User's Manual

Index
C
Cat Data Link - Test .............................................37
Diagnostic Trouble Code Procedure ..................37
Theft Deterrent Module ECM ............................37
Circuit Tests........................................................37
Connector Contact Description.............................59
ECM Pull Down Voltage ...................................59
ECM Pull Up Voltage........................................59
Input/Output ....................................................60
Inputs .............................................................59
Outputs...........................................................60
Connector Locations ...........................................17
D
Data Links ..........................................................16
Determining Diagnostic Trouble Codes .................24
Diagnostic Capabilities ........................................18
The Cat
®
Electronic Technician (Cat ET) Service
Tool...............................................................19
Diagnostic Operation...........................................10
Active Diagnostics ........................................... 11
Logged Diagnostics ......................................... 11
Diagnostic Trouble Codes.............................. 24–25
Component Identifier (CID) ...............................25
Detailed FMI Explanations................................25
Diagnostic Codes.............................................29
Failure Mode Identifier (FMI).............................25
Module Identifier (MID).....................................25
Troubleshooting Procedures.............................27
E
ECM - Configure .................................................52
Cat
®
Electronic Technician (Cat ET) Service Tool
Configuration Procedure.................................52
ECM - Replace ...................................................52
ECM Output Driver - Test .....................................39
Diagnostic Trouble Code Procedure ..................40
Theft Deterrent Module ECM ............................39
ECM Software - Install .........................................52
Electrical Connector - Inspect...............................43
Guidelines.......................................................43
Important Safety Information.............................43
Tests...............................................................43
Electrical Power Supply - Test ..............................46
Diagnostic Trouble Code Procedure ..................47
Theft Deterrent Module ECM ............................46
Electronic Control Module (ECM) .........................14
ECM Inputs .....................................................15
ECM Outputs...................................................15
FCC NOTICE ..................................................14
Industry Canada Notice to Users.......................14
Emerging Symptom Information ...........................30
Engine Does Not Crank and Status Indicator Is
Green ...............................................................31
Engine Does Not Start and Status Indicator Is
Continuously Red ..............................................34
Events................................................................ 11
Cat
®
Electronic Technician (Cat ET) ................. 11
Logged Events ................................................13
F
Factory Password - Obtain...................................79
Internet ...........................................................80
Telephone Help Line ........................................85
G
General Information ...................................4, 17, 61
Cat
®
Electronic Key ........................................61
Security Management using Cat
®
Electronic
Technician (Cat
®
ET).....................................61
Glossary of Terms ...............................................91
I
Important Safety Information ..................................2
Introduction ........................................................17
K
Key - Program.....................................................63
“Fleet/Key Configuration” .................................70
Programming with a Service Tool ......................63
Key Information.....................................................8
Access Level .....................................................9
Expiration Date..................................................9
Security ID ........................................................9
Security Type ....................................................9
L
Lost Key (MSS)...................................................36
Lost Key (MSS3S) ...........................................36
M
Machine Preparation for Troubleshooting..............22
General Procedure ..........................................22
Warnings.........................................................22
N
Normal Operation..................................................7
Armed...............................................................7
Disarm ..............................................................7
Reading the ID of a Key......................................7
Timeouts ...........................................................7
O
Operation of Status Indicator..................................7
Status Indicator .................................................8
P
Product Identification Number - Program...............61
Protected Functions ............................................13
UENR7061 93
Index Section