P rofes s i o n a l Su p p l i e s CONVEYOR TOASTER MANUAL (*688.200 / *688.300) SAVE THESE INSTRUCTIONS This manual contains important safety information concerning the maintenance, use and operation of this product. Failure to follow the instructions contained in this manual may result in serious injury. If you are unable to understand the contents of this manual, please bring it to the attention of your supervisor.
TABLE OF CONTENTS Owner Information .........................................................................................................2 General ....................................................................................................................2 Warranty Information .................................................................................................2 Important Safety Information ...........................................................................................
IMPORTANT SAFETY INFORMATION Throughout this manual, you will find the following safety words that signify important safety issues with regards to operating or maintaining the equipment. WARNING WARNING GENERAL WARNING. Indicates information important to the proper operation of the equipment. Failure to observe may result in damage to the equipment and/or severe bodily injury or death. ELECTRIC WARNING. Indicates information relating to possible shock hazard.
i CAUTIONS i Locate the unit at the proper counter height, in an area that is convenient for use. The location should be level to prevent the unit or its contents from accidentally falling, and strong enough to support the weight of the unit. i Do not place anything on top of the toaster; doing so could damage toaster or subject personnel to possible injury. i The toasting of coated or buttered products such as garlic bread, cheese sandwiches and sweet rolls is NOT recommended.
INSTALLATION UNPACKING 1. Remove unit and all packing materials from shipping carton. 2. Open the large box. Remove all packing materials and protective covering from the unit and parts. 3. Remove tape from discharge chute, crumb tray and toast collector pan. 4. If unit is not level, use 9/16 “ (14cm) open-end wrench to adjust the foot of each leg until unit is level. LOCATION CAUTION Do not locate the toaster in an area subject to excessive temperatures or grease from grills, fryers, etc.
SET-UP i CAUTION Unit is not weatherproof. For safe and proper operation locate the unit indoors where the ambient air temperature is a minimum of 70°F (21 °C) and a maximum of 85°F (25°C). i CAUTION The toasting of coated or buttered products such as garlic bread, cheese sandwiches and sweet rolls is NOT recommended. Residue will reduce toaster performance and could possibly ignite inside the toaster.
OPERATION FOR MODEL EQUPPED WITH ROCKER SWITCH 1. Plug toaster into a properly grounded electrical outlet of the correct voltage, size and puge configuration. (See the Rating Label) 2. Place the On/Off switch in the On position. 3. Turn the Color Control to the lightest position while the unit heats up. (Note: Allow approximately 15 to 21 minutes for a warm-up period.) 4.
MAINTENANCE GENERAL The Electric Conveyor Toasters are designed for maximum durability and performance, with minimum maintenance. i WARNING TO AVOID ANY INJURY, TURN THE POWER SWITCH OFF, UNPLUG THE UNIT FORM THE POWER SOURCE AND ALLOW TO COOL BEFOR PERFORMING ANY MAINTENANCE. CLEANING EXTERIOR To preserve the bright finish of the unit, it is recommended that the exterior surfaces be wiped daily with a damp cloth. Stubborn stains may be removed with a good stainless steel cleaner or non-abrasive cleaner.