 2.5mm

J1 21-50545 Phone Jack 1/4" Stereo H=24mm

J10 21-40022 RCA Phono Jack x4

J11 21-50345 Phone Jack 1/4" Mono H=24mm

J12 21-50345 Phone Jack 1/4" Mono H=24mm

J13 21-50345 Phone Jack 1/4" Mono H=24mm

J2 21-50545 Phone Jack 1/4" Stereo H=24mm

J3 21-50345 Phone Jack 1/4" Mono H=24mm

J31 21-40001 XLR Jack Male Vert

J32 21-40001 XLR Jack Male Ver

J33 21-40001 XLR Jack Male Ver

J4 21-50345 Phone Jack 1/4" Mono H=24mm

J5 21-50345 Phone Jack 1/4" Mono H=24mm

J6 21-50345 Phone Jack 1/4" Mono H=24mm

J7 21-50345 Phone Jack 1/4" Mono H=24mm

J8 21-50345 Phone Jack 1/4" Mono H=24mm

J9 21-50545 Phone Jack 1/4" Stereo H=24mm

P1 71-15065 Fader 25A50K 60mm HT=.215

P107 72-13168 Potentiometer B50Kx2 D Shaft 14 25F

P109 72-13168 Potentiometer B50Kx2 D Shaft 14 25F

P11 71-10333 Fader B50K C-C 30mm HT=6.5

P110 72-13168 Potentiometer B50Kx2 D Shaft 14 25F

P12 71-10333 Fader B50K C-C 30mm HT=6.5

P120 72-13168 Potentiometer B50Kx2 D Shaft 14 25F

P13 71-10333 Fader B50K C-C 30mm HT=6.5

P130 72-13168 Potentiometer B50Kx2 D Shaft 14 25F

P14 71-10333 Fader B50K C-C 30mm HT=6.5

P15 71-10333 Fader B50K C-C 30mm HT=6.5

P16 71-10333 Fader B50K C-C 30mm HT=6.5

P17 71-10333 Fader B50K C-C 30mm HT=6.5

P18 71-10333 Fader B50K C-C 30mm HT=6.5

P19 71-10333 Fader B50K C-C 30mm HT=6.5

P2 71-15065 Fader 25A50K 60mm HT=.215

P21 71-10333 Fader B50K C-C 30mm HT=6.5

P22 71-10333 Fader B50K C-C 30mm HT=6.5

P23 71-10333 Fader B50K C-C 30mm HT=6.5

P24 71-10333 Fader B50K C-C 30mm HT=6.5

P25 71-10333 Fader B50K C-C 30mm HT=6.5

P26 71-10333 Fader B50K C-C 30mm HT=6.5

P27 71-10333 Fader B50K C-C 30mm HT=6.5

P28 71-10333 Fader B50K C-C 30mm HT=6.5

P29 71-10333 Fader B50K C-C 30mm HT=6.5

P3 71-15065 Fader 25A50K 60mm HT=.215

P31 71-15065 Fader 25A50K 60mm HT=.215

P32 71-15065 Fader 25A50K 60mm HT=.215

P33 71-09253 Potentiometer B50K D Shaft 9 25F

P4 71-09253 Potentiometer B50K D Shaft 9 25F

P42 71-09253 Potentiometer B50K D Shaft 9 25F

P5 71-09253 Potentiometer B50K D Shaft 9 25F

P6 71-09253 Potentiometer B50K D Shaft 9 25F

P8 71-09253 Potentiometer B50K D Shaft 9 25F

Q1 60-17500 JFET J175 TO-92 P Chnl

Q17 60-45000 Transistor 2N54000 TO-92

Q18 60-45000 Transistor 2N54000 TO-92

Q2 60-17500 JFET J175 TO-92 P Chnl

R1 50-22055 1/4W Resistor 220K 5% Carbon

R10 50-10045 1/4W Resistor 10K 5% Carbon

R100 50-47015 1/4W Resistor 47Ω 5% Carbon

R101 50-22045 1/4W Resistor 22K 5% Carbon

R102 50-10045 1/4W Resistor 10K 5% Carbon

R103 50-22035 1/4W Resistor 2.2K 5% Carbon

R104 50-22035 1/4W Resistor 2.2K 5% Carbon

R105 50-10045 1/4W Resistor 10K 5% Carbon

R106 50-10045 1/4W Resistor 10K 5% Carbon

R107 50-24035 1/4W Resistor 2.4K 5% Carbon

R108 50-15055 1/4W Resistor 150K 5% Carbon

R109 50-22035 1/4W Resistor 2.2K 5% Carbon

R11 50-10045 1/4W Resistor 10K 5% Carbon

R110 50-15035 1/4W Resistor 1.5K 5% Carbon

R111 50-22055 1/4W Resistor 220K 5% Carbon

R112 50-10015 1/4W Resistor 10Ω 5% Carbon

R113 50-22035 1/4W Resistor 2.2K 5% Carbon

R114 50-30055 1/4W Resistor 300K 5% Carbon

R115 50-24035 1/4W Resistor 2.4K 5% Carbon

R116 50-18055 1/4W Resistor 180K 5% Carbon

R117 50-22035 1/4W Resistor 2.2K 5% Carbon

R118 50-36055 1/4W Resistor 360K 5% Carbon

R119 50-12045 1/4W Resistor 12K 5% Carbon

R12 50-10055 1/4W Resistor 100K 5% Carbon

R120 50-20035 1/4W Resistor 2K 5% Carbon

R121 50-13055 1/4W Resistor 130K 5% Carbon

R122 50-22035 1/4W Resistor 2.2K 5% Carbon

R123 50-11055 1/4W Resistor 110K 5% Carbon

R124 50-47035 1/4W Resistor 4.7K 5% Carbon

R125 50-22035 1/4W Resistor 2.2K 5% Carbon

R126 50-11055 1/4W Resistor 110K 5% Carbon

R127 50-18035 1/4W Resistor 1.8K 5% Carbon

R128 50-91045 1/4W Resistor 91K 5% Carbon

R129 50-24035 1/4W Resistor 2.4K 5% Carbon

R13 50-47025 1/4W Resistor 470Ω 5% Carbon

R130 50-22035 1/4W Resistor 2.2K 5% Carbon

R131 50-22035 1/4W Resistor 2.2K 5% Carbon

R132 50-24035 1/4W Resistor 2.4K 5% Carbon

R133 50-22055 1/4W Resistor 220K 5% Carbon

R134 50-30055 1/4W Resistor 300K 5% Carbon

R135 50-91045 1/4W Resistor 91K 5% Carbon

R136 50-10045 1/4W Resistor 10K 5% Carbon

R137 50-10045 1/4W Resistor 10K 5% Carbon

R138 50-10015 1/4W Resistor 10Ω 5% Carbon

R139 50-33035 1/4W Resistor 3.3K 5% Carbon

R14 50-10045 1/4W Resistor 10K 5% Carbon

R140 50-10045 1/4W Resistor 10K 5% Carbon

R141 50-10045 1/4W Resistor 10K 5% Carbon

R142 50-22045 1/4W Resistor 22K 5% Carbon

R143 50-22045 1/4W Resistor 22K 5% Carbon

R144 50-10055 1/4W Resistor 100K 5% Carbon

R145 50-10045 1/4W Resistor 10K 5% Carbon

R146 50-10055 1/4W Resistor 100K 5% Carbon

R147 50-10045 1/4W Resistor 10K 5% Carbon

R148 50-10065 1/4W Resistor 1M 5% Carbon

R149 50-10065 1/4W Resistor 1M 5% Carbon

R15 50-10045 1/4W Resistor 10K 5% Carbon

R150 50-10055 1/4W Resistor 100K 5% Carbon

R16 50-10045 1/4W Resistor 10K 5% Carbon

R160 50-47025 1/4W Resistor 470Ω 5% Carbon

R163 50-47025 1/4W Resistor 470Ω 5% Carbon

R167 50-12045 1/4W Resistor 12K 5% Carbon

R168 50-10045 1/4W Resistor 10K 5% Carbon

R17 59-10040 1/8W Resistor 10Kx4 SIP 2%

R18 50-47045 1/4W Resistor 47K 5% Carbon

R19 50-10045 1/4W Resistor 10K 5% Carbon

R2 50-10045 1/4W Resistor 10K 5% Carbon

R20 50-10045 1/4W Resistor 10K 5% Carbon

R200 50-47005 1/4W Resistor 4.7Ω 5% Carbon

R201 50-47005 1/4W Resistor 4.7Ω 5% Carbon

R21 50-10055 1/4W Resistor 100K 5% Carbon

R210 50-22055 1/4W Resistor 220K 5% Carbon

R22 50-10045 1/4W Resistor 10K 5% Carbon

R227 50-12045 1/4W Resistor 12K 5% Carbon

R228 50-47025 1/4W Resistor 470Ω 5% Carbon

R229 50-47025 1/4W Resistor 470Ω 5% Carbon

R23 50-10045 1/4W Resistor 10K 5% Carbon

R230 50-12045 1/4W Resistor 12K 5% Carbon

R235 50-12045 1/4W Resistor 12K 5% Carbon

R236 50-47035 1/4W Resistor 4.7K 5% Carbon

R237 50-47025 1/4W Resistor 470Ω 5% Carbon

R238 50-10045 1/4W Resistor 10K 5% Carbon

R239 50-43045 1/4W Resistor 43K 5% Carbon

R24 50-10045 1/4W Resistor 10K 5% Carbon

R240 50-47025 1/4W Resistor 470Ω 5% Carbon

R241 50-47025 1/4W Resistor 470Ω 5% Carbon

R242 50-27045 1/4W Resistor 27K 5% Carbon

R243 50-15045 1/4W Resistor 15K 5% Carbon

R245 50-68035 1/4W Resistor 6.8K 5% Carbon

R246 50-39035 1/4W Resistor 39K 5% Carbon

R247 50-18035 1/4W Resistor 1.8K 5% Carbon

R248 50-91025 1/4W Resistor 910Ω 5% Carbon

R249 50-47025 1/4W Resistor 470Ω 5% Carbon

R25 50-47025 1/4W Resistor 470Ω 5% Carbon

R250 50-27025 1/4W Resistor 270Ω 5% Carbon

R251 50-33025 1/4W Resistor 330Ω 5% Carbon

R254 50-22045 1/4W Resistor 22K 5% Carbon

R255 50-22045 1/4W Resistor 22K 5% Carbon

R26 50-22045 1/4W Resistor 22K 5% Carbon

R260 50-12045 1/4W Resistor 12K 5% Carbon

R261 50-12045 1/4W Resistor 12K 5% Carbon

R266 50-22045 1/4W Resistor 22K 5% Carbon

R267 50-22045 1/4W Resistor 22K 5% Carbon

R27 50-47025 1/4W Resistor 470Ω 5% Carbon

R28 50-22045 1/4W Resistor 22K 5% Carbon

R29 50-12045 1/4W Resistor 12K 5% Carbon

R3 50-47035 1/4W Resistor 4.7K 5% Carbon

R30 50-47045 1/4W Resistor 470Ω 5% Carbon

R303 50-00035 Jumper 0.35" 0.0Ω

R31 50-10045 1/4W Resistor 10K 5% Carbon

R32 50-33035 1/4W Resistor 3.3K 5% Carbon

R33 50-10045 1/4W Resistor 10K 5% Carbon

R34 50-10045 1/4W Resistor 10K 5% Carbon

R35 50-10045 1/4W Resistor 10K 5% Carbon

R36 50-10045 1/4W Resistor 10K 5% Carbon

R37 50-36055 1/4W Resistor 360K 5% Carbon

R38 50-10055 1/4W Resistor 100K 5% Carbon

R39 50-22045 1/4W Resistor 22K 5% Carbon

R4 50-47025 1/4W Resistor 470Ω 5% Carbon

R40 50-10045 1/4W Resistor 10K 5% Carbon

R404 50-00035 Jumper 0.35" 0.0Ω

R41 50-10045 1/4W Resistor 10K 5% Carbon

R42 50-22045 1/4W Resistor 22K 5% Carbon

R43 50-10045 1/4W Resistor 10K 5% Carbon

R44 50-22045 1/4W Resistor 22K 5% Carbon

R45 50-47025 1/4W Resistor 470Ω 5% Carbon

R46 50-47025 1/4W Resistor 470Ω 5% Carbon

R47 50-10045 1/4W Resistor 10K 5% Carbon

R48 50-10045 1/4W Resistor 10K 5% Carbon

R49 50-10045 1/4W Resistor 10K 5% Carbon

R5 50-47025 1/4W Resistor 470Ω 5% Carbon

R50 50-10045 1/4W Resistor 10K 5% Carbon

R505 50-00035 Jumper 0.35" 0.0Ω

R51 50-10045 1/4W Resistor 10K 5% Carbon

R52 50-10045 1/4W Resistor 10K 5% Carbon

R53 50-10045 1/4W Resistor 10K 5% Carbon

R54 50-10045 1/4W Resistor 10K 5% Carbon

R55 50-10045 1/4W Resistor 10K 5% Carbon

R56 50-22045 1/4W Resistor 22K 5% Carbon

R57 50-22045 1/4W Resistor 22K 5% Carbon

R58 50-15035 1/4W Resistor 1.5K 5% Carbon

R59 50-47025 1/4W Resistor 470Ω 5% Carbon

R6 50-22055 1/4W Resistor 220K 5% Carbon

R60 50-10045 1/4W Resistor 10K 5% Carbon

R606 50-47025 1/4W Resistor 470Ω 5% Carbon

R61 50-10045 1/4W Resistor 10K 5% Carbon

R62 50-10045 1/4W Resistor 10K 5% Carbon

R63 50-47025 1/4W Resistor 470Ω 5% Carbon

R64 50-22035 1/4W Resistor 2.2K 5% Carbon

R65 50-33035 1/4W Resistor 3.3K 5% Carbon

R66 50-33035 1/4W Resistor 3.3K 5% Carbon

R67 50-10045 1/4W Resistor 10K 5% Carbon

R68 50-12045 1/4W Resistor 12K 5% Carbon

R69 50-47025 1/4W Resistor 470Ω 5% Carbon

R7 50-22055 1/4W Resistor 220K 5% Carbon

R70 50-12045 1/4W Resistor 12K 5% Carbon

R71 50-10045 1/4W Resistor 10K 5% Carbon

R72 50-22045 1/4W Resistor 22K 5% Carbon

R73 50-15055 1/4W Resistor 150K 5% Carbon

R74 50-10045 1/4W Resistor 10K 5% Carbon

R75 50-10045 1/4W Resistor 10K 5% Carbon

R76 50-12045 1/4W Resistor 12K 5% Carbon

R77 50-10045 1/4W Resistor 10K 5% Carbon

R78 50-10045 1/4W Resistor 10K 5% Carbon

R79 50-18055 1/4W Resistor 180K 5% Carbon

R8 50-10045 1/4W Resistor 10K 5% Carbon

R80 50-22035 1/4W Resistor 2.2K 5% Carbon

R808 50-00035 Jumper 0.35" 0.0Ω

R81 50-36055 1/4W Resistor 360K 5% Carbon

R82 50-20035 1/4W Resistor 2K 5% Carbon

R83 50-13055 1/4W Resistor 130K 5% Carbon

R84 50-22035 1/4W Resistor 2.2K 5% Carbon

R85 50-11055 1/4W Resistor 110K 5% Carbon

R86 50-22035 1/4W Resistor 2.2K 5% Carbon

R87 50-11055 1/4W Resistor 110K 5% Carbon

R88 50-18035 1/4W Resistor 1.8K 5% Carbon

R89 50-10045 1/4W Resistor 10K 5% Carbon

R9 50-10055 1/4W Resistor 100K 5% Carbon

R90 50-10045 1/4W Resistor 10K 5% Carbon

R909 50-10015 1/4W Resistor 10Ω 5% Carbon

R91 50-10045 1/4W Resistor 10K 5% Carbon

R92 50-22045 1/4W Resistor 22K 5% Carbon

R93 50-10045 1/4W Resistor 10K 5% Carbon

R94 50-22045 1/4W Resistor 22K 5% Carbon

R95 50-22045 1/4W Resistor 22K 5% Carbon

R96 50-22045 1/4W Resistor 22K 5% Carbon

R97 50-22045 1/4W Resistor 22K 5% Carbon

R98 50-10045 1/4W Resistor 10K 5% Carbon

R99 50-47015 1/4W Resistor 47Ω 5% Carbon

R999 50-00035 Jumper 0.35" 0.0Ω

S1 25-04201 Switch 4PDT Push Vert

S2 25-04201 Switch 4PDT Push Vert

S5 25-02201 Switch DPDT Push Vert

S6 25-02201 Switch DPDT Push Vert

S7 25-02201 Switch DPDT Push Vert

S8 25-02201 Switch DPDT Push Vert

REPLACEMENT PARTS LIST

This symbol is intended to alert the user

to the presence of uninsulated “dangerous

voltage” within the product’s enclosure that

may be of sufficient magnitude to consti-

tute a risk of electric shock to persons.

This symbol is intended to alert the

user to the presence of important

operating and maintenance (servic-

ing) instructions in the literature

accompanying the appliance.

LIMITED WARRANTY

Your Carvin mixer is guaranteed against failure for 1 YEAR unless otherwise stated. Carvin will

service and supply all parts at no charge to the customer providing the unit is under warranty.

Shipping costs are the responsibility of the customer. CARVIN DOES NOT PAY FOR PARTS OR

SERVICING OTHER THAN OUR OWN. A COPY OF THE ORIGINAL INVOICE IS REQUIRED TO

VERIFY YOUR WARRANTY. Carvin assumes no responsibility for horn drivers or speakers dam-

aged by this unit. This warranty does not cover, and no liability is assumed, for damage due to:

natural disasters, accidents, abuse, loss of parts, lack of reasonable care, incorrect use, or failure

to follow instructions. This warranty is in lieu of all other warranties, expressed or implied. No

representative or person is authorized to represent or assume for Carvin any liability in connec-

tion with the sale or servicing of Carvin products.

CARVIN SHALL NOT BE LIABLE FOR INCIDEN-

TAL OR CONSEQUENTIAL DAMAGES.

When RETURNING merchandise to the factory, you may call for a return authorization number.

Describe in writing each problem. If your unit is out of warranty, you will be charged the cur-

rent FLAT RATE for parts and labor to bring your unit up to factory specifications.

MAINTAINING YOUR EQUIPMENT

Avoid spilling liquids or allowing any other foreign matter inside the unit. The panel of your

unit can be wiped from time to time with a dry or slightly damp cloth in order to remove

dust and bring back the new look.

As with all pro gear, avoid prolonged use in caustic

environments such as dust or salt air. When used in such an environment, be sure the

mixer is adequately protected by a cover.

Summary of content (6 pages)

PAGE 1
This symbol is intended to alert the user to the presence of uninsulated “dangerous voltage” within the product’s enclosure that may be of sufficient magnitude to constitute a risk of electric shock to persons. CAUTION RISK OF ELECTRIC SHOCK DO NOT OPEN This symbol is intended to alert the user to the presence of important operating and maintenance (servicing) instructions in the literature accompanying the appliance.
PAGE 2
CARVIN ENGINEERING DATA C844, C1644, C2444, C3244 4-BUS MIXER OPERATING MANUAL RECEIVING INSPECTION—read before getting started INSPECT YOUR MIXER FOR ANY DAMAGE which may have occurred during shipping. If any damage is found, please notify the shipping company and CARVIN immediately. SAVE THE CARTON & ALL PACKING MATERIALS. In the event you have to re-ship your unit, always use the original carton and packing material. This will provide the best possible protection during shipment.
PAGE 3
C844, C1644, C2444 & C3244 4-BUS MIXERS QUICK START UP If you’re like most new owners, you’re probably in a hurry to plug your mixer in and use it. Here are some brief instructions to get you going quickly. With the mixer unplugged and the unit turned off, complete the following procedures: 1. CONNECTING AC POWER TO YOUR MIXER • The mixer can be used with 120 or 240VAC (it automatically switches internally) • Use only a grounded (3 prong) power outlet to prevent a shock hazard.
PAGE 4
MASTER SECTION 15. CHANNEL MUTE SWITCH Use the MUTE switch to kill the channel. This feature saves having to reset your faders and monitor sends. 3 20. TWO STEREO 24-BIT EFFECTS The internal 24-BIT stereo processors receive signals from the EFF 1 / EFF 2 channel controls. If the adjacent PK (peak) LED flashes, reduce the level from the channel EFF 1 / EFF 16. CHANNEL PFL SWITCH 2 control.
PAGE 5
STEREO LIVE SOUND SYSTEM In a live sound reinforcement system, the input signals to the mixer will come from the microphones and instruments. Each microphone or instrument to be amplified by the system must be connected to one of the mixing console inputs. It is preferred to have as many of the stage instruments as possible plugged into the mixer. This allows for the best overall control of the instruments as they are mixed together and then amplified by the system.
PAGE 6
INSERTS AND DIRECT OUTS 1/2 INSERT HALF INSERT DIRECT OUT FULL INSERT FULL INSERT The insert jack is a Tip Ring Sleeve (TRS) 1/4” phone jack, where the tip is the send, the ring is the return and the sleeve is ground. When used as an insert point or in full insert mode, the channel is opened up to allow an external piece of equipment to be inserted into the channels signal path.