Operation Manual NI60A 04-2002
The Hot Water Dispenser is shipped, from the factory, with the Heater Switch in the "OFF" position. DO NOT turn the heater switch ON until the unit is primed with water. The heater switch is located at the lower back of the unit. WATER INLET CONNECTION : The Hot Water Dispenser is to be installed to comply with all applicable Federal, State and Local plumbing codes.
Hot Water Dispenser - HWD2 Tomlinson faucet Manual dispense Electrical Specifications MODEL NO VOLTS WATTS PHASE & CYCLES HWD2 120 1700 1 PH. 50/60 Hz P5-15 R5-15 240 3000 1 PH. 50/60 Hz P6-15 R6-15 POWER CORD (included) RECEPTACLE Export units add "X" to Model No. Specify Voltage and type of line cord required. Water Connection Water pressure: 20 - 90 PSI (69 - 621 KPA) Supplied with ¼ OD male flare fitting Operational MODEL NO VOLTS HWD2 120 (1.7 KW) 240 (3.
1 2 3 20 19 4 5 6 7 18 8 23 9 10 17 11 16 12 15 13 14 21 22 1 2 FAUCET FAUCET SHANK 80234 77203 3 4 5 POWER SWITCH POWER LIGHT - RED L069A C165A C260A 6 7 8 HEATER LIGHT - AMBER SILICONE SEAL 12mm (0.466 I.D.
Hot Water Dispenser - HWD3 Tomlinson faucet Manual dispense Electrical Specifications MODEL NO VOLTS WATTS PHASE & CYCLES POWER CORD (included) RECEPTACLE HWD3 120 1700 1 PH. 50/60 Hz P5-15 R5-15 240 3000 1 PH. 50/60 Hz P6-15 R6-15 Export units add "X" to Model No. Specify Voltage and type of line cord required. Water Connection Water pressure: 20 - 90 PSI (69 - 621 KPA) Supplied with ¼ OD male flare fitting Operational MODEL NO VOLTS HWD3 120 (1.7 KW) 240 (3.
Hot Water Dispenser - HWD5 Tomlinson faucet Manual dispense Electrical Specifications MODEL NO VOLTS WATTS PHASE & CYCLES HWD5 120 1700 1 PH. 50/60 Hz P5-15 R5-15 240 3000 1 PH. 50/60 Hz P6-15 R6-15 240 6000 1 PH. 50/60 Hz P6-30 R6-30 POWER CORD (included) RECEPTACLE Export units add "X" to Model No. Specify Voltage and type of line cord required.
22 1 8 2 21 9 3 20 4 19 5 10 6 18 7 11 3 17 16 12 7 13 15 14 23 1 2 3 24 25 HEATER ELEMENT, 120V 1700W HEATER ELEMENT, 240V 3000W THERMOSTAT G267A G266A L532A 4 HI-LIMIT 220° CUTOUT L573A 5 6 FLOAT SWITCH L499A K402Q 7 8 9 10 11 12 13 LEVEL CONTROL PROBE SILICONE HOSE 3/8ID x 16" LG PILOT LIGHT "HEATING" POWER SWITCH PILOT LIGHT "READY" TEACH-ME TIMER SILICONE HOSE 3/8ID x 16" LG DRIP TRAY PAN M857A C165A L155A C072A L576A M857A SA72A Page -10- DRIP TRAY GRILL CONTACTOR, 2 POLE
PROGRAMMABLE TIMER "TEACH ME" ADJUSTMENTS This timer can be programmed from the push buttons to dispense different volumes of hot water. PROGRAMMING INSTRUCTIONS FOR AUTOMATIC DISPENSE 1. Turn Power Switch ON. 2. PRESS and HOLD [red] STOP Button with one hand. 3. PRESS and HOLD [green] DISPENSE Button with other hand. 4. RELEASE [red] STOP Button ONLY. 5. Continue to HOLD [green] DISPENSE Button for 5 SECONDS, then RELEASE. 6. PRESS and RELEASE [green] DISPENSE Button. Product begins dispensing.
Hot Water Dispenser - HWD3PC Push Button with Portion control or Manual dispense Electrical Specifications MODEL NO VOLTS WATTS PHASE & CYCLES 120 1700 1 PH. 50/60 Hz P5-15 R5-15 240 3000 1 PH. 50/60 Hz P6-15 R6-15 HWD3PC POWER CORD (included) RECEPTACLE Export units add "X" to Model No. Specify Voltage and type of line cord required.
Hot Water Dispenser - HWD5PC Push Button with Portion control or Manual dispense Electrical Specifications MODEL NO VOLTS WATTS PHASE & CYCLES 120 1700 1 PH. 50/60 Hz P5-15 R5-15 240 3000 1 PH. 50/60 Hz P6-15 R6-15 240 6000 1 PH. 50/60 Hz P6-30 R6-30 HWD5PC POWER CORD (included) RECEPTACLE Export units add "X" to Model No. Specify Voltage and type of line cord required.
8 1 9 2 3 4 5 10 6 11 18 7 3 17 16 12 13 15 14 7 19 20 21 1 HEATER ELEMENT, 120V 1700W G267A 14 DRIP TRAY GRILL SA73A 2 HEATER ELEMENT, 230V 6000W THERMOSTAT G281A L532A L573A 15 CONTACTOR, 2 POLE 30/40 AMP, 120V SILICONE HOSE 3/8ID x 16" LG B177A M857A M461A 3 4 5 6 7 8 9 10 11 12 13 HI-LIMIT 220° CUTOUT FLOAT SWITCH LEVEL CONTROL PROBE L499A K402Q SILICONE HOSE 3/8ID x 16" LG PILOT LIGHT "HEATING" M857A C165A POWER SWITCH FAUCET SHANK SUB-ASSEMBLY SILICONE HOSE 3/8ID x 16" LG
L1 N L1 HEATER LIGHT WHT L1 HEATER SWITCH L1 POWER LIGHT POWER SWITCH WHT BLK N L1 CECILWARE CORPORATION
CECILWARE CORPORATION
HI-LIMIT THERMOSTAT CONTACTOR HEATER SW HEATING WATER INLET VALVE LEVEL CONTROL FLOAT SWITCH WATER LEVEL PROBE CECILWARE CORPORATION